MENU

Safety Recalls 2006

Launch DateRecalls NumberMakeRecalls Model InformationConcernDefectRemedyVehicle NumbersManufacturer RefModelVIN StartVIN EndBuild StartBuild End
Search
Launch Date
Search
Recalls Number
Search
Make
Search
Recalls Model Information
Search
Concern
Search
Defect
Search
Remedy
Search
Vehicle Numbers
Search
Manufacturer Ref
Search
Model
Search
VIN Start
Search
VIN End
Search
Build Start
Search
Build End
01/01/06RCOMP/2006/001CAROSPEEDCAROSPEEDCONTROL SYSTEM BALL JOINT MAY FAIL There is a concern that the Carospeed control may have been fitted incorrectly in that the ball joint may not be fully tight which can lead to a failure of the service brake. To address the concern the manufacturer has instructed conversion companies to ensure that the subject ball joint is tight. Additionally technicians will visit customers to validate their particular installation.48CAROSPEED
03/01/06R/2005/167SAAB9-3REAR AXLE HUB MAY NOT BE TO SPECIFICATIONThe hardening process applied to the rear wheel bearing inner ring may be incorrect. There is a possibility that a rumbling noise may become apparent which if not checked could in extreme circumstances result in the detachment of the hub and severely impaired road holding/handling.Recall the vehicles that are likely to be affected and check the date stamp on the rear wheel hubs. Where necessary replace the hub bearing assembly.571150229-300000006*102*420500000006*102*7871
03/01/06RM/2005/030KAWASAKIKAF 400FRONT SUSPENSION MAY COLLAPSE AND LOSS OF STEERING CONTROLThere is a possibility that the front lower suspension swivel joints may fracture. If this occurs steering control will be lost.Recall the vehicles that are likely to be affected and replace both of the front lower suspension swivel joints.14106-101KAF400JK1AF400BBB600001`JK1AF400BBB600501
09/01/06R/2005/149SUZUKIGrand VitaraRISK OF FIREThere is a risk of damage (shorting) between the cable connections and glow plugs due to insufficient torque on the connector securing nuts on the relay end posts.Recall affected vehicles check the security of the glow plug relay cables and if required replace the glow plug relay.5884601VITARAJSAFTD82V00100030 JSAFTD83V00100027 JSAFTB83V00100015 JSAHTX83V00200033 JSAHTX83V00300002JSAFTD82V00130521 JSAFTD83V00112033 JSAFTB83V00201418 JSAHTX83V00201418 JSAHTX83V0030306522/09/200025/02/2004
09/01/06R/2006/005PEUGEOT307 LHDAIRBAG MAY DEPLOY INADVERTENTLYThe incorrect fixing of the left hand curtain airbag can lead to incorrect deployment in the case of a left hand side impact or frontal impact with a high degree of angular bias to the left.Recall the vehicles that are likely to be affected and re-fix the airbag correctly.1X9B307
09/01/06R/2006/003DENNISENVIRO 300STEERING COLUMN MAY FOULIt has been identified that the steering column universal joint may make rubbing contact with the column's outer casing. It is not thought that this will cause the steering to lock up.Recalled vehicles will have a small part of the column retaining lug removed.119ENVIRO 30001/05/200230/11/2005
12/01/06RM/2006/004SUZUKI M/C'S -KJM IMPORTSVL800 AND VZ800ENGINE MAY CUT OUTIt has been identified that the routing of the wiring harness from the ignition switch passes over some control cables which can place the connector plug within the harness under a pulling strain. Over a period of time the connector may work loose and separate which can lead to the engine cutting out and the loss of electrical power to the lights. Recalled machines will have the wiring harness re-routed and the ignition switch will be replaced if found to be damaged.34
16/01/06RSPV/2006/002SUZUKI MOTORCYCLESLT-A700X K5 - KING QUADPOSSIBLE LOSS OF DIRECTIONAL CONTROLIt has been identified that if the steering tie rod ends have been incorrectly aligned either at build or in use the seal which protects the ball-joint may be forced out of position allowing the ingress of contaminants ultimately resulting in early failure of the joint with possible loss of directional control.Recalled machines will have the left and right hand steering tie rod ends replaced with those of a different design.143R05/12LT-A700XJSAAP41A*52102348JSAAP41A*5212496301/01/200531/12/2005
16/01/06R/2006/106UNVI SAESKER TOURING COACHBRAKES MAY APPLY INADVERTANTLYIf the wheel chair lift sensors signal that the lift is not in the stowed position the service brakes apply.Recall the vehicles that are likely to be affected to disconnect this interlock and restore the braking system to factory standard. The lift is switched off after it has been used by means of an illuminated switch within reach of the driver that is standard fitment to this vehicle.2ESKER TOURING COACH
16/01/06RM/2006/002SUZUKI MOTORCYCLESAN650 K5 - BURGMAN AND AN5650A K5 - BURGMANFUEL TANK MAY LEAKIt has been identified that the retaining ring which fastens the fuel pump to the fuel tank may have been incorrectly fitted. This could result in fuel leaking from a full tank if the machine were to be placed on the side stand.Recalled machines will have the original fuel pump retainer replaced with a new part.30R05/13AN650JS1BU111200100489JS1BU11120010050801/01/200531/12/2005
16/01/06RM/2006/002SUZUKI MOTORCYCLESAN650 K5 - BURGMAN AND AN5650A K5 - BURGMANFUEL TANK MAY LEAKIt has been identified that the retaining ring which fastens the fuel pump to the fuel tank may have been incorrectly fitted. This could result in fuel leaking from a full tank if the machine were to be placed on the side stand.Recalled machines will have the original fuel pump retainer replaced with a new part.30R05/13AN650JS1BU132200100101JS1BU13220010011401/01/200531/12/2005
17/01/06R/2005/182RENAULTMODUS (WITH D.P.O AUTOMATIC TRANSMISSION AND 1.6 - 16 v ENGINEGEARBOX MAY DISENGAGE FROM THE PARK POSITION Due to the possible non-conformity of the gearbox control there is a risk that the transmission may disengage from the parking position (without the footbrake having first been applied)Recalled vehicles will have the conformity of the gearbox control checked and replaced as necessary.55MODUS10/11/200425/11/2004
17/01/06RM/2005/026APRILIAMX125BRAKE CALLIPER MOUNTING SCREWS MAY BECOME LOOSEThe bolts retaining the brake caliper carrier plates may become loose. Recall the machines that are likely to be affected replace the brake caliper carrier plates and fixings.239MX125
18/01/06RM/2006/003SUZUKI M/C'S - D&K IMPORTVL800 AND VZ800ENGINE MAY CUT OUTIt has been identified that the routing of the wiring harness from the ignition switch passes over some control cables which can place the connector plug within the harness under a pulling strain. Over a period of time; the connector may work loose and separate which can lead to the engine cutting out and the loss of electrical power to the lights. Recalled machines will have the wiring harness re-routed and the ignition switch will be replaced if found to be damaged.26
19/01/06R/2006/007PORSCHE911 CARRERA S (997)WELD SEAMS ON THE EXHAUST TAILPIPE MAY FAILThe welded seams on the exhaust tailpipe may fail. This can cause rattling noises while driving and can result in the loss of the exhaust tailpipe if the driver continues to drive the vehicle.Recall the vehicles that are likely to be affected and replace the exhaust tailpipes with modified units.2566A601911 CARRERA
19/01/06R/2006/046MERCEDES BENZC E AND S CLASSENGINE MAY REVERT TO LIMP HOME MODEThe differential pressure sensor for the diesel particulate filter can fail due to contamination of the protective gel layer by exhaust gases. This will result in the car reverting to limp home mode (restricted engine speed).Replace the differential pressure sensor with the latest modified type.4869P059C CLASS
19/01/06R/2006/046MERCEDES BENZC E AND S CLASSENGINE MAY REVERT TO LIMP HOME MODEThe differential pressure sensor for the diesel particulate filter can fail due to contamination of the protective gel layer by exhaust gases. This will result in the car reverting to limp home mode (restricted engine speed).Replace the differential pressure sensor with the latest modified type.4869P059E CLASS
19/01/06R/2006/046MERCEDES BENZC E AND S CLASSENGINE MAY REVERT TO LIMP HOME MODEThe differential pressure sensor for the diesel particulate filter can fail due to contamination of the protective gel layer by exhaust gases. This will result in the car reverting to limp home mode (restricted engine speed).Replace the differential pressure sensor with the latest modified type.4869P059S CLASS
24/01/06R/2006/014PORSCHEBOXTER BOXTER S (987) 911 CARRERA CARRERA S (997) AND CAYMAN SPARKING BRAKE MAY FAILA bearing flange on the parking brake lever is likely to break. If this occurs the parking brake will be ineffective.Recall the vehicles that are likely to be affected and replace the parking brake lever assembly.111A603911 CARRERA22/11/200513/12/2005
24/01/06R/2006/014PORSCHEBOXTER BOXTER S (987) 911 CARRERA CARRERA S (997) AND CAYMAN SPARKING BRAKE MAY FAILA bearing flange on the parking brake lever is likely to break. If this occurs the parking brake will be ineffective.Recall the vehicles that are likely to be affected and replace the parking brake lever assembly.111A603CAYMAN 22/11/200513/12/2005
24/01/06R/2006/014PORSCHEBOXTER BOXTER S (987) 911 CARRERA CARRERA S (997) AND CAYMAN SPARKING BRAKE MAY FAILA bearing flange on the parking brake lever is likely to break. If this occurs the parking brake will be ineffective.Recall the vehicles that are likely to be affected and replace the parking brake lever assembly.111A603BOXSTER22/11/200513/12/2005
25/01/06R/2005/128OUGHTRED & HARRISON CITROEN BERLINGO (DISABLED ACCESSABLE)REAR SUSPENSION MAY COLLAPSEThe rear axle front mounting distance piece may fracture with the result that the rear suspension may collapse.Recall likely to be affected vehicles and fit a modified distance piece.37BERLINGO
26/01/06R/2006/011CITROENC8FUEL MAY LEAK INTO ENGINEA potential fault within the engine management system could cause an internal engine fuel leak via one or more of the injectors following engine switch off. The engine would then not restart because of the excess fuel present in the inlet manifold or cylinders.Recalled vehicles will have the engine management unit software updated.502XWNC8VF7******13003950VF7******1307056725/04/200210/04/2003
01/02/06R/2006/024BENTLEY MOTOR CARSARNARGE T R AND RLWHEEL FIXING BOLTS MAY LOOSENDue to the possibility of the road wheels having an incorrect finish the potential exists for the wheel fixing bolts to loosen. This defect could lead to the road wheel becoming detached from the hub.Affected vehicles will have all the road wheels including the spare (if it is a full size wheel) and all the wheel fixing bolts replaced55RE06/01ARNAGE01/01/200431/05/2005
01/02/06RM/2006/005SUZUKI MOTORCYCLESVL800 AND VZ800ENGINE MAY CUT OUTAn ignition wiring connector that is located under the fuel tank may separate causing the engine to fail.Recall the machines that are likely to be affected and re-route the ignition wiring. Where necessary replace the wiring harness.565VL800JS1BM111200101358JS1BM111200101388
01/02/06RM/2006/005SUZUKI MOTORCYCLESVL800 AND VZ800ENGINE MAY CUT OUTAn ignition wiring connector that is located under the fuel tank may separate causing the engine to fail.Recall the machines that are likely to be affected and re-route the ignition wiring. Where necessary replace the wiring harness.565VL800JS1BM111200101117JS1BM111200101357
01/02/06RM/2006/005SUZUKI MOTORCYCLESVL800 AND VZ800ENGINE MAY CUT OUTAn ignition wiring connector that is located under the fuel tank may separate causing the engine to fail.Recall the machines that are likely to be affected and re-route the ignition wiring. Where necessary replace the wiring harness.565VZ800JS1B4111200100271JS1B4111200100305
01/02/06RM/2006/005SUZUKI MOTORCYCLESVL800 AND VZ800ENGINE MAY CUT OUTAn ignition wiring connector that is located under the fuel tank may separate causing the engine to fail.Recall the machines that are likely to be affected and re-route the ignition wiring. Where necessary replace the wiring harness.565VZ800JS1B4111200100002JS1B4111200100270
01/02/06RM/2006/001SUZUKI MOTORCYCLESAY50A K5 - KATANA AND AY50A K6 - KATANAPOSSIBLE LOSS OF BRAKING AT REAR WHEELUnder certain circumstances the rear brake hydraulic hose can contact the rear tyre sidewall causing the hose to wear and in extreme cases leak hydraulic fluid which could result in loss of braking to the rear wheel. Recalled machines will be fitted with an additional rear brake hose guide and the rear brake hose will be inspected and renewed; in the case of any tyre contact damage. 553AY50VTTAAL11200100001VTTAAL1120010072101/01/200531/12/2005
01/02/06RM/2006/001SUZUKI MOTORCYCLESAY50A K5 - KATANA AND AY50A K6 - KATANAPOSSIBLE LOSS OF BRAKING AT REAR WHEELUnder certain circumstances the rear brake hydraulic hose can contact the rear tyre sidewall causing the hose to wear and in extreme cases leak hydraulic fluid which could result in loss of braking to the rear wheel. Recalled machines will be fitted with an additional rear brake hose guide and the rear brake hose will be inspected and renewed; in the case of any tyre contact damage. 553AY50VTTAAL11200100722`VTTAAL1120010090101/01/200531/12/2005
07/02/06R/2005/184IVECOSTRALISPROPSHAFT MAY CONTACT AXLE BEAMUnder certain circumstances it is possible that the distance between the propshaft and the second front axle may be insufficient. Should axle/propshaft contact be made damage to one or both of these components might ensue.Recalled vehicles will have the clearance between the propshaft and the second front axle beam checked. Should the clearance be outside of the specified parameters the suspension will be adjusted.82RCV22STRALISWJMS2NSK004292511WJMS2NUH00430118327/01/200514/07/2005
08/02/06RM/2005/028BARRUSMALAGUTI DRAKONREAR WHEEL MAY LOCK UPThe rear sprocket can work loose resulting in sprocket and chain jamming between the rear wheel and the swinging arm. This could result in the rear wheel skidding and possible loss of control.Recalled machines will have the existing socket head screws replaced with longer hexagon bolts and secured in position with a lock ring.150DRAKON
08/02/06R/2005/186LOTUSELISE AND EXIGEGEAR LEVER MAY BREAKIt has been found that there is a small risk that the gear lever may break if subjected to high handling force.Recall the likely to be affected vehicles and where necessary replace the gear lever and associated parts.7642006/01RELISE21/01/200408/02/2005
08/02/06R/2005/186LOTUSELISE AND EXIGEGEAR LEVER MAY BREAKIt has been found that there is a small risk that the gear lever may break if subjected to high handling force.Recall the likely to be affected vehicles and where necessary replace the gear lever and associated parts.7642006/01REXIGE21/01/200408/02/2005
08/02/06R/2006/021ASTON MARTINV8 VANTAGEENGINE MAY NOT STARTThe engine may not start because the power train to chassis primary earth stud may have intermittent high resistance. This condition may occur when electrical items that draw high current are utilised in which case the electrical path could route through the rear braided hoses causing them to heat up and possibly melt leading to a soft pedal illumination of the brake warning lamp and poor starting.Recall the vehicles that are likely to be affected so the primary earth stud can be moved to a new location and fit a secondary earth strap between the transmission and chassis.125SAR012VANTAGE23/05/200527/10/2005
08/02/06R/2006/018CITROENC3 PLURIELSPARE WHEEL TYRE PRESSURE INCORRECTLY STATED ON INFORMATION LABELOn subject vehicles the indication of 2.5 bar pressure for the spare wheel which can be found on a label affixed to the left hand door pillar is incorrect for the vehicle specification. Recalled vehicles will have a replacement label affixed to the vehicle which will indicate the correct spare tyre pressure i.e. 4.2 bar. It should be noted that at manufacture the tyre was inflated to the correct pressure however as a precaution the pressure of the spare wheel will be checked.6324XXDPLURIELVF7******28000180VF7*****28006616601/07/200230/04/2003
13/02/06R/2006/082VOLVO TRUCKFH/FMSTEERING MAY FAILIt has been identified that a number of vehicles may have left the assembly plant without a split pin in the track rod end securing nut. In this condition it is a possibility that the securing nuts may work loose.Recalled vehicles will be checked for the presence of the split pins and if theses are in place no additional work will be carried out. If the spilt pins are found to be missing the assembly will be dismantled and then re-torqued ensuring that the split pins are in place. 5C0654FM
16/02/06R/2005/121SEDDON ATKINSONM5 Pacer and R5 RigidCONCERN THAT LINK BETWEEN TWO FUSES MAY OVER HEATInsufficient contact surface area on the removable link between the two 30 amp windscreen fuses may cause overheating of the fuses.Replace with new quality assured fuse link.1271N518260CSD05/09/200102/02/2005
16/02/06R/2005/121SEDDON ATKINSONM5 Pacer and R5 RigidCONCERN THAT LINK BETWEEN TWO FUSES MAY OVER HEATInsufficient contact surface area on the removable link between the two 30 amp windscreen fuses may cause overheating of the fuses.Replace with new quality assured fuse link.1271R518240NSD05/09/200102/02/2005
16/02/06R/2005/121SEDDON ATKINSONM5 Pacer and R5 RigidCONCERN THAT LINK BETWEEN TWO FUSES MAY OVER HEATInsufficient contact surface area on the removable link between the two 30 amp windscreen fuses may cause overheating of the fuses.Replace with new quality assured fuse link.1271N518240NSD05/09/200102/02/2005
16/02/06R/2005/121SEDDON ATKINSONM5 Pacer and R5 RigidCONCERN THAT LINK BETWEEN TWO FUSES MAY OVER HEATInsufficient contact surface area on the removable link between the two 30 amp windscreen fuses may cause overheating of the fuses.Replace with new quality assured fuse link.1271N523275NML05/09/200102/02/2005
16/02/06R/2005/121SEDDON ATKINSONM5 Pacer and R5 RigidCONCERN THAT LINK BETWEEN TWO FUSES MAY OVER HEATInsufficient contact surface area on the removable link between the two 30 amp windscreen fuses may cause overheating of the fuses.Replace with new quality assured fuse link.1271M523275NML05/09/200102/02/2005
16/02/06R/2005/121SEDDON ATKINSONM5 Pacer and R5 RigidCONCERN THAT LINK BETWEEN TWO FUSES MAY OVER HEATInsufficient contact surface area on the removable link between the two 30 amp windscreen fuses may cause overheating of the fuses.Replace with new quality assured fuse link.1271N523260CML05/09/200102/02/2005
16/02/06R/2005/121SEDDON ATKINSONM5 Pacer and R5 RigidCONCERN THAT LINK BETWEEN TWO FUSES MAY OVER HEATInsufficient contact surface area on the removable link between the two 30 amp windscreen fuses may cause overheating of the fuses.Replace with new quality assured fuse link.1271M526275NDD05/09/200102/02/2005
16/02/06R/2005/121SEDDON ATKINSONM5 Pacer and R5 RigidCONCERN THAT LINK BETWEEN TWO FUSES MAY OVER HEATInsufficient contact surface area on the removable link between the two 30 amp windscreen fuses may cause overheating of the fuses.Replace with new quality assured fuse link.1271M526260CDD05/09/200102/02/2005
16/02/06R/2005/121SEDDON ATKINSONM5 Pacer and R5 RigidCONCERN THAT LINK BETWEEN TWO FUSES MAY OVER HEATInsufficient contact surface area on the removable link between the two 30 amp windscreen fuses may cause overheating of the fuses.Replace with new quality assured fuse link.1271R518275NSD05/09/200502/02/2005
16/02/06R/2005/121SEDDON ATKINSONM5 Pacer and R5 RigidCONCERN THAT LINK BETWEEN TWO FUSES MAY OVER HEATInsufficient contact surface area on the removable link between the two 30 amp windscreen fuses may cause overheating of the fuses.Replace with new quality assured fuse link.1271M526260CMS05/09/200102/02/2005
16/02/06R/2005/121SEDDON ATKINSONM5 Pacer and R5 RigidCONCERN THAT LINK BETWEEN TWO FUSES MAY OVER HEATInsufficient contact surface area on the removable link between the two 30 amp windscreen fuses may cause overheating of the fuses.Replace with new quality assured fuse link.1271N518275NSD05/09/200102/02/2005
16/02/06R/2005/121SEDDON ATKINSONM5 Pacer and R5 RigidCONCERN THAT LINK BETWEEN TWO FUSES MAY OVER HEATInsufficient contact surface area on the removable link between the two 30 amp windscreen fuses may cause overheating of the fuses.Replace with new quality assured fuse link.1271S518240NSD05/09/200102/02/2005
16/02/06R/2005/121SEDDON ATKINSONM5 Pacer and R5 RigidCONCERN THAT LINK BETWEEN TWO FUSES MAY OVER HEATInsufficient contact surface area on the removable link between the two 30 amp windscreen fuses may cause overheating of the fuses.Replace with new quality assured fuse link.1271M518240NSD05/09/200102/02/2005
16/02/06R/2005/121SEDDON ATKINSONM5 Pacer and R5 RigidCONCERN THAT LINK BETWEEN TWO FUSES MAY OVER HEATInsufficient contact surface area on the removable link between the two 30 amp windscreen fuses may cause overheating of the fuses.Replace with new quality assured fuse link.1271M518275NSD05/09/200102/02/2005
16/02/06R/2005/121SEDDON ATKINSONM5 Pacer and R5 RigidCONCERN THAT LINK BETWEEN TWO FUSES MAY OVER HEATInsufficient contact surface area on the removable link between the two 30 amp windscreen fuses may cause overheating of the fuses.Replace with new quality assured fuse link.1271M526275NMS05/09/200102/02/2005
22/02/06R/2006/040PEUGEOT407FUEL MAY LEAKDue to a potential fault in the engine management system an internal engine fuel leak via the injectors may occur following switching off. This would result in the engine failing to restart due to excess fuel being present in the inlet manifold or cylinders.To address the issue recalled vehicles will receive an engine management download.319X7V407
23/02/06R/2006/041PEUGEOT307 406 607 and 807FUEL MAY LEAKDue to a potential fault in the engine management system an internal engine fuel leak via the injectors may occur following switching off. This would result in the engine failing to restart due to excess fuel being present in the inlet manifold or cylinders.To address the issue recalled vehicles will receive an engine management download.4338X9D406
23/02/06R/2006/041PEUGEOT307 406 607 and 807FUEL MAY LEAKDue to a potential fault in the engine management system an internal engine fuel leak via the injectors may occur following switching off. This would result in the engine failing to restart due to excess fuel being present in the inlet manifold or cylinders.To address the issue recalled vehicles will receive an engine management download.4338X9D307
23/02/06R/2006/041PEUGEOT307 406 607 and 807FUEL MAY LEAKDue to a potential fault in the engine management system an internal engine fuel leak via the injectors may occur following switching off. This would result in the engine failing to restart due to excess fuel being present in the inlet manifold or cylinders.To address the issue recalled vehicles will receive an engine management download.4338X9D807
23/02/06R/2006/041PEUGEOT307 406 607 and 807FUEL MAY LEAKDue to a potential fault in the engine management system an internal engine fuel leak via the injectors may occur following switching off. This would result in the engine failing to restart due to excess fuel being present in the inlet manifold or cylinders.To address the issue recalled vehicles will receive an engine management download.4338X9D607
23/02/06RCOMP/2006/002CHARLTON BODIES LTDAIRTEKCOUPLING MAY FAILThe towing coupling may detach as a result of the retaining nut not being to the required torque and the locking pin not being fitted.Recall the vehicles that are likely to be affected to re-torque the towing coupling retaining nut and fit a retaining split pin.2 Airtek
23/02/06R/2006/030CITROENC5FUEL LEAKING INTO ENGINEIt has been identified that a potential fault in the engine management system could cause an internal fuel leak via one or more of the fuel injectors after switching off. This would result in a failure to restart because of excess fuel present in the inlet manifold or cylinders.Recalled vehicles will have the engine management unit software upgraded.257XVSC5VF7******76600913VF7******7666629827/07/200425/02/2005
23/02/06R/2006/030CITROENC5FUEL LEAKING INTO ENGINEIt has been identified that a potential fault in the engine management system could cause an internal fuel leak via one or more of the fuel injectors after switching off. This would result in a failure to restart because of excess fuel present in the inlet manifold or cylinders.Recalled vehicles will have the engine management unit software upgraded.257XVSC5VF7******76600913VF7******7666629827/07/200425/02/2005
23/02/06R/2006/032NISSANPATHFINDER AND NAVARASTEERING CONTROL MAY BE LOSTA concern has been identified relating to the fitment of the steering shaft lower joint. Should the joint become detached steering control will be lost.Recalled vehicles will have the subject joint inspected and the clamp bolt will be renewed if required.7812NAVARA07155501/02/200531/01/2006
23/02/06R/2006/032NISSANPATHFINDER AND NAVARASTEERING CONTROL MAY BE LOSTA concern has been identified relating to the fitment of the steering shaft lower joint. Should the joint become detached steering control will be lost.Recalled vehicles will have the subject joint inspected and the clamp bolt will be renewed if required.7812PATHFINDER07155501/02/200531/01/2006
25/02/06R/2006/037CITROENC4BRAKE FLUID MAY LEAKThere is a possibility that a seepage of brake fluid may occur at the union between the rear flexi hose and the metal brake pipes. This would eventually lead to the illumination of the low fluid warning lamp which if left would result in longer brake pedal travel and reduced effectiveness of the brakes.Recall the vehicles that likely to be affected and check for seepage of brake fluid. If the brake fluid seepage is apparent the flexible brake hose and the associated metal brake pipes will be replaced.6906XXLC4VF7******74278760VF7******7434264201/06/200530/09/2005
27/02/06RM/2006/009APRILIARSV1000 TUONO 1000 AND ETV CAPONORD 1000DRIVE CHAIN MAY BREAKIt has been identified that in some instances a link within the drive chain may break under particular riding conditions and after high mileage.Recalled machines which have covered less than 12000km will have the chain replaced. Machines which have covered in excess of 12000km's will have the chain and sprockets replaced.180ETV CAPONORD 1000
27/02/06RM/2006/009APRILIARSV1000 TUONO 1000 AND ETV CAPONORD 1000DRIVE CHAIN MAY BREAKIt has been identified that in some instances a link within the drive chain may break under particular riding conditions and after high mileage.Recalled machines which have covered less than 12000km will have the chain replaced. Machines which have covered in excess of 12000km's will have the chain and sprockets replaced.180RSV1000
27/02/06RM/2006/009APRILIARSV1000 TUONO 1000 AND ETV CAPONORD 1000DRIVE CHAIN MAY BREAKIt has been identified that in some instances a link within the drive chain may break under particular riding conditions and after high mileage.Recalled machines which have covered less than 12000km will have the chain replaced. Machines which have covered in excess of 12000km's will have the chain and sprockets replaced.180TUONO1000
28/02/06RM/2006/010HARLEY DAVIDSONXL DYNA SOFTTAIL AND TOURINGFUEL TAP READS INCORRECTLYCertain 2004 model year carburettor equipped motorcycles have been fitted with a fuel tap where the 'On' and 'Reserve' markings have been transposed.Replace the fuel valve (tap).159118DYNA
28/02/06RM/2006/010HARLEY DAVIDSONXL DYNA SOFTTAIL AND TOURINGFUEL TAP READS INCORRECTLYCertain 2004 model year carburettor equipped motorcycles have been fitted with a fuel tap where the 'On' and 'Reserve' markings have been transposed.Replace the fuel valve (tap).159118XL
28/02/06RM/2006/010HARLEY DAVIDSONXL DYNA SOFTTAIL AND TOURINGFUEL TAP READS INCORRECTLYCertain 2004 model year carburettor equipped motorcycles have been fitted with a fuel tap where the 'On' and 'Reserve' markings have been transposed.Replace the fuel valve (tap).159118SOFTAIL
28/02/06RM/2006/010HARLEY DAVIDSONXL DYNA SOFTTAIL AND TOURINGFUEL TAP READS INCORRECTLYCertain 2004 model year carburettor equipped motorcycles have been fitted with a fuel tap where the 'On' and 'Reserve' markings have been transposed.Replace the fuel valve (tap).159118TOURING
28/02/06RM/2006/025BUELLXB9SX XB12S AND XB12RSIDE STAND MAY NOT RETRACTDue to an incorrectly manufactured side stand pivot bolt the side stand may not move backwards when the weight of the parked machine is removed from it.Recalled machines will have the side stand pivot bolt replaced.11830XB9SX
28/02/06RM/2006/025BUELLXB9SX XB12S AND XB12RSIDE STAND MAY NOT RETRACTDue to an incorrectly manufactured side stand pivot bolt the side stand may not move backwards when the weight of the parked machine is removed from it.Recalled machines will have the side stand pivot bolt replaced.11830XB12R
28/02/06RM/2006/025BUELLXB9SX XB12S AND XB12RSIDE STAND MAY NOT RETRACTDue to an incorrectly manufactured side stand pivot bolt the side stand may not move backwards when the weight of the parked machine is removed from it.Recalled machines will have the side stand pivot bolt replaced.11830XB12S
28/02/06RM/2006/014HARLEY DAVIDSONDYNA XL AND TOURINGTAIL LAMP MAY BECOME LOOSEThe tail lamp bulb may become loose in its mounting socket.Recall the machines that are likely to be affected and replace the tail lamp bulb with a re-designed bulb.520114DYNA01/06/200331/08/2003
28/02/06RM/2006/014HARLEY DAVIDSONDYNA XL AND TOURINGTAIL LAMP MAY BECOME LOOSEThe tail lamp bulb may become loose in its mounting socket.Recall the machines that are likely to be affected and replace the tail lamp bulb with a re-designed bulb.520114XL01/06/200331/08/2003
28/02/06RM/2006/014HARLEY DAVIDSONDYNA XL AND TOURINGTAIL LAMP MAY BECOME LOOSEThe tail lamp bulb may become loose in its mounting socket.Recall the machines that are likely to be affected and replace the tail lamp bulb with a re-designed bulb.520114TOURING01/06/200331/08/2003
28/02/06RM/2006/016HARLEY DAVIDSONFLHXI - STREET GLIDEMIRRORS IMPROPERLY MOUNTEDThe mirrors are incorrectly located on the inner fairing making it impossible to achieve correct mirror adjustment thus restricting rearward vision.Recall the vehicles that are likely to be affected and reposition the mirrors.46121FL01/06/200531/08/2005
28/02/06R/2006/043IVECOEUROCARGOREAR BRAKE PERFORMANCE MAY NOT BE AS EXPECTEDIt is possible in an emergency braking situation with fully laden vehicle the rear axle brakes will not be applied as expected giving a rise of extended braking distance.Recall the vehicles that are likely to be affected and check the brake pressure regulator type fitted to the vehicle is the same as that list on the vehicle plate. If necessary fit a new plate. Check and if necessary adjust the load sensing valve linkage.4RCC01EUROCARGO01/10/200430/11/2004
28/02/06RM/2006/012HARLEY DAVIDSONDYNAFUEL MAY LEAKOn the affected machines the possibility exists that the internal lining of the fuel hose may separate from the hose outer leading to a possible fuel leak.Affected machines will have the fuel line replaced90112DYNA01/01/200331/12/2004
28/02/06RM/2006/013HARLEY DAVIDSONTOURINGELECTRICAL CIRCUIT FAILUREIt has been identified that the subject machines have been fitted with a sub-standard 40amp circuit.Recalled machines will have the circuit breaker replaced.341113TOURING01/01/199931/12/2003
28/02/06RM/2006/017HARLEY DAVIDSONDYNA FUEL MAY LEAKCertain 2004 Dyna range motorcycles may have a condition which allows the throttle cables to contact the underside of the fuel tank. This could eventually lead to them wearing through the tank causing a fuel leak.Recall the machines that are likely to be affected and modify the throttle cable retention. The throttle cable and tank will be replaced as necessary.164122DYNA01/06/200328/02/2004
28/02/06RM/2006/024BUELLXB9S AND XB12SHORN OR MAIN KEY SWITCH CIRCUITS MAY FUSEIt is possible that the horn main power feed cable may have been incorrectly routed which can lead to the cable fraying and either the horn or main key switch fusing when the horn is operated. Recalled machines will have the subject wiring harness re-routed.88828XB9S
28/02/06RM/2006/024BUELLXB9S AND XB12SHORN OR MAIN KEY SWITCH CIRCUITS MAY FUSEIt is possible that the horn main power feed cable may have been incorrectly routed which can lead to the cable fraying and either the horn or main key switch fusing when the horn is operated. Recalled machines will have the subject wiring harness re-routed.88828XB12S
28/02/06RM/2006/018HARLEY DAVIDSONDYNANEUTRAL GEAR LIGHT MAY ILLUMINATE WHEN MACHINE IS IN GEARCertain 2006 Dyna range motorcycles may have a fault which leaves the neutral light illuminated when 1st or 2nd gear is selected.Recall the machines that are likely to be affected and replace the detent arm neutral switch and shift cam assembly.248124DYNA01/06/200531/10/2005
01/03/06RM/2006/019MOTO GUZZIBREVA 1100 AND GRISO 1100OIL MAY LEAK ONTO REAR WHEELThere is a possiblility that a fault with the rear transmission box may allow oil to leak onto the rear wheelRecall the vehicles that are likely to be affected and replace the drive assembly.190GRISO
01/03/06RM/2006/019MOTO GUZZIBREVA 1100 AND GRISO 1100OIL MAY LEAK ONTO REAR WHEELThere is a possiblility that a fault with the rear transmission box may allow oil to leak onto the rear wheelRecall the vehicles that are likely to be affected and replace the drive assembly.190BREVA
03/03/06R/2006/016JAGUARXJ8 (WITH MOONROOF)ROOF GLASS MAY SHATTERThe moonroofs glass may shatter due to the reinforcement bars being incorrectly assembled.Recall the vehicles that are likely to be affected and replace the moonroof with a quality assured replacement.100R722XJ8SAJWA71B16SG50084SAJAC73R96TH0567816/07/200522/12/2005
03/03/06RM/2006/011KAWASAKIKAF400-B1 AND KAF400-B6FSTRUT MAY BECOME LOOSE AND SEPARATEThe front steering knuckle clamp bolts may not have been tightened sufficiently.Recall the vehicles that are affect (the vehicles that have had recall number RM/2005/030 completed prior to 03/03/2006) to inspect the steering knuckle clamp bolts and replace as necessary. Refit the clamp bolts and tighten to the correct torque.6106-101RKAF400JK1AF400BBB600001JK1AF400BBB6000251
03/03/06RM/2006/011KAWASAKIKAF400-B1 AND KAF400-B6FSTRUT MAY BECOME LOOSE AND SEPARATEThe front steering knuckle clamp bolts may not have been tightened sufficiently.Recall the vehicles that are affect (the vehicles that have had recall number RM/2005/030 completed prior to 03/03/2006) to inspect the steering knuckle clamp bolts and replace as necessary. Refit the clamp bolts and tighten to the correct torque.6106-101RKAF400JK1AF400BBB600501JK1AF400BBB600560
03/03/06R/2005/179ISUZUTROUPER 3.0 LITREDILUTION OF ENGINE OIL LEADING TO ENGINE DAMAGEDue to excessive clearance within the fuel injectors fuel may leak into the cylinder bores and then into the sump causing engine oil dilution. If this situation is ignored engine damage can occur additionally the engine revs may show an unintentional increase. Affected vehicles will have the fuel injectors replaced.14215TROOPER01/01/199831/12/2003
04/03/06RTW/2006/001COOPERLT285/75R16 COOPER DISCOVERER S/TTYRE TREAD MAY SEPARATEIt has been identified that a low tread gauge in the shoulder slot area could lead to cracking at the base of the shoulder slots. This could result in exposed belt wire and accelerated belt degradation which could result in separation.Customers are to be contacted and the subject tyres changed free of charge.81#145LT285/75R16 COOPER DISCOVERER S/T22/02/200421/01/2006
04/03/06RTW/2006/001COOPERLT285/75R16 COOPER DISCOVERER S/TTYRE TREAD MAY SEPARATEIt has been identified that a low tread gauge in the shoulder slot area could lead to cracking at the base of the shoulder slots. This could result in exposed belt wire and accelerated belt degradation which could result in separation.Customers are to be contacted and the subject tyres changed free of charge.81#145LT285/75R1622/02/200421/01/2006
04/03/06RTW/2006/002COOPER235/35R19XL91W COOPER ZEON 2XS AND 245/40R20XL95W COOPER ZEON 2XSTYRE MAY DEFLATEThe subject tyres may develop scattered compression cracking within the inner liner which can result in a reduction in the ability of the tyre to retain inflation pressure. Customers will be contacted and tyres replaced free of charge.1676#146235/R19XL91W COOPER ZEON 2XS28/11/200412/02/2005
04/03/06RTW/2006/002COOPER235/35R19XL91W COOPER ZEON 2XS AND 245/40R20XL95W COOPER ZEON 2XSTYRE MAY DEFLATEThe subject tyres may develop scattered compression cracking within the inner liner which can result in a reduction in the ability of the tyre to retain inflation pressure. Customers will be contacted and tyres replaced free of charge.1676#146245/R20XL95W25/04/200408/05/2004
04/03/06RTW/2006/002COOPER235/35R19XL91W COOPER ZEON 2XS AND 245/40R20XL95W COOPER ZEON 2XSTYRE MAY DEFLATEThe subject tyres may develop scattered compression cracking within the inner liner which can result in a reduction in the ability of the tyre to retain inflation pressure. Customers will be contacted and tyres replaced free of charge.1676#146245/R20XL95W COOPER ZEON 2XS25/04/200408/05/2004
04/03/06RTW/2006/002COOPER235/35R19XL91W COOPER ZEON 2XS AND 245/40R20XL95W COOPER ZEON 2XSTYRE MAY DEFLATEThe subject tyres may develop scattered compression cracking within the inner liner which can result in a reduction in the ability of the tyre to retain inflation pressure. Customers will be contacted and tyres replaced free of charge.1676#146235/R19XL91W28/11/200412/02/2005
06/03/06R/2006/001KIASEDONAPOSSIBILITY OF FIREThe wiring to the driver's electric seat adjuster may chafe on the sharp edge of the seat base which may result in an electrical short circuit. This can cause the wiring and fuse-box to overheat and a risk of fire.Recalled vehicles will have the routing of the wiring checked and any sharp edges will be insulated.2347SEDONA
06/03/06R/2005/127TOYOTA4RUNNERSTEERING RELAY ROD MAY CRACKIf the steering wheel is repeatedly turned under conditions where high steering effort is required such as when fully turning the steering wheel whilst the vehicle is stationary a fatigue crack may develop in the relay rod. In extreme cases the steering rod may fracture causing a loss of steering control.Recall the likely to be affected vehicles and replace the steering relay rod.1690RNP/MIF/0434RUNNERJT111VND##9016646JT111VND##901928016/04/199308/03/1995
06/03/06R/2005/127TOYOTA4RUNNERSTEERING RELAY ROD MAY CRACKIf the steering wheel is repeatedly turned under conditions where high steering effort is required such as when fully turning the steering wheel whilst the vehicle is stationary a fatigue crack may develop in the relay rod. In extreme cases the steering rod may fracture causing a loss of steering control.Recall the likely to be affected vehicles and replace the steering relay rod.1690RNP/MIF/0434RUNNERJT111GND##8000002JT111GND##800961619/04/199328/07/1995
10/03/06RSPV/2006/003SWIFTBESSACAR SUNDANCE E450TYRE VALVE MAY FAILIt has been identified that a limited number of motorhomes have been fitted during production with an incorrect tyre valve. In extreme circumstances the valve could fail resulting in a total loss of tyre air pressure.Owners are being asked to identify what tyre valve is fitted to their motorhome and to have the valve/s replaced if found to be incorrect.998BESSACARR E450 SUNDANCE01/07/200331/01/2006
14/03/06RM/2006/021BMW MOTORCYCLESR1200 RT R1200 ST AND R1200 GSABS MAY FAILWhen work involving removal of the left brake caliper is undertaken (i.e. when a tyre is changed) there is a possibility that the ABS sensor cable can be incorrectly routed when the caliper is reinstalled. If it is incorrectly routed the sensor cable can chafe against the brake disc with the result that the ABS function (not the active braking function)can fail.Recalled machines will have the ABS sensor cable rerouted.4582R SERIES
14/03/06RM/2006/023BMW MOTORCYCLESR1200 RT ST AND GSCLUTCH MAY FAILIt is possible for some clutch components to work loose while the motorcycle is being ridden and punch out through the engine block possibly endangering the health and safety of the rider.Recall the vehicles that are likely to be affected to replace the clutch assembly.111R SERIES
14/03/06RM/2006/020BMW MOTORCYCLESR1200 RT R1200 ST R1200 GS K1200R AND K1200 SABS MAY FAILIn certain exceptional circumstances (constant use of the ABS) it is possible for the ABS to stop functioning. This is as a result of excessive pressure building up in the ABS system.To recall the machines that are likely to be affected and fit a pressure restrictor into the hand brake control hydraulics.5575K SERIES
14/03/06RM/2006/020BMW MOTORCYCLESR1200 RT R1200 ST R1200 GS K1200R AND K1200 SABS MAY FAILIn certain exceptional circumstances (constant use of the ABS) it is possible for the ABS to stop functioning. This is as a result of excessive pressure building up in the ABS system.To recall the machines that are likely to be affected and fit a pressure restrictor into the hand brake control hydraulics.5575R SERIES
15/03/06R/2005/174CHRYSLERJEEP WRANGLERVEHICLE MAY ROLL AWAYThe cup plug on the automatic transmission parking pawl may be incorrectly installed. Thus even when park is selected it may be possible that the vehicle could roll away.Recalled vehicles will have a bracket fitted to the transmission cup plug.279E14WRANGLER
17/03/06R/2006/013IVECODAILY 35C 12 AND 50C15REAR AXLE SPRING SUPPORT BRACKET MAY CRACK There is a possibility that the rear axle spring support brackets may crack which could affect the vehicle's stability.Recalled vehicles will have the welding of the spring support brackets checked for cracks. Should any cracking be found the drive axle casing will be changed. 114RCT05DAILYZCFC4090005244448ZCFC359100547598101/05/200031/10/2003
17/03/06R/2006/013IVECODAILY 35C 12 AND 50C15REAR AXLE SPRING SUPPORT BRACKET MAY CRACK There is a possibility that the rear axle spring support brackets may crack which could affect the vehicle's stability.Recalled vehicles will have the welding of the spring support brackets checked for cracks. Should any cracking be found the drive axle casing will be changed. 114RCT05DAILYZCFC359100D123928ZCFC35A100D23707501/05/200031/12/2003
20/03/06R/2005/131MAN14.220 HOCLMOUNTING PLATE ON REAR AXLE MAY BREAKMounting plate for rear axle location may break and allow the axle to become insecure.Recall the vehicles that are likely to be affected and replace the cast mounting plate (81.43240-0141) for a modified mounting plate.3416940414 SERIES
20/03/06RM/2006/015YAMAHAYP250RPOSSIBILITY OF FUEL LEAKAGEUnder certain circumstances the fuel tank cap may not vent sufficiently. This can cause a build up of vacuum which in extreme cases; may result in the fuel tank pipe being forced off allowing fuel to escape.Recalled machines will have the fuel tank cap modified.50YP250
20/03/06RSPV/2006/005JOHNSTON SWEEPERS LTDCOMPACT SWEEPERFIT MISSING SEAT BELTSDue to changes in UK legislation vehicles manufactured between October 2001 and December 2004 are required to be fitted with driver and passenger seat belts.Recalled vehicles will be fitted with the requisite number of seat belts.183COMPACT SWEEPER
20/03/06R/2006/022HONDAFR-VENGINE MAY STALLThe engine may hesitate or cut out due to air accumulating in the fuel strainer which is then drawn in by the high pressure fuel pump. This in turn results in low fuel pressure leading to hesitation illuminating MIL lamp on and possible stalling.Recall the vehicles that are likely to be affected and fit a redesigned fuel strainer.1296FR-V10/03/200517/01/2006
20/03/06R/2006/056WRIGHT BUSSOLAR AND SOLAR FUSIONROOF PANEL DETACHEDThere is a possibility that the roof inspection door locks may loosen and allow the door to fall down whilst the vehicle is in serviceRecall the vehicles that are likely to be affected fit modified locking plates and safety straps to lock to retain the roof inspection door safely in position.79SOLAR FUSION01/02/200231/01/2006
20/03/06R/2006/056WRIGHT BUSSOLAR AND SOLAR FUSIONROOF PANEL DETACHEDThere is a possibility that the roof inspection door locks may loosen and allow the door to fall down whilst the vehicle is in serviceRecall the vehicles that are likely to be affected fit modified locking plates and safety straps to lock to retain the roof inspection door safely in position.79FUSION01/02/200231/01/2006
22/03/06R/2006/006VAUXHALLCORSA C COMBO C AND TIGRA BWATER INGRESS INTO ABS WIRING MAY CAUSE A SHORT CIRCUIT AND A FIREIt has been identified that the above vehicles could be affected by moisture ingress at the ABS connector. The moisture can enter through the ground wiring connection which can lead to the ABS not functioning correctly overheating within the connector and in extreme cases a fire.Recalled vehicles will have the ABS harness plug checked for moisture ingress and where necessary the wiring harness and control unit will be replaced. In all other cases the ground cable will be secured against ingress of moisture by soldering the cable sockets and applying shrink tubes. 21737405C39COMBO*********43000023*********54330240
22/03/06R/2006/006VAUXHALLCORSA C COMBO C AND TIGRA BWATER INGRESS INTO ABS WIRING MAY CAUSE A SHORT CIRCUIT AND A FIREIt has been identified that the above vehicles could be affected by moisture ingress at the ABS connector. The moisture can enter through the ground wiring connection which can lead to the ABS not functioning correctly overheating within the connector and in extreme cases a fire.Recalled vehicles will have the ABS harness plug checked for moisture ingress and where necessary the wiring harness and control unit will be replaced. In all other cases the ground cable will be secured against ingress of moisture by soldering the cable sockets and applying shrink tubes. 21737405C39TIGRA*********5E000023*********5E037478
22/03/06R/2006/006VAUXHALLCORSA C COMBO C AND TIGRA BWATER INGRESS INTO ABS WIRING MAY CAUSE A SHORT CIRCUIT AND A FIREIt has been identified that the above vehicles could be affected by moisture ingress at the ABS connector. The moisture can enter through the ground wiring connection which can lead to the ABS not functioning correctly overheating within the connector and in extreme cases a fire.Recalled vehicles will have the ABS harness plug checked for moisture ingress and where necessary the wiring harness and control unit will be replaced. In all other cases the ground cable will be secured against ingress of moisture by soldering the cable sockets and applying shrink tubes. 21737405C39CORSA*********44000009*********54330240
24/03/06R/2006/068EAST LANCSELCB DEMOUNTABLE UPPERDECK D/DECKERROOF BECAME DETACHED INADVERTENTLYIt has been established that under certain circumstances the roof locks may be subject to incorrect operation which may lead to the roof becoming insecureRecalled vehicles will be fitted with a modified roof locking system.13ELCB DEMOUNTABLE UPPERDECK DOUBLE/DECKER01/01/200513/04/2006
24/03/06R/2006/015FIATMULTIPLA 1.9 JTDSUSPENSION COIL SPRING MAY BREAKUnder environmental conditions that require intensive use of salt on the roads corrosive deposits accumulate inside the noise-insulating protective sheath located on the front suspension springs creating areas of corrosion which may lead to the spring breaking after a period of time.Recall the vehicles that are likely to be affected and replace the front coil springs with those of a new type.10276MULTIPLAZFA18600002026501ZFA1860000223440801/05/199931/12/2004
27/03/06R/2006/020IVECOSTRALIS AD/ATCAB SIDE MEMBER MAY DEFORMIt has been identified that the cab lower side member may become deformed due to excessive hydraulic tilt pump pressure.Recalled vehicles will have the cab tilt pump pressure reduced to 310 bar. Should the cab side member be deformed a repair to rectify this will be carried out.64RCV24STRALISWJME2NSJ004285721WJMS2NSK00428890201/09/200430/11/2004
27/03/06R/2006/031AUDIA3FLYWHEEL MAY FAIL FIRE MAY RESULTThe two mass flywheel can become damaged because of a non-optimally designed through-flow restrictor in the clutch pressure pipe. This can lead to a total failure of the flywheel and under unfavourable circumstances to a vehicle fire. Recall the vehicles that are likely to be affected and establish the manufacturer of the two mass flywheel. Where necessary replace the flywheel and the breather of the clutch pressure pipe.8586A3WAUZZZ8P*4A064592WAUZZZ8P*4A18153201/12/200330/06/2005
27/03/06R/2006/031AUDIA3FLYWHEEL MAY FAIL FIRE MAY RESULTThe two mass flywheel can become damaged because of a non-optimally designed through-flow restrictor in the clutch pressure pipe. This can lead to a total failure of the flywheel and under unfavourable circumstances to a vehicle fire. Recall the vehicles that are likely to be affected and establish the manufacturer of the two mass flywheel. Where necessary replace the flywheel and the breather of the clutch pressure pipe.8586A3WAUZZZ8P*5A000164WAUZZZ8P*5A17671901/12/200301/06/2005
27/03/06R/2006/031AUDIA3FLYWHEEL MAY FAIL FIRE MAY RESULTThe two mass flywheel can become damaged because of a non-optimally designed through-flow restrictor in the clutch pressure pipe. This can lead to a total failure of the flywheel and under unfavourable circumstances to a vehicle fire. Recall the vehicles that are likely to be affected and establish the manufacturer of the two mass flywheel. Where necessary replace the flywheel and the breather of the clutch pressure pipe.8586A3WAUZZZ8P*6B000004WAUZZZ8P*6B00383201/12/200301/06/2005
27/03/06R/2006/031AUDIA3FLYWHEEL MAY FAIL FIRE MAY RESULTThe two mass flywheel can become damaged because of a non-optimally designed through-flow restrictor in the clutch pressure pipe. This can lead to a total failure of the flywheel and under unfavourable circumstances to a vehicle fire. Recall the vehicles that are likely to be affected and establish the manufacturer of the two mass flywheel. Where necessary replace the flywheel and the breather of the clutch pressure pipe.8586A301/12/200330/06/2005
27/03/06R/2006/031AUDIA3FLYWHEEL MAY FAIL FIRE MAY RESULTThe two mass flywheel can become damaged because of a non-optimally designed through-flow restrictor in the clutch pressure pipe. This can lead to a total failure of the flywheel and under unfavourable circumstances to a vehicle fire. Recall the vehicles that are likely to be affected and establish the manufacturer of the two mass flywheel. Where necessary replace the flywheel and the breather of the clutch pressure pipe.8586A3WAUZZZ8P*5B000002WAUZZZ8P*5B01734801/12/200330/06/2005
27/03/06R/2006/031AUDIA3FLYWHEEL MAY FAIL FIRE MAY RESULTThe two mass flywheel can become damaged because of a non-optimally designed through-flow restrictor in the clutch pressure pipe. This can lead to a total failure of the flywheel and under unfavourable circumstances to a vehicle fire. Recall the vehicles that are likely to be affected and establish the manufacturer of the two mass flywheel. Where necessary replace the flywheel and the breather of the clutch pressure pipe.8586A3WAUZZZ8P*6A000109WAUZZZ8P*6A02425201/12/200301/06/2005
27/03/06R/2006/031AUDIA3FLYWHEEL MAY FAIL FIRE MAY RESULTThe two mass flywheel can become damaged because of a non-optimally designed through-flow restrictor in the clutch pressure pipe. This can lead to a total failure of the flywheel and under unfavourable circumstances to a vehicle fire. Recall the vehicles that are likely to be affected and establish the manufacturer of the two mass flywheel. Where necessary replace the flywheel and the breather of the clutch pressure pipe.8586A3WAUZZZ8P369020490WAUZZZ8P36902049001/12/200330/06/2003
28/03/06RSPV/2006/006YAMAHAYFM250B YFM350A YFM350FA AND YFM450POSSIBLE LOSS OF STEERING CONTROLUnder certain circumstances there is a possibility that the excessive wear may occur within the tie rod end which in extreme cases may result in the joint failing and loss of steering control.Recall the vehicles that are likely to be affected and replace the tie rod ends.974YFM25001/01/200531/12/2005
28/03/06RSPV/2006/006YAMAHAYFM250B YFM350A YFM350FA AND YFM450POSSIBLE LOSS OF STEERING CONTROLUnder certain circumstances there is a possibility that the excessive wear may occur within the tie rod end which in extreme cases may result in the joint failing and loss of steering control.Recall the vehicles that are likely to be affected and replace the tie rod ends.974YFM35001/01/200531/12/2005
28/03/06RSPV/2006/006YAMAHAYFM250B YFM350A YFM350FA AND YFM450POSSIBLE LOSS OF STEERING CONTROLUnder certain circumstances there is a possibility that the excessive wear may occur within the tie rod end which in extreme cases may result in the joint failing and loss of steering control.Recall the vehicles that are likely to be affected and replace the tie rod ends.974YFM45001/01/200531/12/2005
28/03/06R/2006/051CITROENC2 C3 C3 PLURIELACCELERATOR PEDAL RETURNS TOO SLOWLYIt has been identified that the accelerator pedal can return too slowly. This can have an effect on the driving of the vehicle Recalled vehicles will have the accelerator pedal replaced.9868PLURIELVF7******28036651VF7******2808304831/05/200506/01/2006
28/03/06R/2006/051CITROENC2 C3 C3 PLURIELACCELERATOR PEDAL RETURNS TOO SLOWLYIt has been identified that the accelerator pedal can return too slowly. This can have an effect on the driving of the vehicle Recalled vehicles will have the accelerator pedal replaced.9868C3VF7******28501003VF7******2859234718/10/200517/12/2005
28/03/06R/2006/051CITROENC2 C3 C3 PLURIELACCELERATOR PEDAL RETURNS TOO SLOWLYIt has been identified that the accelerator pedal can return too slowly. This can have an effect on the driving of the vehicle Recalled vehicles will have the accelerator pedal replaced.9868C2VF7******97308110VF7******9734558106/09/200523/12/2005
05/04/06RSPV/2006/008MCCORMICK TRACTORS LTDCXBRAKING PERFORMANCE MAY BE AFFECTEDIn certain circumstances it is possible for aerated oil to enter the compact brake booster. With air in the system the brake pedal travel increases and the brake efficiency reduces.Recall the machines that are likely to be affected to install a modified reservoir tube assembly and hose.1060CXJJE20029171JJE205806602/11/200327/02/2006
05/04/06R/2006/033SEATALTEA TOLEDO AND LEON (2 LTR TDI ENGINE AND 6 SPEED MANUAL GEARBOX)FLYWHEEL MAY FAILThe two mass flywheel can become damaged because of a non-optimally designed through-flow restrictor in the clutch pressure pipe. This can lead to a total failure of the flywheel and under unfavourable circumstances to a vehicle fire. Recall the vehicles that are likely to be affected and establish the manufacturer of the two mass flywheel. Where necessary replace the flywheel and the breather of the clutch pressure pipe.147713S2ALTEA VSSZZZ5PZ4R000048VSSZZZ5PZ4R01739001/02/200430/06/2005
05/04/06R/2006/033SEATALTEA TOLEDO AND LEON (2 LTR TDI ENGINE AND 6 SPEED MANUAL GEARBOX)FLYWHEEL MAY FAILThe two mass flywheel can become damaged because of a non-optimally designed through-flow restrictor in the clutch pressure pipe. This can lead to a total failure of the flywheel and under unfavourable circumstances to a vehicle fire. Recall the vehicles that are likely to be affected and establish the manufacturer of the two mass flywheel. Where necessary replace the flywheel and the breather of the clutch pressure pipe.147713S2ALTEA VSSZZZ5PZ5R000026VSSZZZ5PZ5R10362001/02/200430/06/2005
05/04/06R/2006/033SEATALTEA TOLEDO AND LEON (2 LTR TDI ENGINE AND 6 SPEED MANUAL GEARBOX)FLYWHEEL MAY FAILThe two mass flywheel can become damaged because of a non-optimally designed through-flow restrictor in the clutch pressure pipe. This can lead to a total failure of the flywheel and under unfavourable circumstances to a vehicle fire. Recall the vehicles that are likely to be affected and establish the manufacturer of the two mass flywheel. Where necessary replace the flywheel and the breather of the clutch pressure pipe.147713S2TOLEDOVSSZZZ1PZ6R000004VSSZZZ1PZ6R00161001/02/200430/06/2005
05/04/06R/2006/033SEATALTEA TOLEDO AND LEON (2 LTR TDI ENGINE AND 6 SPEED MANUAL GEARBOX)FLYWHEEL MAY FAILThe two mass flywheel can become damaged because of a non-optimally designed through-flow restrictor in the clutch pressure pipe. This can lead to a total failure of the flywheel and under unfavourable circumstances to a vehicle fire. Recall the vehicles that are likely to be affected and establish the manufacturer of the two mass flywheel. Where necessary replace the flywheel and the breather of the clutch pressure pipe.147713S2ALTEA VSSZZZ1PZ6R000004VSSZZZ1PZ6R00161001/02/200430/06/2005
05/04/06R/2006/033SEATALTEA TOLEDO AND LEON (2 LTR TDI ENGINE AND 6 SPEED MANUAL GEARBOX)FLYWHEEL MAY FAILThe two mass flywheel can become damaged because of a non-optimally designed through-flow restrictor in the clutch pressure pipe. This can lead to a total failure of the flywheel and under unfavourable circumstances to a vehicle fire. Recall the vehicles that are likely to be affected and establish the manufacturer of the two mass flywheel. Where necessary replace the flywheel and the breather of the clutch pressure pipe.147713S2TOLEDOVSSZZZ5PZ4R000048VSSZZZ5PZ4R01739001/02/200430/06/2005
05/04/06R/2006/033SEATALTEA TOLEDO AND LEON (2 LTR TDI ENGINE AND 6 SPEED MANUAL GEARBOX)FLYWHEEL MAY FAILThe two mass flywheel can become damaged because of a non-optimally designed through-flow restrictor in the clutch pressure pipe. This can lead to a total failure of the flywheel and under unfavourable circumstances to a vehicle fire. Recall the vehicles that are likely to be affected and establish the manufacturer of the two mass flywheel. Where necessary replace the flywheel and the breather of the clutch pressure pipe.147713S2TOLEDOVSSZZZ5PZ5R000026VSSZZZ5PZ5R10362001/02/200430/06/2005
05/04/06R/2006/033SEATALTEA TOLEDO AND LEON (2 LTR TDI ENGINE AND 6 SPEED MANUAL GEARBOX)FLYWHEEL MAY FAILThe two mass flywheel can become damaged because of a non-optimally designed through-flow restrictor in the clutch pressure pipe. This can lead to a total failure of the flywheel and under unfavourable circumstances to a vehicle fire. Recall the vehicles that are likely to be affected and establish the manufacturer of the two mass flywheel. Where necessary replace the flywheel and the breather of the clutch pressure pipe.147713S2LEONVSSZZZ1PZ6R000004VSSZZZ1PZ6R00161001/02/200430/06/2005
05/04/06R/2006/033SEATALTEA TOLEDO AND LEON (2 LTR TDI ENGINE AND 6 SPEED MANUAL GEARBOX)FLYWHEEL MAY FAILThe two mass flywheel can become damaged because of a non-optimally designed through-flow restrictor in the clutch pressure pipe. This can lead to a total failure of the flywheel and under unfavourable circumstances to a vehicle fire. Recall the vehicles that are likely to be affected and establish the manufacturer of the two mass flywheel. Where necessary replace the flywheel and the breather of the clutch pressure pipe.147713S2LEONVSSZZZ5PZ5R000026VSSZZZ5PZ5R10362001/02/200430/06/2005
05/04/06R/2006/033SEATALTEA TOLEDO AND LEON (2 LTR TDI ENGINE AND 6 SPEED MANUAL GEARBOX)FLYWHEEL MAY FAILThe two mass flywheel can become damaged because of a non-optimally designed through-flow restrictor in the clutch pressure pipe. This can lead to a total failure of the flywheel and under unfavourable circumstances to a vehicle fire. Recall the vehicles that are likely to be affected and establish the manufacturer of the two mass flywheel. Where necessary replace the flywheel and the breather of the clutch pressure pipe.147713S2LEONVSSZZZ5PZ4R000048VSSZZZ5PZ4R01739001/02/200430/06/2005
05/04/06R/2006/033SEATALTEA TOLEDO AND LEON (2 LTR TDI ENGINE AND 6 SPEED MANUAL GEARBOX)FLYWHEEL MAY FAILThe two mass flywheel can become damaged because of a non-optimally designed through-flow restrictor in the clutch pressure pipe. This can lead to a total failure of the flywheel and under unfavourable circumstances to a vehicle fire. Recall the vehicles that are likely to be affected and establish the manufacturer of the two mass flywheel. Where necessary replace the flywheel and the breather of the clutch pressure pipe.147713S2LEONVSSZZZ5PZ6R000009VSSZZZ5PZ6R00163801/02/200430/06/2005
05/04/06R/2006/033SEATALTEA TOLEDO AND LEON (2 LTR TDI ENGINE AND 6 SPEED MANUAL GEARBOX)FLYWHEEL MAY FAILThe two mass flywheel can become damaged because of a non-optimally designed through-flow restrictor in the clutch pressure pipe. This can lead to a total failure of the flywheel and under unfavourable circumstances to a vehicle fire. Recall the vehicles that are likely to be affected and establish the manufacturer of the two mass flywheel. Where necessary replace the flywheel and the breather of the clutch pressure pipe.147713S2ALTEA VSSZZZ5PZ6R000009VSSZZZ5PZ6R00163801/02/200430/06/2005
05/04/06R/2006/033SEATALTEA TOLEDO AND LEON (2 LTR TDI ENGINE AND 6 SPEED MANUAL GEARBOX)FLYWHEEL MAY FAILThe two mass flywheel can become damaged because of a non-optimally designed through-flow restrictor in the clutch pressure pipe. This can lead to a total failure of the flywheel and under unfavourable circumstances to a vehicle fire. Recall the vehicles that are likely to be affected and establish the manufacturer of the two mass flywheel. Where necessary replace the flywheel and the breather of the clutch pressure pipe.147713S2TOLEDOVSSZZZ5PZ6R000009VSSZZZ5PZ6R00163801/02/200430/06/2005
06/04/06R/2006/025VAUXHALLAstra HPOSSIBLE LOSS OF STEERING CONTROL It has been identified that on affected vehicle's the right hand front lower control arm guide joint may be incorrectly mounted. In the worst case the lower control arm could work loose separate from the steering knuckle and severely impair the control of the vehicle.Recalled vehicles will have the guide joint checked for correct mounting and replaced if the mounting is found to be incorrect.2510ASTRA H01/01/200503/02/2006
07/04/06R/2006/122RENAULT TRUCKS UK LTDMAGNUM DXI PREMATURE WEAR OF STEERING BALL JOINTS.It has been identified that due to a heat treatment problem premature wear of the steering linkage ball joints may take place.Recalled vehicles will have the subject components replaced with quality certified parts.4971ADMAGNUM
10/04/06R/2006/061PEUGEOTBoxer 11 & 807 DW10 & DW12 EnginesBRAKING EFFICIENCY MAY BE AFFECTEDBraking assistance could be adversely by freezing of moisture that may accumulate in the vacuum circuit.Recall the vehicles that may be affected and fit a separate air vent complete with filter to each electro valve fitted to the vacuum circuit.16530X8LBOXER
10/04/06R/2006/061PEUGEOTBoxer 11 & 807 DW10 & DW12 EnginesBRAKING EFFICIENCY MAY BE AFFECTEDBraking assistance could be adversely by freezing of moisture that may accumulate in the vacuum circuit.Recall the vehicles that may be affected and fit a separate air vent complete with filter to each electro valve fitted to the vacuum circuit.16530X8L807
11/04/06R/2006/064PEUGEOT807 & Expert IISEAT BELT BRACING ACTION MAY BE AFFECTEDThe seat belt locking action may not be as fast as it is designed to be.Recall the vehicles that may be affected to check the date of manufacture of the seat belts and where necessary replace the seat belts.3780716/12/200519/12/2005
11/04/06R/2006/064PEUGEOT807 & Expert IISEAT BELT BRACING ACTION MAY BE AFFECTEDThe seat belt locking action may not be as fast as it is designed to be.Recall the vehicles that may be affected to check the date of manufacture of the seat belts and where necessary replace the seat belts.37EXPERT16/12/200519/12/2005
11/04/06RM/2006/008SUZUKI MOTORCYCLESVL1500FUEL MAY LEAK FROM FUEL TANKIt has been identified due to the method used to mount the fuel tank that under certain engine conditions it is possible for a hairline crack to develop in the fuel tank. This can result in the fuel tank leaking. Recalled machines will have the fuel tank removed and visually inspected for cracks following which the tank will be subject to pressure testing. If the tank should be found to leak it will be replaced. In any event all affected machines will be fitted with a re-designed fuel tank mounting kit to prevent future problems. 392VL1500JS1AL111200100001JS1AL11120010051201/01/199831/12/1999
12/04/06R/2006/083RENAULT TRUCKS UK LTDMASTERPARKING BRAKE MAY FAILThe parking brake control levers on the rear calipers may not be to specificationRecall the vehicles that are likely to be affected to check the parking brake control levers on the rear calipers. Where the levers are not to specification replace the calipers.105OTS 1TGMASTER23/10/200526/01/2006
12/04/06RM/2005/029HONDA MOTORCYCLESVT750HEADLIGHT MAY EXTINGUISH UNEXPECTEDLYInsufficient contact between the terminals of the headlamp connector may lead to the headlamp failure.Recall the vehicles that are likely to be affected and fit new wiring loom and connectors192VT750JH2RC50A86M200072JH2RC50A06M20043715/09/200531/10/2005
12/04/06RM/2005/029HONDA MOTORCYCLESVT750HEADLIGHT MAY EXTINGUISH UNEXPECTEDLYInsufficient contact between the terminals of the headlamp connector may lead to the headlamp failure.Recall the vehicles that are likely to be affected and fit new wiring loom and connectors192VT750JH2RC50A65M104195JH2RC50A55M10535404/04/200511/07/2005
13/04/06R/2006/042IVECODAILYBRAKES MAY FAILThe left hand front brake pipe may chafe against the shock absorber which if left could result in brake operation being endangered.Recall the vehicles that are likely to be affected check the condition and path of the left hand front brake pipe. If necessary re-route or replace the brake pipe.1176RCT10DAILYZCFC35A100D257289ZCFC35A200D28404501/11/200431/07/2005
13/04/06R/2006/042IVECODAILYBRAKES MAY FAILThe left hand front brake pipe may chafe against the shock absorber which if left could result in brake operation being endangered.Recall the vehicles that are likely to be affected check the condition and path of the left hand front brake pipe. If necessary re-route or replace the brake pipe.1176RCT10DAILYZCFC35A2005513241ZCFC35C100555888801/11/200431/07/2005
17/04/06R/2006/084FERRARI360 SPIDERFUEL VAPOUR MAY LEAKIt has been identified that there is the possibility of a defect within the roll-over fuel shut off valves. The affected component may fracture allowing fuel vapour to be released.To address the concern Ferrari will replace the affected valves with a modified type.51360ZFFYT53C000131109ZFFYT53B000131857
19/04/06RM/2006/027LLEXETER LTDCTM50QT-7HANDLEBARS MAY BECOME LOOSEThe steering clamp bolt may not be torqued to specification which could eventually have an adverse affect on the directional control of the machine. Recall the vehicles that are likely to be affected and tighten the steering clamp bolt to specified torque setting.50CTM50QT-7
19/04/06R/2006/035SKODAOCTAVIA 11 WITH 2 LTR TDI ENGINE AND 6 SP MANUAL GEARBOXFLYWHEEL MAY FAIL RESULTING IN FIREIt has been identified that the two mass flywheel can become damaged because of a not optimally aligned through-flow restrictor in the clutch pressure pipe. This situation can lead to total failure of the flywheel and under unfavourable conditions a fireRecalled vehicles will have the make of the two mass flywheel identified and if necessary replaced together with the breather of the clutch pressure pipe.168713C9OCTAVIA 1101/02/200430/06/2005
24/04/06R/2006/044NISSANNAVARAREAR WHEEL BEARING MAY FAILA concern has been identified relating to the incorrect assembly of the rear axle. This may result in excessive wear of the wheel bearings which will lead to noise occurring from the rear axle. If this is not rectified the bearing may ultimately fail resulting in the assembly becoming detached from the axle.Recalled vehicles will be checked and fitted with new halfshafts as required.5812NAVARA128106753101/05/200531/12/2005
25/04/06R/2006/034FORDGALAXYFLYWHEEL MAY FAILThe Duel Mass Flywheel could fail in such a way that the friction pad and spring break through the duel mass flywheel housing. This could cause rough running noise and vibration and in extreme cases could result in transmission damage and localised burning of the engine under shield insulationRecall the vehicles that are likely to be affected and renew the Duel Mass Flyweheel and clutch assembly.20095c030GALAXY 01/11/200231/08/2003
26/04/06R/2006/072CITROENRELAYBRAKING MAY BE AFFECTEDBraking assistance could be adversely by freezing of moisture that may accumulate in the vacuum circuit.Recall the vehicles that may be affected and fit a separate air vent complete with filter to each electro valve fitted to the vacuum circuit.18387XVZRELAYVF7******17043335VF7******1757367526/03/200227/07/2005
02/05/06RM/2006/026KAWASAKIZX1000D6FSTEERING DAMPER BOLT MAY BECOME DETACHEDIt is possible that the steering damper mounting bolt may not have been correctly tightened during assembly. If not found this could lead to the bolt loosening and the steering damper detaching from the bracket allowing it to possibly interfere with the steering and creating the potential for an accident.Recall the vehicles that are likely to be affected to tighten the steering damper bolt to the correct torque and to check the play between the steering damper and bracket.1116ZX1000JKAZXT00DD000074JKAZXT00DDA018730
03/05/06R/2006/081CITROENC4FRONT AIRBAG MAY NOT DEPLOY AS DESIGNED IN A FRONTAL IMPACTIt has been identified that the front air bag ECU may not take full account of frontal impacts that are below the legal threshold for triggering deployment.Recalled vehicles will have the air bag ECU re-programmed. 25083XYDC4VF7******74132281VF7******7440254119/11/200412/01/2006
04/05/06RSPV/2006/007SUZUKI MOTORCYCLESLT-F400FMFUEL TANK MAY LEAKIt has been identified that a small number of fuel tanks were manufactured with a thinner then specified wall thickness. It is therefore possible that these fuel tanks may not withstand normal impacts and could leak fuel.Recalled machines will have their fuel tanks replaced with tanks having a wall thickness which meets the specification.40606LT-F400FM5SAAK46A4571060715SAAK46AX5710611001/02/200531/03/2005
04/05/06R/2006/086BMW6 seriesREAR TYRE MAY HAVE SUDDEN LOSS OF TYRE PRESSUREThere is a possibility that the tyres on the affected vehicles may have been damaged when they were fitted to the rim. If the tyres have been damaged this may lead to a sudden loss of pressure in the rear tyres.Recall the vehicles that are likely to be affected and replace all the tyres11S8514/02/200606/04/2006
04/05/06R/2006/086BMW6 seriesREAR TYRE MAY HAVE SUDDEN LOSS OF TYRE PRESSUREThere is a possibility that the tyres on the affected vehicles may have been damaged when they were fitted to the rim. If the tyres have been damaged this may lead to a sudden loss of pressure in the rear tyres.Recall the vehicles that are likely to be affected and replace all the tyres11M614/02/200606/04/2006
04/05/06R/2006/086BMW6 seriesREAR TYRE MAY HAVE SUDDEN LOSS OF TYRE PRESSUREThere is a possibility that the tyres on the affected vehicles may have been damaged when they were fitted to the rim. If the tyres have been damaged this may lead to a sudden loss of pressure in the rear tyres.Recall the vehicles that are likely to be affected and replace all the tyres11E6314/02/200606/04/2006
04/05/06R/2006/086BMW6 seriesREAR TYRE MAY HAVE SUDDEN LOSS OF TYRE PRESSUREThere is a possibility that the tyres on the affected vehicles may have been damaged when they were fitted to the rim. If the tyres have been damaged this may lead to a sudden loss of pressure in the rear tyres.Recall the vehicles that are likely to be affected and replace all the tyres116 SERIES14/02/200606/04/2006
06/05/06R/2006/080CITROENC8/DISPATCHSEATBELT MAY NOT OPERATE AS DESIGNEDThe seat belt locking action may not be as fast as it is designed to be.Recall the vehicles that may be affecte check the date of manufacture of the seat belts and where necessary replace the seat belts.39XYAC8VF7******13272643VF7******1327284704/01/200605/01/2006
06/05/06R/2006/080CITROENC8/DISPATCHSEATBELT MAY NOT OPERATE AS DESIGNEDThe seat belt locking action may not be as fast as it is designed to be.Recall the vehicles that may be affecte check the date of manufacture of the seat belts and where necessary replace the seat belts.39XYADISPATCHVF7******86247594VF7******8624853004/01/200606/01/2006
06/05/06R/2006/071CITROENC8BRAKING MAY BE AFFECTEDBraking assistance could be adversely affected by freezing of moisture that may accumulate in the vacuum circuit.Recall the vehicles that may be affected and fit a separate air vent complete with filter to each electro valve fitted to the vacuum circuit.5062XVZC8VF7******13094386VF7******1320205708/07/200329/11/2004
08/05/06R/2006/045RENAULTSCENICSEAT BELT STALK MAY DETACHIt is possible under certain conditions for the seatbelt stalk fixings on the first row of rear seats to become loose.Recall the vehicles that are likely to be affected to remove the bolts retaining the stalks of the affected seatbelts. Thread adhesive is to be applied to the bolts then the bolts are to be refitted and torqued.93289SCENIC01/02/200312/12/2005
10/05/06R/2006/089VOLVO CARXC90STEERING MAY FAILUnder continuous exceptionally hard use it is possible for the track rod end ball joint to fracture. In extreme cases this could lead to loss of steering control.Recall the vehicles that are likely to be affected to replace both the nearside and the offside outer track rod ends.18728r66021XC90
11/05/06R/2006/060SCANIA TRUCKR580POSSIBILITY OF A FUEL LEAKIt has been identified that fuel pipes may chafe against the induction and charge air pipe.Recalled vehicles will have the subject fuel pipe replaced and prevented from chafing against the induction and air charge pipes. 160304R SERIES351127351127
15/05/06R/2006/090VOLVO CARS40 AND V50FUEL MAY LEAK - POSSIBILITY OF FIREIt has been identified that the fuel line is sensitive to the extreme temperatures that occur in the area where the turbo and exhaust manifold are located. This can result in a fuel leak a non-start and in extreme cases a fire.Recalled vehicles will have the existing fuel line replaced with one made from Teflon which is capable of withstanding the extreme temperatures encountered.932S40
15/05/06R/2006/090VOLVO CARS40 AND V50FUEL MAY LEAK - POSSIBILITY OF FIREIt has been identified that the fuel line is sensitive to the extreme temperatures that occur in the area where the turbo and exhaust manifold are located. This can result in a fuel leak a non-start and in extreme cases a fire.Recalled vehicles will have the existing fuel line replaced with one made from Teflon which is capable of withstanding the extreme temperatures encountered.932V50
16/05/06RPC/2006/003MADISON CYCLESFRONT QUICK RELEASE MECHANISM WITH SILVER PLATED AXLEFRONT QUICK RELEASE MAY FAILIt has been identified that in certain cases it is possible that after the "quick release" as fitted to the front wheels of road and off-road bicycles has been locked into position the "quick release" axle could fail or break simultaneously. Should this occur the rider may lose control of the bicycle and injury might ensue.Subject bicycles will be recalled and have the "quick release" assembly replaced.3000FRONT QUICK RELEASE MECHANISM
17/05/06R/2006/052VAUXHALLMONARO AND MONARO VXRAIRBAG MAY INADVERTENTLY DEPLOYIn some circumstances there is a possibility that the side airbag may inadvertently deploy.Recall the vehicles that are likely to be affected and fit additional springs to the front seats so that any electrostatic discharge will correctly earthed.79906C009MONARO6G1VX14F84L1938586G1ZX14U15L525799
17/05/06R/2006/047SAAB9-3REDUCED BRAKING PERFORMANCEIt has been identified that under certain conditions a valve within the brake servo may have a shortened service life due to high ambient and engine bay temperatures. This could affect the functioning of the servo resulting in reduced braking performance Recalled vehicles will have the subject valve checked and replaced if necessary.21613150199-301/07/200230/03/2005
17/05/06R/2006/050VAUXHALLVectra CREAR SEAT CENTRE BELT MIGHT NOT RESTRAIN THE SEAT OCCUPANT IN A FRONTAL IMPACTIt has been identified that during the manufacturing process the lock bar may not have been fitted to the belt retractor. In the worst case the restraint function of the rear seat centre belt might not operate correctly in the case of a frontal impact.Recalled vehicles will have the rear centre seat belt inspected and replaced if necessary.1172VECTRA C01/01/200609/03/2006
22/05/06R/2006/099SCANIA BUSK94 L94 K114 and K124POSSIBILITY OF FIREThe grommets for the alternator protection fall out and the wires chafe against the alternator body. In the worst case fire could ensue.Recall the vehicles that are likely to be affected and where 140A alternators are fitted replace the protective casing grommets and plugs.201061601&061602K114
22/05/06R/2006/099SCANIA BUSK94 L94 K114 and K124POSSIBILITY OF FIREThe grommets for the alternator protection fall out and the wires chafe against the alternator body. In the worst case fire could ensue.Recall the vehicles that are likely to be affected and where 140A alternators are fitted replace the protective casing grommets and plugs.201061601&061602K124
22/05/06R/2006/099SCANIA BUSK94 L94 K114 and K124POSSIBILITY OF FIREThe grommets for the alternator protection fall out and the wires chafe against the alternator body. In the worst case fire could ensue.Recall the vehicles that are likely to be affected and where 140A alternators are fitted replace the protective casing grommets and plugs.201061601&061602K94
22/05/06R/2006/099SCANIA BUSK94 L94 K114 and K124POSSIBILITY OF FIREThe grommets for the alternator protection fall out and the wires chafe against the alternator body. In the worst case fire could ensue.Recall the vehicles that are likely to be affected and where 140A alternators are fitted replace the protective casing grommets and plugs.201061601&061602L94
23/05/06R/2006/028NISSANZ50 MuranoPOSSIBLE DAMAGE TO FUEL TANKIn the event of a front tyre travelling over a sharp object the object could be propelled towards the rear of the vehicle and possibly damage the front edge of the fuel tank. Recalled vehicles will have a protective shield fitted to the fuel tank vulnerable area.1684MURANOJN1TANZ50U0000042JN1TANZ50U001285201/04/200230/11/2005
23/05/06R/2006/028NISSANZ50 MuranoPOSSIBLE DAMAGE TO FUEL TANKIn the event of a front tyre travelling over a sharp object the object could be propelled towards the rear of the vehicle and possibly damage the front edge of the fuel tank. Recalled vehicles will have a protective shield fitted to the fuel tank vulnerable area.1684Z50 MURANOJN1TANZ50U0000042JN1TANZ50U001285201/04/200230/11/2005
23/05/06R/2006/029NISSANZ50 Murano REAR SEAT BELT WEBBING MAY BE DAMAGED IN A FRONTAL IMPACTThere is a possibility that during a frontal impact and under specific circumstances the rear seat belt webbing may be damaged. This could increase the risk of injury to an occupant during an impact. Recalled vehicles will have a protector fitted to the affected seat belt area.1434Z50 MURANOJN1***Z50U0000042JNI***Z50U000939701/04/200201/07/2005
23/05/06R/2006/029NISSANZ50 Murano REAR SEAT BELT WEBBING MAY BE DAMAGED IN A FRONTAL IMPACTThere is a possibility that during a frontal impact and under specific circumstances the rear seat belt webbing may be damaged. This could increase the risk of injury to an occupant during an impact. Recalled vehicles will have a protector fitted to the affected seat belt area.1434MURANOJN1TANZ50U0000042JN1TANZ50U000939701/04/200231/07/2005
23/05/06R/2006/100VOLVO TRUCKFH/FMBRAKES MAY OVERHEATOn axles with parking brake it has been found that some brakes are binding which can cause overheating of the brakes.Recall the vehicles that are likely to be affected and replace the brake pads.1044FH
23/05/06R/2006/100VOLVO TRUCKFH/FMBRAKES MAY OVERHEATOn axles with parking brake it has been found that some brakes are binding which can cause overheating of the brakes.Recall the vehicles that are likely to be affected and replace the brake pads.1044FM
23/05/06R/2010/183MERCEDES BENZUNIMOGCLUTCH MAY FAILThe possibility exists that on a certain number of vehicles air pockets can build up in the clutch hydraulics system which will lead to difficulty in changing gear and selecting neutral..Recall the vehicles that are likely to be affected to replace the central clutch release bearing the bracket for the clutch booster and the clutch control unit.7U006UNIMOG
26/05/06R/2006/062TATASafari 4x4/4x2 (Airbag Version)POSSIBLE LOSS OF STEERING CONTROL.There is a possibility of welds cracking on the steering wheel. In extreme circumstances if the symptoms are ignored the cracks can progress into total separation causing loss of steering control.Recall the vehicles that are likely to be affected and replace the steering wheel with a redesigned steering wheel.438SAFARI01/06/200328/03/2005
29/05/06RCOMP/2006/004FASTER BY DESIGNROLL-A-CLICK FRONT BRAKE LEVERBRAKES MAY SEIZE ONIt has been identified that the front brake lever rocker may have been fitted with components which are significantly out of line. In the worst case this could result in the brake lever becoming seized in the brake applied position thus preventing the front brakes from being released. With the potential for an accident to occur. Recalled machines will be fitted with a replacement rocker or the front brake lever.99 RB-512
29/05/06RCOMP/2006/004FASTER BY DESIGNROLL-A-CLICK FRONT BRAKE LEVERBRAKES MAY SEIZE ONIt has been identified that the front brake lever rocker may have been fitted with components which are significantly out of line. In the worst case this could result in the brake lever becoming seized in the brake applied position thus preventing the front brakes from being released. With the potential for an accident to occur. Recalled machines will be fitted with a replacement rocker or the front brake lever.99RB-511
30/05/06RM/2006/029KAWASAKIZX1400A6FENGINE MAY STALLThe mounting bolts of the vehicle down sensor may loosen and in the worst case the down sensor may detach from the bracket causing the engine to stall whilst being ridden or the engine not to cut out in the event of a fall.Recall the vehicles that are likely to be affected and tighten the down sensor mounting bolts to the specified torque.258ZX1400A6FJKBZXT40AAA000065JKBZXT40AAA007624
01/06/06R/2006/156EAST LANCSMYLLENNIUMHOT WATER MAY ENTER SALOONA steel clip which secures an interior heater pipe has a rubber sleeve bonded to it which protects it against chafing on it's carrier bracket. On a small number of vehicles this sleeve has moved causing the bracket to cut into the heater pipe with subsequent loss of coolant Recalled vehicles will have the piping checked and replaced together with the carrier bracket as necessary.46MYLLENNIUM
01/06/06RM/2006/022BMW MOTORCYCLESK1200 RABS MAY FAILIn certain exceptional circumstances (constant use of the ABS) it is possible for the ABS to stop functioning. This is as a result of excessive pressure building up in the ABS system.Recall the machines that are likely to be affected and fit modified brake discs which will decrease the volume in the brake system caused by very high temperatures and thereby discourage the 'overpressure' effect.8463K SERIES
02/06/06R/2006/055MANA51 A66 AND A76STEERING MAY FAILIt has been identified that the connection between the steering shaft and the fork on the steering propshaft may work loose. This if ignored it has the potential to cause the steering to fail.Subject vehicles will have the steering shafts checked and replaced as necessary.78185004A51
02/06/06R/2006/055MANA51 A66 AND A76STEERING MAY FAILIt has been identified that the connection between the steering shaft and the fork on the steering propshaft may work loose. This if ignored it has the potential to cause the steering to fail.Subject vehicles will have the steering shafts checked and replaced as necessary.78185004A76
02/06/06R/2006/055MANA51 A66 AND A76STEERING MAY FAILIt has been identified that the connection between the steering shaft and the fork on the steering propshaft may work loose. This if ignored it has the potential to cause the steering to fail.Subject vehicles will have the steering shafts checked and replaced as necessary.78185004A66
02/06/06R/2006/058VWSHARAN 1.9L TDITWIN-MASS FLYWHEEL MAY FAIL AND RESULT IN A VEHICLE FIREIt has been advised that the twin-mass flywheel can become damaged because of poor internal installation. This can result in a failure of the twin-mass flywheel and under unfavourable circumstances a vehicle fire.Recalled vehicles will have the twin-mass flywheel replaced.152113C3SHARANWVW0007M03V000781WVW0007M03V06095001/11/200231/08/2003
02/06/06R/2006/058VWSHARAN 1.9L TDITWIN-MASS FLYWHEEL MAY FAIL AND RESULT IN A VEHICLE FIREIt has been advised that the twin-mass flywheel can become damaged because of poor internal installation. This can result in a failure of the twin-mass flywheel and under unfavourable circumstances a vehicle fire.Recalled vehicles will have the twin-mass flywheel replaced.152113C3SHARANWVW0007M04V000001WVW0007M00V01132501/11/200231/08/2003
02/06/06R/2006/059SEATALHAMBRA 1.9L TDITWIN-MASS FLYWHEEL MAY FAIL AND RESULT IN A VEHICLE FIREIt has been advised that the twin-mass flywheel can become damaged because of poor internal installation. This can result in a failure of the twin-mass flywheel and under unfavourable circumstances a vehicle fire.Recalled vehicles will have the twin-mass flywheel replaced.108513S3ALHAMBRAVSS0007M03V509111VSS0007M03V52773701/11/200231/08/2003
02/06/06R/2006/059SEATALHAMBRA 1.9L TDITWIN-MASS FLYWHEEL MAY FAIL AND RESULT IN A VEHICLE FIREIt has been advised that the twin-mass flywheel can become damaged because of poor internal installation. This can result in a failure of the twin-mass flywheel and under unfavourable circumstances a vehicle fire.Recalled vehicles will have the twin-mass flywheel replaced.108513S3ALHAMBRAVSS0007M04V500002VSS0007M04V50559301/11/200231/08/2003
02/06/06R/2006/094MANL2000-TGL & F2000 TGA Specialized VehiclesSTEERING MAY FAILIt has been identified that the connection between the steering shaft and the fork on the steering propshaft may work loose. This if ignored has the potential to cause the steering to fail.Subject vehicle will have the steering shafts checked and replaced as necessary.1638185004enTG-A01/01/200417/05/2006
02/06/06R/2006/094MANL2000-TGL & F2000 TGA Specialized VehiclesSTEERING MAY FAILIt has been identified that the connection between the steering shaft and the fork on the steering propshaft may work loose. This if ignored has the potential to cause the steering to fail.Subject vehicle will have the steering shafts checked and replaced as necessary.1638185004enL200001/01/200417/05/2006
02/06/06R/2006/094MANL2000-TGL & F2000 TGA Specialized VehiclesSTEERING MAY FAILIt has been identified that the connection between the steering shaft and the fork on the steering propshaft may work loose. This if ignored has the potential to cause the steering to fail.Subject vehicle will have the steering shafts checked and replaced as necessary.1638185004enF200001/01/200417/05/2006
02/06/06R/2006/094MANL2000-TGL & F2000 TGA Specialized VehiclesSTEERING MAY FAILIt has been identified that the connection between the steering shaft and the fork on the steering propshaft may work loose. This if ignored has the potential to cause the steering to fail.Subject vehicle will have the steering shafts checked and replaced as necessary.1638185004enTGL01/01/200417/05/2006
02/06/06R/2006/039NISSANT30 - X-TRAILFUEL MAY LEAKThere is a possibility that the fuel tank filler tube may rust around the mounting bracket. This may create a small hole through progression of rust and fuel may leak during the refuelling process.Recalled vehicles will have the fuel filler tube replaced.27869X-TRAIL720000901/06/200023/11/2004
02/06/06R/2006/104PEUGEOT407 COUPE & 607 ENGINE TYPE DT17ENGINE MAY STALLIt is possible that the engine may stall when lifting your foot off of the accelerator immediately after high speed usage of the vehicle.Recall the vehicles that are likely to be affected to download a new piece of software to the engine ECU.635YBK407 COUPE
02/06/06R/2006/104PEUGEOT407 COUPE & 607 ENGINE TYPE DT17ENGINE MAY STALLIt is possible that the engine may stall when lifting your foot off of the accelerator immediately after high speed usage of the vehicle.Recall the vehicles that are likely to be affected to download a new piece of software to the engine ECU.635YBK607
05/06/06R/2006/116PEUGEOT307 (WITH EW10J4S ENGINE)REAR AXLE FIXING BOLTS MAY BECOME LOOSEThe quality of the welding at the suspension mounting reinforcement plates may not be to specification.Recall the vehicles that are likely to be affected and check the welding. Where necessary take corrective action to ensure that the reinforcement plate welding operation has been correctly completed.221YBJ307
06/06/06R/2006/049TOYOTARAV4ROAD WHEEL SPOKES MAY CRACK AND SEPARATEIt has been identified that steel wheels of insufficient strength have been fitted to some grades of RAV4 vehicles fitted with diesel engines. The possibility then exist that a crack may appear on the spoke(s) of the wheel which in the worst case could cause the spoke to separate. Affected vehicles will have their wheels replaced with those of an improved quality.851RAV4JTEYG20V#00001271JTEYG20V#0002607504/07/200115/09/2004
06/06/06R/2006/049TOYOTARAV4ROAD WHEEL SPOKES MAY CRACK AND SEPARATEIt has been identified that steel wheels of insufficient strength have been fitted to some grades of RAV4 vehicles fitted with diesel engines. The possibility then exist that a crack may appear on the spoke(s) of the wheel which in the worst case could cause the spoke to separate. Affected vehicles will have their wheels replaced with those of an improved quality.851RAV4JTEHG20V#00002183JTEHG20V#0007503104/07/200115/09/2004
07/06/06R/2006/069LAND ROVERDiscovery 3 Petrol VariantFUEL MAY LEAKIt has been identified that on vehicles fitted with fuel tanks which incorporate an internal breather pipe the breather pipe may not be to specification. This may result in swelling and cracking of a grommet and detachment of the breather pipe from a connector tube. In this condition fuel may enter the breather pipe resulting in MIL illumination fuel odour and drivability concerns such as hesitation misfiring stalling rough running or difficult starting. In the worst case fuel may be discharged onto the ground.Recall affected vehicles and replace the fuel tank.590A016DISCOVERYSALLAAA545A000360SALLAAA445A34282702/07/200430/04/2005
08/06/06R/2006/095CITROENPicassoENGINE MAY FAILIt has been identified that on a small number of vehicles the engine may have been fitted with a cylinder head where the lubrication circuit is not in conformity. This could result in failure of the engine.Recalled vehicles will have the marking on the camshaft carrier checked and if found to be within the effected range the engine will be replaced. 127PICASSOVF7******39696951VF7******3973503927/02/200403/05/2004
12/06/06R/2006/079LAND ROVERRANGE ROVER SPORTBRAKE HOSE ABS AND PAD SENSOR LEADS MAY CHAFE ON WHEEL BALANCE WEIGHTSIt is possible for the wheel balance weights to foul the left front brake hose and/or the ABS wheel speed sensor and/or the brake pad wear warning sensor.Recall the vehicles that are likely to be affected to fit stick on wheel balance weights in place of the clamp on weights. A handbook supplement will also be produced stating the requirement for stick on weights.6226RANGE ROVER SPORTSALLSAA546A900109SALLSAA546A94910801/01/200513/02/2006
12/06/06R/2006/078RENAULTMEGANE II AND SCENIC IIBRAKES MAY FAILIt has been identified that the possibility exists that the stop for the foot brake pedal collapse system is missing. This can result in the loss of braking efficiency when the brake pedal is at full travel.Recalled vehicles will be inspected for the presence of the brake pedal collapse system stop and where this is found to be missing the brake pedal will be replaced.57995OANYSCENICVF1BM0B0H26984075VF1BM0F052957452601/09/200321/01/2004
12/06/06R/2006/078RENAULTMEGANE II AND SCENIC IIBRAKES MAY FAILIt has been identified that the possibility exists that the stop for the foot brake pedal collapse system is missing. This can result in the loss of braking efficiency when the brake pedal is at full travel.Recalled vehicles will be inspected for the presence of the brake pedal collapse system stop and where this is found to be missing the brake pedal will be replaced.57995OANYMEGANEVF1BM0B0H26984075VF1BM0F052957452601/09/200212/02/2004
14/06/06R/2006/088VAUXHALLVectra C and SignumHEATED WASHER NOZZLE MAY SHORT CIRCUITIt is possible that moisture may enter the heated washer nozzle housing and cause a short circuit of the heating elements. In the worse case a fire may ensue.Recall the vehicles that are likely to be affected to disconnect the heated washer nozzle housings.122006C014VECTRA C01/01/200430/12/2006
14/06/06R/2006/065TOYOTALexus 5. GS300/430/IS220d/IS250FRONT SEAT BELT LOCKING SYSTEM MAY NOT RELEASE WHEN ACTIVATED. Some front seat belt retractors when the emergency lock has been applied will not release. If the seat belt is locked in this manner the seat belt will not adjust for the next occupant.Recall the vehicles that are likely to be affected and replace the front seat belt assemblies.4038LEXUSJTHBB2*6202000030JTHBB2*620200180601/09/200531/01/2006
14/06/06R/2006/065TOYOTALexus 5. GS300/430/IS220d/IS250FRONT SEAT BELT LOCKING SYSTEM MAY NOT RELEASE WHEN ACTIVATED. Some front seat belt retractors when the emergency lock has been applied will not release. If the seat belt is locked in this manner the seat belt will not adjust for the next occupant.Recall the vehicles that are likely to be affected and replace the front seat belt assemblies.4038LEXUSJTHBK262*02000011JTHBK262*0200690201/09/200531/01/2006
14/06/06R/2006/065TOYOTALexus 5. GS300/430/IS220d/IS250FRONT SEAT BELT LOCKING SYSTEM MAY NOT RELEASE WHEN ACTIVATED. Some front seat belt retractors when the emergency lock has been applied will not release. If the seat belt is locked in this manner the seat belt will not adjust for the next occupant.Recall the vehicles that are likely to be affected and replace the front seat belt assemblies.4038LEXUSJYHBK262*05000019JTHBK252*0500905501/09/200531/01/2006
14/06/06R/2006/065TOYOTALexus 5. GS300/430/IS220d/IS250FRONT SEAT BELT LOCKING SYSTEM MAY NOT RELEASE WHEN ACTIVATED. Some front seat belt retractors when the emergency lock has been applied will not release. If the seat belt is locked in this manner the seat belt will not adjust for the next occupant.Recall the vehicles that are likely to be affected and replace the front seat belt assemblies.4038LEXUSJTHBN96S*05007528JTHBN96S*0501241401/07/200531/01/2006
14/06/06R/2006/065TOYOTALexus 5. GS300/430/IS220d/IS250FRONT SEAT BELT LOCKING SYSTEM MAY NOT RELEASE WHEN ACTIVATED. Some front seat belt retractors when the emergency lock has been applied will not release. If the seat belt is locked in this manner the seat belt will not adjust for the next occupant.Recall the vehicles that are likely to be affected and replace the front seat belt assemblies.4038LEXUSJTHBH96S*05018448JTHBH96S*0503098601/07/200531/01/2006
20/06/06RCOMP/2006/007WABCO-PERROTSAF AXLES B19-22W01 - RIGID BINL9-22W01 - TRAILING STEERING AXLE BIVL9-22W01 - LEADING STEERING AXLE BRAKES MAY FAIL TO APPLY OR MAY APPLY INADVERTENTLYIt has been identified that a disconnection of the air intake port may ocurr during service brake application. This can affect the correct functioning of the service brake and may cause the parking brake to apply inadvertently. Recalled vehicles will have the brake assemblies replaced.97BIVL9-22W01
20/06/06RCOMP/2006/007WABCO-PERROTSAF AXLES B19-22W01 - RIGID BINL9-22W01 - TRAILING STEERING AXLE BIVL9-22W01 - LEADING STEERING AXLE BRAKES MAY FAIL TO APPLY OR MAY APPLY INADVERTENTLYIt has been identified that a disconnection of the air intake port may ocurr during service brake application. This can affect the correct functioning of the service brake and may cause the parking brake to apply inadvertently. Recalled vehicles will have the brake assemblies replaced.97B19-22WO1
20/06/06RCOMP/2006/007WABCO-PERROTSAF AXLES B19-22W01 - RIGID BINL9-22W01 - TRAILING STEERING AXLE BIVL9-22W01 - LEADING STEERING AXLE BRAKES MAY FAIL TO APPLY OR MAY APPLY INADVERTENTLYIt has been identified that a disconnection of the air intake port may ocurr during service brake application. This can affect the correct functioning of the service brake and may cause the parking brake to apply inadvertently. Recalled vehicles will have the brake assemblies replaced.97BINL9-22W01
21/06/06R/2010/182MERCEDES BENZActros Atego and AxorSEAT MAY BECOME INSECUREThe threaded connection of the Grammer seat centre bearing may become loose which could overlaod the seat frame and cause it to fracture and fail.Recall all affected vehicles to have the seat checked repaired or replaced.2258C077AXOR
21/06/06R/2010/182MERCEDES BENZActros Atego and AxorSEAT MAY BECOME INSECUREThe threaded connection of the Grammer seat centre bearing may become loose which could overlaod the seat frame and cause it to fracture and fail.Recall all affected vehicles to have the seat checked repaired or replaced.2258C077ATEGO
21/06/06R/2010/182MERCEDES BENZActros Atego and AxorSEAT MAY BECOME INSECUREThe threaded connection of the Grammer seat centre bearing may become loose which could overlaod the seat frame and cause it to fracture and fail.Recall all affected vehicles to have the seat checked repaired or replaced.2258C077ACTROS RANGE
21/06/06R/2006/108DAFCF AND XFPARKING BRAKE MAY APPLY INADVERTENTLLYThere is a possibility that the clamp ring connecting the brake hose of the parking brake relay valve on the rear axle may have been fitted incorrectly. Should the hose detach the spring parking brake would inadvertently apply.Recalled vehicles will have the position of the clamp ring checked. If found to be incorrect the hose will be cut to the required length and fitted with a new clamp ring and reinforcing sleeve.998334XF01/09/200431/12/2004
21/06/06R/2006/108DAFCF AND XFPARKING BRAKE MAY APPLY INADVERTENTLLYThere is a possibility that the clamp ring connecting the brake hose of the parking brake relay valve on the rear axle may have been fitted incorrectly. Should the hose detach the spring parking brake would inadvertently apply.Recalled vehicles will have the position of the clamp ring checked. If found to be incorrect the hose will be cut to the required length and fitted with a new clamp ring and reinforcing sleeve.998334CF01/09/200431/12/2004
26/06/06R/2010/184MERCEDES BENZSprinterSEAT BELT MAY BECOME INSECUREIt is possible that the mounting bolts for rear seat belts on the rear seats may not have been torqued to the correct specification.Recall all affected vehicles to check and if necessary re-torque the mounting bolts.1C079SPRINTER
26/06/06RM/2006/030APRILIARSV1000SWING ARM MAY CRACKIt is possible that the rear swinging arm could crack.Recall the vehicles that are likely to be affected and replace the swinging arm.1892RSV1000
29/06/06RCOMP/2007/003TRUMA GERAETETECHNICK GMBHBLOWN HOT AIR HEATER - Models C3402 E C4002 E C6002 E and C6002 EHHEATER MAY OVERHEATIt has been identified that the potential exists for an over-heat situation within the unit which may be too great for the heat circulation fan housing This could cause the plastic material from which the housing is made to deform or in extreme circumstances to melt.Subject heaters will be recalled and replaced with units whose fan housing plastics are constructed from a more substantial material. Additionally a heat shield will be added within the heater body.2135C6002 (EL)
29/06/06RCOMP/2007/003TRUMA GERAETETECHNICK GMBHBLOWN HOT AIR HEATER - Models C3402 E C4002 E C6002 E and C6002 EHHEATER MAY OVERHEATIt has been identified that the potential exists for an over-heat situation within the unit which may be too great for the heat circulation fan housing This could cause the plastic material from which the housing is made to deform or in extreme circumstances to melt.Subject heaters will be recalled and replaced with units whose fan housing plastics are constructed from a more substantial material. Additionally a heat shield will be added within the heater body.2135C6002EH
29/06/06RCOMP/2007/003TRUMA GERAETETECHNICK GMBHBLOWN HOT AIR HEATER - Models C3402 E C4002 E C6002 E and C6002 EHHEATER MAY OVERHEATIt has been identified that the potential exists for an over-heat situation within the unit which may be too great for the heat circulation fan housing This could cause the plastic material from which the housing is made to deform or in extreme circumstances to melt.Subject heaters will be recalled and replaced with units whose fan housing plastics are constructed from a more substantial material. Additionally a heat shield will be added within the heater body.21354002 (EL)
29/06/06RCOMP/2007/003TRUMA GERAETETECHNICK GMBHBLOWN HOT AIR HEATER - Models C3402 E C4002 E C6002 E and C6002 EHHEATER MAY OVERHEATIt has been identified that the potential exists for an over-heat situation within the unit which may be too great for the heat circulation fan housing This could cause the plastic material from which the housing is made to deform or in extreme circumstances to melt.Subject heaters will be recalled and replaced with units whose fan housing plastics are constructed from a more substantial material. Additionally a heat shield will be added within the heater body.2135C3402 (EL)
04/07/06RSPV/2006/012MCCORMICK TRACTORS LTDMC AND MTX (WITH SPEED SEQUENCER)DRIVE MAY BE TAKEN UP WHILST IN NEUTRALUnder certain circumstances if the tractor is left with the engine running and the speed sequencer engaged it is possible for the drive to take up and the tractor to move.A revised operating procedure for dismounting the tractor is to be sent to the tractor owners with an explanatory letter. Also a decal is provided to inform the user to select neutral on the speed sequencer and also how to select neutral. This is to be mounted next to the sequencer.117MC
04/07/06RSPV/2006/012MCCORMICK TRACTORS LTDMC AND MTX (WITH SPEED SEQUENCER)DRIVE MAY BE TAKEN UP WHILST IN NEUTRALUnder certain circumstances if the tractor is left with the engine running and the speed sequencer engaged it is possible for the drive to take up and the tractor to move.A revised operating procedure for dismounting the tractor is to be sent to the tractor owners with an explanatory letter. Also a decal is provided to inform the user to select neutral on the speed sequencer and also how to select neutral. This is to be mounted next to the sequencer.117MTX
05/07/06RSPV/2006/010AUTO-SLEEPERS LTDSYMBOL SYMBOL ES DORSET AND PAVOSEATBELT MAY FAILIt has been identified that during production a spacer has been omitted from the nearside forward facing bed box seatbelt. This over time may cause the seatbelt to wear against the mounting bracket.Recalled vehicles will be fitted with a replacement seatbelt and spacer.84SYMBOL AND ES
05/07/06RSPV/2006/010AUTO-SLEEPERS LTDSYMBOL SYMBOL ES DORSET AND PAVOSEATBELT MAY FAILIt has been identified that during production a spacer has been omitted from the nearside forward facing bed box seatbelt. This over time may cause the seatbelt to wear against the mounting bracket.Recalled vehicles will be fitted with a replacement seatbelt and spacer.84PAVO
05/07/06RSPV/2006/010AUTO-SLEEPERS LTDSYMBOL SYMBOL ES DORSET AND PAVOSEATBELT MAY FAILIt has been identified that during production a spacer has been omitted from the nearside forward facing bed box seatbelt. This over time may cause the seatbelt to wear against the mounting bracket.Recalled vehicles will be fitted with a replacement seatbelt and spacer.84DORSET
05/07/06R/2006/092FORDFOCUS C-MAX WTH 1/6L DIESEL ENGINEENGINE MAY FAILIt has been identified that a batch of engines have misaligned oil feed holes between the cylinder head and the camshaft bearings. The reduced oil flow could cause premature wear of the camshaft bearings and may also result in seizure of the engine without prior warning.Recalled vehicles will be checked by dealers for the presence of the relevant build code and the engine will be renewed if it is within the specified range. 1676C041FOCUS C MAX27/02/200428/06/2004
06/07/06R/2006/119BMW5 6 AND 7 SERIESREAR SHOCK ABSORBER MOUNTING MAY FAILIt has been identified that the lower rubber mounting on the metal bush of the rear shock absorbers may fail to meet the quality requirement. Dependant on the mileage and operating conditions the rubber mounting may come completely free from the shock absorber. If this occurs the bodywork would no longer be supported above the wheels causing it to come into contact with the wheel concerned. Should this occur the possibility exists that a critical driving condition might occur or even the risk of an accident.Recalled vehicles will have the rear shock absorbers checked and replaced if necessary.37437 SERIES
06/07/06R/2006/119BMW5 6 AND 7 SERIESREAR SHOCK ABSORBER MOUNTING MAY FAILIt has been identified that the lower rubber mounting on the metal bush of the rear shock absorbers may fail to meet the quality requirement. Dependant on the mileage and operating conditions the rubber mounting may come completely free from the shock absorber. If this occurs the bodywork would no longer be supported above the wheels causing it to come into contact with the wheel concerned. Should this occur the possibility exists that a critical driving condition might occur or even the risk of an accident.Recalled vehicles will have the rear shock absorbers checked and replaced if necessary.37436 SERIES
06/07/06R/2006/119BMW5 6 AND 7 SERIESREAR SHOCK ABSORBER MOUNTING MAY FAILIt has been identified that the lower rubber mounting on the metal bush of the rear shock absorbers may fail to meet the quality requirement. Dependant on the mileage and operating conditions the rubber mounting may come completely free from the shock absorber. If this occurs the bodywork would no longer be supported above the wheels causing it to come into contact with the wheel concerned. Should this occur the possibility exists that a critical driving condition might occur or even the risk of an accident.Recalled vehicles will have the rear shock absorbers checked and replaced if necessary.37435 SERIES
10/07/06R/2006/113MERCEDES BENZ BUSCC/TC 400 ANF TOUROSUSPENSION MAY CRACKThere is a possibility of the front wishbones cracking which if ignored could in the worst case lead to front suspension detachment.Recall the vehicles that are likely to be affected to carry out a specific check sequence and then to inspect the wishbones. Where any signs of cracking is found both the wishbones are to be replaced.93TC400WEB63420323000165WKK6321342310175301/01/200531/12/2006
10/07/06R/2006/113MERCEDES BENZ BUSCC/TC 400 ANF TOUROSUSPENSION MAY CRACKThere is a possibility of the front wishbones cracking which if ignored could in the worst case lead to front suspension detachment.Recall the vehicles that are likely to be affected to carry out a specific check sequence and then to inspect the wishbones. Where any signs of cracking is found both the wishbones are to be replaced.93TOUROWEB634203223000165WKK6321342310175301/01/200531/12/2006
10/07/06R/2006/113MERCEDES BENZ BUSCC/TC 400 ANF TOUROSUSPENSION MAY CRACKThere is a possibility of the front wishbones cracking which if ignored could in the worst case lead to front suspension detachment.Recall the vehicles that are likely to be affected to carry out a specific check sequence and then to inspect the wishbones. Where any signs of cracking is found both the wishbones are to be replaced.93CC400WEB63420323000165WKK6321342310175301/01/200531/12/2006
10/07/06R/2006/124VOLVO TRUCKFH/FMEXHAUST FUMES MAY ENTER THE CABIt is possible for the exhaust pipe of the parking heater to be squeezed and restricted which could result in exhaust fumes entering the cab.Recall the vehicles that are likely to be affected to replace the exhaust pipe and clamp. Additionally the drain hole on the exhaust silencer is to be closed.27FM
10/07/06R/2006/124VOLVO TRUCKFH/FMEXHAUST FUMES MAY ENTER THE CABIt is possible for the exhaust pipe of the parking heater to be squeezed and restricted which could result in exhaust fumes entering the cab.Recall the vehicles that are likely to be affected to replace the exhaust pipe and clamp. Additionally the drain hole on the exhaust silencer is to be closed.27FH
12/07/06R/2006/127RENAULT TRUCKS UK LTDMIDLUM EURO 2RISK OF ENGINE WIRING LOOM SHORT CIRCUITIt has been identified that the risk of a short circuit exists between individual wires of the engine wiring loom.Recalled vehicles will have the engine wiring loom checked for condition and wear and will proceed as follows. If no wiring cores are visible a protective sheath will be fitted to the wiring loom. If the core of one or more of the wires is visible the wiring loom will be replaced. 11001ABMIDLUM
12/07/06R/2006/070CADILLACCHEVROLET CORVETTE (AUTOMATIC AND MANUAL) STEERING MAY LOCKOn identified models it has been established that under certain conditions the steering locking mechanism may operate whilst the vehicle is being driven. Recalled vehicles will have the control module reprogrammed and checks made to ensure adequate lock plate clearance. If necessary the lock plate will be replaced. 62CHEVROLET
14/07/06RSPV/2006/009SUZUKI MOTORCYCLESLT-R450 K6FRAME MAY CRACK AND DETACHIt has been identified that there may be a weld of insufficient strength joining a mounting bush to the attachment bracket of the main rear suspension pivot. The circular bush is joined by two opposing welds of approximately a quarter of the circumference each. Under heavy use the welds can develop a fracture and prolonged use in this condition can lead to detachment.Recalled machines whether displaying the concern or not will have the brackets over-welded around the full circumference of the bush. In cases where the fracture has opened up a modified frame will be fitted.135610LT-R450JSAAL41*622102930JSAAL41A*622108361
17/07/06R/2006/118FORDS-MAX AND GALAXYPOSSIBILITY OF ENGINE CUT OUTIt has been identified that the fuel pipe connector between the engine fuel line and fuel tank may not be totalled secured. This may result in a disconnection of the fuel line with the possibility of engine cut out and loss of fuel onto the road surface. Whilst the vehicle is in the dealership the opportunity will be taken to carry out a slight modification to the alternator to prevent the possibility of a short circuit occurring with other components.Recalled vehicles will have the integrity of the fuel line connector checked. Additionally the alternator cable will be modified by removing a portion of sleeving that may be in contact with the end eyelet.209S-MAX01/02/200611/06/2006
17/07/06R/2006/118FORDS-MAX AND GALAXYPOSSIBILITY OF ENGINE CUT OUTIt has been identified that the fuel pipe connector between the engine fuel line and fuel tank may not be totalled secured. This may result in a disconnection of the fuel line with the possibility of engine cut out and loss of fuel onto the road surface. Whilst the vehicle is in the dealership the opportunity will be taken to carry out a slight modification to the alternator to prevent the possibility of a short circuit occurring with other components.Recalled vehicles will have the integrity of the fuel line connector checked. Additionally the alternator cable will be modified by removing a portion of sleeving that may be in contact with the end eyelet.209GALAXY 01/02/200611/06/2006
20/07/06RM/2006/031HARLEY DAVIDSONSPORTSTER 883R AND 1200RFRONT BRAKE ACTUATED STOP LIGHT MAY REMAIN ILLUMINATEDCertain 2203/2004 883R & 1200R Sportster motorcycles may have a fault which leaves the brake light illuminated after the release of the front brake lever.Recalled machines will have the front brake master cylinder seal replaced.588125SPORTSTER25/06/200303/06/2005
21/07/06R/2006/098MAZDA5 & 6 Fitted with MZR-CD diesel engine.ENGINE MAY STALL.It is possible for the camshaft sensor plate mounting bolts to loosen. If the vehicle continues to be used in this condition the sensor plate and bolts may fall off resulting in an engine stall and inability to restart.Recall the vehicles that are likely to be affected and tighten the sensor plate to the specified torque. Only replace parts if they are seen to be damaged.20056JMZGG******627347JMZGG******64500103/10/200529/12/2005
21/07/06R/2006/098MAZDA5 & 6 Fitted with MZR-CD diesel engine.ENGINE MAY STALL.It is possible for the camshaft sensor plate mounting bolts to loosen. If the vehicle continues to be used in this condition the sensor plate and bolts may fall off resulting in an engine stall and inability to restart.Recall the vehicles that are likely to be affected and tighten the sensor plate to the specified torque. Only replace parts if they are seen to be damaged.20056 EstateJMZGY******412057JMZGY******42101503/10/200529/12/2005
21/07/06R/2006/098MAZDA5 & 6 Fitted with MZR-CD diesel engine.ENGINE MAY STALL.It is possible for the camshaft sensor plate mounting bolts to loosen. If the vehicle continues to be used in this condition the sensor plate and bolts may fall off resulting in an engine stall and inability to restart.Recall the vehicles that are likely to be affected and tighten the sensor plate to the specified torque. Only replace parts if they are seen to be damaged.20055JMZCR******122851JMZCR******13384403/10/200529/12/2005
24/07/06R/2006/053IVECODAILY S 2000POSSIBLE OF LOSS OF POWER STEERINGThe possibility exists that power steering may be lost due to chafing of the power steering fluid pipes.Recalled vehicles will be fitted with clips; and a spacer to separate the power steering fluid pipes.27891RCT12DAILYZCFC509000D087153ZCFC65A000D30079012/02/199924/01/2006
24/07/06R/2006/053IVECODAILY S 2000POSSIBLE OF LOSS OF POWER STEERINGThe possibility exists that power steering may be lost due to chafing of the power steering fluid pipes.Recalled vehicles will be fitted with clips; and a spacer to separate the power steering fluid pipes.27891RCT12DAILYZCFC3572005209727ZCFC65A000558216928/04/199909/12/2005
24/07/06R/2006/102CADILLACSRXSUSPENSION MAY SEPARATERear suspension toe link assembly could separate and vehicle control could be compromised.Recall the vehicles that are likely to be affected to inspect the number on the toe link assemblies and where necessary replace the assembly.6SRX
25/07/06R/2006/198SCANIA BUSK114 IB 4x2 Irizar CenturyRISK OF FIREAn isolated case of a fire appears to have originated in the wiring harness adjacent to the fuel tank. Recall affected vehicles check and secure wiring replacing any damaged cables.1961692K11418424791841123
25/07/06R/2006/125TOYOTACOROLLA VERSOFRONT SEAT PASSENGER AIRBAG MAY ACTIVATE WHEN TURNED OFFThe airbag and seat belt pretensioner ECU system may be incorrectly programmed.Affected vehicles will be recalled and airbag sensors replaced.19115COROLLA VERSONMTEZ15R#0R001769NMTEZ15R#0R02820701/05/200430/04/2006
25/07/06R/2006/125TOYOTACOROLLA VERSOFRONT SEAT PASSENGER AIRBAG MAY ACTIVATE WHEN TURNED OFFThe airbag and seat belt pretensioner ECU system may be incorrectly programmed.Affected vehicles will be recalled and airbag sensors replaced.19115COROLLA VERSONMTEX16R#0R000016NMTEX16R#0R06048401/02/200430/08/2005
25/07/06R/2006/125TOYOTACOROLLA VERSOFRONT SEAT PASSENGER AIRBAG MAY ACTIVATE WHEN TURNED OFFThe airbag and seat belt pretensioner ECU system may be incorrectly programmed.Affected vehicles will be recalled and airbag sensors replaced.19115COROLLA VERSONMTEZ16R#0R000026NMTEZ16R#0R01733901/02/200430/08/2005
25/07/06R/2006/125TOYOTACOROLLA VERSOFRONT SEAT PASSENGER AIRBAG MAY ACTIVATE WHEN TURNED OFFThe airbag and seat belt pretensioner ECU system may be incorrectly programmed.Affected vehicles will be recalled and airbag sensors replaced.19115COROLLA VERSONMTEA16R#0R000050NMTEA16R#0R03761301/08/200530/04/2006
25/07/06R/2006/125TOYOTACOROLLA VERSOFRONT SEAT PASSENGER AIRBAG MAY ACTIVATE WHEN TURNED OFFThe airbag and seat belt pretensioner ECU system may be incorrectly programmed.Affected vehicles will be recalled and airbag sensors replaced.19115COROLLA VERSONMTER16R#0R000026NMTER16R#0R08282301/02/200430/05/2006
25/07/06R/2006/125TOYOTACOROLLA VERSOFRONT SEAT PASSENGER AIRBAG MAY ACTIVATE WHEN TURNED OFFThe airbag and seat belt pretensioner ECU system may be incorrectly programmed.Affected vehicles will be recalled and airbag sensors replaced.19115COROLLA VERSONMTEB16R#0R000022NMTEB16R#0R03739001/08/200530/04/2006
26/07/06R/2006/057TOYOTARAV4 PRIUS AND COROLLA VERSO LEXUS GS300 LEXUS IS250 AND LEXUS IS220dAIRBAGS MAY NOT INFLATE DURING A COLLISIONDue to improper assembly of the airbag inflator used in the side airbag curtain shield airbag and knee airbag systems the subject airbags may not fully inflate during a collision resulting in an increased risk of injury to the vehicle's occupants. Recalled vehicles will have the subject airbags replaced.11LEXUS IS220dJHHBB262X02001344JHHBB262X0200134406/12/200506/12/2005
26/07/06R/2006/057TOYOTARAV4 PRIUS AND COROLLA VERSO LEXUS GS300 LEXUS IS250 AND LEXUS IS220dAIRBAGS MAY NOT INFLATE DURING A COLLISIONDue to improper assembly of the airbag inflator used in the side airbag curtain shield airbag and knee airbag systems the subject airbags may not fully inflate during a collision resulting in an increased risk of injury to the vehicle's occupants. Recalled vehicles will have the subject airbags replaced.11LEXUS IS25030/09/200507/12/2005
26/07/06R/2006/057TOYOTARAV4 PRIUS AND COROLLA VERSO LEXUS GS300 LEXUS IS250 AND LEXUS IS220dAIRBAGS MAY NOT INFLATE DURING A COLLISIONDue to improper assembly of the airbag inflator used in the side airbag curtain shield airbag and knee airbag systems the subject airbags may not fully inflate during a collision resulting in an increased risk of injury to the vehicle's occupants. Recalled vehicles will have the subject airbags replaced.11LEXUS GS300JTHBH96S105020628JTHBH96S10502062823/08/200523/08/2005
26/07/06R/2006/057TOYOTARAV4 PRIUS AND COROLLA VERSO LEXUS GS300 LEXUS IS250 AND LEXUS IS220dAIRBAGS MAY NOT INFLATE DURING A COLLISIONDue to improper assembly of the airbag inflator used in the side airbag curtain shield airbag and knee airbag systems the subject airbags may not fully inflate during a collision resulting in an increased risk of injury to the vehicle's occupants. Recalled vehicles will have the subject airbags replaced.11COROLLA VERSONMTER16ROOR067698NMTER16ROOR06769816/12/200516/12/2005
26/07/06R/2006/057TOYOTARAV4 PRIUS AND COROLLA VERSO LEXUS GS300 LEXUS IS250 AND LEXUS IS220dAIRBAGS MAY NOT INFLATE DURING A COLLISIONDue to improper assembly of the airbag inflator used in the side airbag curtain shield airbag and knee airbag systems the subject airbags may not fully inflate during a collision resulting in an increased risk of injury to the vehicle's occupants. Recalled vehicles will have the subject airbags replaced.11PRIUS20/11/200329/07/2005
26/07/06R/2006/057TOYOTARAV4 PRIUS AND COROLLA VERSO LEXUS GS300 LEXUS IS250 AND LEXUS IS220dAIRBAGS MAY NOT INFLATE DURING A COLLISIONDue to improper assembly of the airbag inflator used in the side airbag curtain shield airbag and knee airbag systems the subject airbags may not fully inflate during a collision resulting in an increased risk of injury to the vehicle's occupants. Recalled vehicles will have the subject airbags replaced.11RAV418/09/200302/09/2005
26/07/06R/2006/085FIATMULTIPLA - RHD WITH REAR DISC BRAKESBRAKE FLUID MAY LEAKIt may be possible for the handbrake cable to foul the rigid brake pipe at the right hand rear suspension arm. In time this could lead to wear of the rigid brake pipe and as a consequence there maybe a loss of brake fluid and longer stopping distances.Recall the vehicles that are likely to be affected to check the routing of the handbrake cable and fit rubber pads to the rigid brake pipe to prevent fouling.2278MULTIPLAZFA18600002166357ZFA1860000219162301/04/200228/02/2003
26/07/06R/2006/117NISSANNOTEREAR SEAT ISOFIX BRACKETS MAY NOT PERFORM AS DESIGNED IN A SIDE IMPACTA concern has been identified with the rear seat ISOFIX brackets of some E11 Note vehicles. In that the brackets may have been manufactured incorrectly with the potential that the brackets may not perform to the design intent in the case of a side impact. In addition the brackets may not conform to the required EC legislation. Recalled vehicles will have the subject seat brackets replaced. 338NOTE25/01/200603/02/2006
27/07/06R/2006/107VAUXHALLVX220REAR ALLOY ROAD WHEEL MAY FRACTUREIn extreme driving conditions it is possible that the rear wheel/s may fracture.Recall the vehicles that are likely to be affected and check that H.T. is stamped on the inside of one of the spokes. I there is no such marking the wheel/s must be replaced.80606C006VX220
27/07/06R/2006/107VAUXHALLVX220REAR ALLOY ROAD WHEEL MAY FRACTUREIn extreme driving conditions it is possible that the rear wheel/s may fracture.Recall the vehicles that are likely to be affected and check that H.T. is stamped on the inside of one of the spokes. I there is no such marking the wheel/s must be replaced.80606C006VX22001/01/200131/12/2002
01/08/06R/2006/087HYUNDAITerracan 4x4POSSIBILTY OF POOR BRAKING PERFORMANCESome Terracan vehicles were produced with reduced metal thickness on the front brake discs between the disc surface and flange. Abnormal noise and poor braking performance may result.Recall affected vehicles and measure brake disc with specialst tool. If metal thickness is less than 4.5 mmm replace disc167650B029TERRACANKMHNM81XR4U138118KMHNM81XR4U14438608/12/200327/01/2005
02/08/06RM/2006/034KTM990 ADVENTUREABS SYSTEM COULD FAIL TO OPERATEIt is possible for water to ingress into the ABS brake system override switch and warning light causing a failure of the switch and warning lamp. This will lead to the ABS system not working and the rider being unaware of the situation. The brakes will function but without the facility of ABS.Recall the machines that are likely to be affected to replace the original ABS system override switch with a modified item.174990 ADVENTURE01/12/200531/05/2006
03/08/06R/2006/137POLESWORTH PANEL VANSEATS MAY DETACH Passenger seats may detach during a collisonRecall affected vehicles and secure seats as per the seat manufacturers recommendations8NISSAN PRIMASTAR PANEL VAN
07/08/06R/2006/115VWPASSAT 2.0 TDI (WITH 6 SPEED MANUAL GEARBOX)POSSIBILITY OF FIREThe two mass flywheel can become damaged because of a non- optimally designed through-flow restrictor in the clutch pressure pipe. This can lead to total failure of the two mass flywheel and under unfavourable circumstances a fire.Recalled vehicles will have the manufacturer of the two mass flywheel checked and if necessary the flywheel and the breather of the clutch pressure pipe will be replaced. 140613D2PASSATWVW***3C*6E000057WVW***3C*6E04802001/04/200530/06/2005
07/08/06R/2006/115VWPASSAT 2.0 TDI (WITH 6 SPEED MANUAL GEARBOX)POSSIBILITY OF FIREThe two mass flywheel can become damaged because of a non- optimally designed through-flow restrictor in the clutch pressure pipe. This can lead to total failure of the two mass flywheel and under unfavourable circumstances a fire.Recalled vehicles will have the manufacturer of the two mass flywheel checked and if necessary the flywheel and the breather of the clutch pressure pipe will be replaced. 140613D2PASSATWVW***3C*6P000013WVW***3C*6P02295101/04/200530/06/2005
08/08/06R/2006/096IVECOEURO TRAKKER 4x4-6x6-8x4FRONT AXLE COULD BE OUT OF ALIGNMENTIt has been identified that the possibility exists that the front spring spacer plate position may be incorrect and the U bolts may not have been tightened to the correct torque setting.Recalled vehicles will have the position of the spacer plate checked. The spacer plate will be renewed if found to be incorrectly positioned. In addition the torque of the front spring U bolts will be checked.184EUROTREKKERWJMJ3JRS00C091714WJME2NNS00C12331901/07/200131/07/2003
08/08/06R/2006/073IVECO BUSDAILY S2000RISK OF FIREDuring prolonged use the heater and air conditioning circuit fuse 21 (mini fuse) may overheat in the central fuse holder. Excessive overheating of the fuse can result in melting of the plastic fuse holder. Recalled vehicles will have fuse 21 replaced with a maxi fuse. 694RCT13DAILYBUSZCFC509000D102990ZCFC65A000D20931601/08/199928/02/2003
08/08/06R/2006/073IVECO BUSDAILY S2000RISK OF FIREDuring prolonged use the heater and air conditioning circuit fuse 21 (mini fuse) may overheat in the central fuse holder. Excessive overheating of the fuse can result in melting of the plastic fuse holder. Recalled vehicles will have fuse 21 replaced with a maxi fuse. 694RCT13DAILYBUSZCFC5090005243935ZCFC459000543401401/03/200030/04/2003
09/08/06R/2006/012TOYOTARAV4FRONT COIL SPRING MAY FRACTURE RESULTING IN THE POSSIBILITY OF TYRE DAMAGEDue to insufficient surface treatment prior to painting the paint on the front coil springs may not have adhered properly. This can render the spring susceptible to corrosion in environments where road salt is used. Prolonged use of the vehicle in this condition may cause the spring to fracture which in extreme cases can lead to tyre damage.Recalled vehicles will have both front coil springs replaced with quality assured items. 1998RAV4JT172SC1*00013120JT172SC1*0003361419/05/199531/07/1995
09/08/06R/2006/012TOYOTARAV4FRONT COIL SPRING MAY FRACTURE RESULTING IN THE POSSIBILITY OF TYRE DAMAGEDue to insufficient surface treatment prior to painting the paint on the front coil springs may not have adhered properly. This can render the spring susceptible to corrosion in environments where road salt is used. Prolonged use of the vehicle in this condition may cause the spring to fracture which in extreme cases can lead to tyre damage.Recalled vehicles will have both front coil springs replaced with quality assured items. 1998RAV4JT171SC1*00094625JT171SC1*0010092519/05/199531/07/1995
10/08/06R/2006/134MANTGL L2000 AND A66BRAKES MAY FAILIt has been identified that the fastening of the brake calipers on the rear axle may work loose as the result of the bolts not having been tightened to the correct torque. If this situation is allowed to continue the potential exists for the brakes on the affected axle to fail. Recalled vehicles will have the subject bolts checked by the appliance of a test torque.192208005A66
10/08/06R/2006/134MANTGL L2000 AND A66BRAKES MAY FAILIt has been identified that the fastening of the brake calipers on the rear axle may work loose as the result of the bolts not having been tightened to the correct torque. If this situation is allowed to continue the potential exists for the brakes on the affected axle to fail. Recalled vehicles will have the subject bolts checked by the appliance of a test torque.192208005TGL
10/08/06R/2006/134MANTGL L2000 AND A66BRAKES MAY FAILIt has been identified that the fastening of the brake calipers on the rear axle may work loose as the result of the bolts not having been tightened to the correct torque. If this situation is allowed to continue the potential exists for the brakes on the affected axle to fail. Recalled vehicles will have the subject bolts checked by the appliance of a test torque.192208005L2000
11/08/06R/2006/120FIATDUCATOU-BOLTS ON REAR AXLE MAY BREAKThe U bolts securing the leaf spring to the rear axle may not have been tightened to the correct torque. This may result in the U bolts breaking.Recalled vehicles will have the U bolts checked to ensure there is no damage and that they have been tightened to the correct torque. 117DUCATOZFA24400007761041ZFA2440000777780901/01/200628/02/2006
16/08/06R/2006/114MAZDAMAZDA 3 (FITTED WITH DV6 DIESEL ENGINE)ENGINE MAY SEIZEIt has been identified that on a small number of vehicles the oil feed in the cylinder head and camshaft carrier may not be correctly aligned allowing the oil flow to be restricted. If this this allowed to continue it is likely to result in an engine malfunction when the mileage exceeds 62 000. Recalled vehicles will be checked for their presence in the affected range and fitted with a new partial engine if so identified.1813JMZBK1*32**161611JMZBK1*32**20136408/04/200408/09/2004
16/08/06R/2006/027TOYOTAHILUXENGINE MAY SURGE OR STALLIt has been established that when the ambient temperature is cold and the fuel in the fuel tank is low air could be inhaled from the fuel tank vent tube into the fuel filter. This air could then pass into the fuel pump resulting in the vehicle surging or in the worst case the engine stalling. Recalled vehicles will have the fuel tank vent tube replaced. 1218HI LUXAHTDR22G#05500202AHTDR22G#0550165606/07/200515/12/2005
16/08/06R/2006/027TOYOTAHILUXENGINE MAY SURGE OR STALLIt has been established that when the ambient temperature is cold and the fuel in the fuel tank is low air could be inhaled from the fuel tank vent tube into the fuel filter. This air could then pass into the fuel pump resulting in the vehicle surging or in the worst case the engine stalling. Recalled vehicles will have the fuel tank vent tube replaced. 1218HI LUXAHTFR22G#06000366AHTFR22G#0600220206/07/200515/12/2005
16/08/06R/2006/027TOYOTAHILUXENGINE MAY SURGE OR STALLIt has been established that when the ambient temperature is cold and the fuel in the fuel tank is low air could be inhaled from the fuel tank vent tube into the fuel filter. This air could then pass into the fuel pump resulting in the vehicle surging or in the worst case the engine stalling. Recalled vehicles will have the fuel tank vent tube replaced. 1218HI LUXAHTCS12G#07501063AHTCS12G#0750410206/07/200515/12/2005
16/08/06R/2006/027TOYOTAHILUXENGINE MAY SURGE OR STALLIt has been established that when the ambient temperature is cold and the fuel in the fuel tank is low air could be inhaled from the fuel tank vent tube into the fuel filter. This air could then pass into the fuel pump resulting in the vehicle surging or in the worst case the engine stalling. Recalled vehicles will have the fuel tank vent tube replaced. 1218HI LUXAHTFR29G#07000020AHTFR29G#0700328706/07/200515/12/2005
18/08/06RM/2006/033TRIUMPHSPRINT ST 1050 SPRINT ST ABS SPREED TRIPLE 1050 AND DAYTONA 955STOP BOLT MAY SHEARThe rear brake caliper anti-rotation device (stop bolt) may shear. If this occurs the caliper will strike the swinging arm.Recall the motorcycles that are likely to be affected to remove the original stop bolt and replace for a modified bolt1096SPEED TRIPLE
18/08/06RM/2006/033TRIUMPHSPRINT ST 1050 SPRINT ST ABS SPREED TRIPLE 1050 AND DAYTONA 955STOP BOLT MAY SHEARThe rear brake caliper anti-rotation device (stop bolt) may shear. If this occurs the caliper will strike the swinging arm.Recall the motorcycles that are likely to be affected to remove the original stop bolt and replace for a modified bolt1096DAYTONA
18/08/06RM/2006/033TRIUMPHSPRINT ST 1050 SPRINT ST ABS SPREED TRIPLE 1050 AND DAYTONA 955STOP BOLT MAY SHEARThe rear brake caliper anti-rotation device (stop bolt) may shear. If this occurs the caliper will strike the swinging arm.Recall the motorcycles that are likely to be affected to remove the original stop bolt and replace for a modified bolt1096SPRINT ST
22/08/06R/2006/155BENTLEY MOTOR CARSCONTINENTAL GTPOTENTIAL LOSS OF BRAKING EFFICIENCYIt has been identified that the potential exists for a foul condition to occur between a brake pipe and an engine mounted hose clip. A situation which could eventually result in failure of the brake pipe and an increase in stopping distance under braking. Additionally there is a risk of fire due to brake fluid escaping into the engine compartment.Recalled vehicles will be inspected and the clearance between the brake pipe and hose clip checked. If the clearance is to tolerance and no damage exists no further action will be required. Should the clearance be below the required standard remedial action will be taken as appropriate.536AGS EJDCONTINENTAL GT
25/08/06R/2006/138FIATDoblo MPV & VanPOSSIBLE LOSS OF STEERINGThere is a possibility that the weld on the steering shaft at the lower universal joint fitting maybe absent. If there is an absent of the weld at the joint this may lead to a loss of steering.Recall affected vehicles and inspect steering shaft to ensure weld is present if not renew steering shaft.559DOBLOZFA22300005397234ZFA2230000541212601/03/200630/04/2006
30/08/06R/2006/123RENAULTMASTERHANDBRAKE MAY FAILIt is possible that the rear caliper handbrake lever to crack and weaken. In the worst case there is a possibility that the parking brake cables will release.Recall the vehicles that are likely to be affected and check the caliper handbrake lever for evidence of a crack. Where a crack exists on the lever the caliper will be replaced.1023oaluMASTER24/10/200517/01/2006
01/09/06R/2006/152MERCEDES BENZR ClassSEAT BELT MAY DE-LATCHExcessive side movement within the driver's seat belt buckle may cause the seat belt to de-latch.Recalled vehicles will have the subject seat belt buckle checked for excessive side movement. The buckle will be replaced if excessive movement is evident.67PO66R CLASS
01/09/06R/2006/144MERCEDES BENZMcLaren SLRRISK OF FIREThe alternator wiring harness ducting may foul adjacent components with the result that under extreme conditions overheating may occur.Recalled vehicles will have the condition of the ducting checked and the wiring re-routed.75PO72MCLAREN SLR01/01/200515/08/2006
01/09/06R/2006/139MANTGA - Bus/CoachesDRIVER AND CO-DRIVER'S SEATS MAY TIP TO THE REARThe squeezer nut which is part of the scissor-type lever assembly on the seat rack may work loose. This may cause damage to the seat rack and in extreme cases the seat rack may fail. If this occurs there is a risk of the seat tipping rearward which could potentially affect the driver's control of the vehicle. Recall all affected vehicles for inspection and replacement of damages seat scissor-type lever assemblies as required.2960188806TG-A01/01/200431/12/2006
01/09/06R/2006/139MANTGA - Bus/CoachesDRIVER AND CO-DRIVER'S SEATS MAY TIP TO THE REARThe squeezer nut which is part of the scissor-type lever assembly on the seat rack may work loose. This may cause damage to the seat rack and in extreme cases the seat rack may fail. If this occurs there is a risk of the seat tipping rearward which could potentially affect the driver's control of the vehicle. Recall all affected vehicles for inspection and replacement of damages seat scissor-type lever assemblies as required.2960188806TBUS/COACHES01/01/200431/12/2006
01/09/06R/2006/160GOWERINGS MOBILITY LTDGowerings BerlingoBRAKES MAY FAILThe rear suspension dual purpose ram securing cap head screw may not be correctly torqued. There is a possibility that the screw could become loose and damage the brake pipe which could result in brake failure.Recall all affected vehicles for inspection and if found to be incorrectly torqued carry out rework procedure as laid down by converter.5GOWRINGS BERLINGO01/08/200531/03/2006
01/09/06R/2006/148MERCEDES BENZR ClassRISK OF ELECTRICAL SHORT CIRCUIT The routing of the stater motor wiring harness may be incorrect with the attendant risk of a short circuit occurring.Recall vehicles and check the routing of the subject wiring harness taking corrective action as necessary.50PO65R CLASS
04/09/06R/2006/074SUZUKICARRY VANRISK OF FIREIt has been identified that affected vehicles have been fitted with an ignition switch which encompasses an improper design of the contact points.Recalled vehicles will have the ignition switch replaced.3327R06/07CARRYJSAFDA32V00100041JSAFDA32V0013021523/12/199830/09/2000
06/09/06R/2006/136AUDIA3 - SPORTBACKCURTAIN AIRBAG MAY NOT INFLATE IN A COLLISIONThe gas required to inflate the curtain airbag can escape gradually through a defective welded seam on the gas generator. In this instance the curtain airbag would fail to inflate in a collision. Recalled vehicles will have the curtain airbag replaced.9269G3A3WAUZZZ8P#6A023747WAUZZZ8P#6A06147501/06/200531/07/2005
06/09/06R/2006/140MANSTARLINER N516POSSIBLE FIRE OUTBREAKS IN THE VICINITY OF THE CENTRAL ELECTRICAL PANEL.It has been diagnosed that the fire is due to thermal overload on 300-150 negative terminals. The cause being due to a transitional resistance between the cable lug and the terminal which has increased excessively because of the installation of Nord lock washers.Recalled vehicles will be checked to ascertain whether Nord lock washers are fitted. If not no action will be taken. If Nord lock washers are fitted they will be removed and replaced with serrated nuts. During each of these procedures the cabling will be checked for smoldering type damage. 62208702STARLINER N51601/01/200411/08/2006
07/09/06R/2006/167RENAULT TRUCKS UK LTDPREMIUM DCI AND KARAX DCIBALL JOINT MAY DETACH FROM TIE RODThe tie rod may separate from the ball joint which could result in loss of directional control.Recall the vehicles that are likely to be affected and fit new tie rods.330OTS 1CTKERAX01/12/200431/03/2005
07/09/06R/2006/167RENAULT TRUCKS UK LTDPREMIUM DCI AND KARAX DCIBALL JOINT MAY DETACH FROM TIE RODThe tie rod may separate from the ball joint which could result in loss of directional control.Recall the vehicles that are likely to be affected and fit new tie rods.330OTS 1CTPREMIUM RANGE01/12/200431/03/2005
08/09/06RM/2006/044BARRUSGV650HANDLEBAR RETAINING BOLTS MAY LOOSEN OR FAILThe handlebar retaining bolts may loosen or fail. Which is extreme circumstances could result in loss of control of the machine.Recall the effected vehicles and replace the handlebar bolts with quality assured items.42GV650
12/09/06RM/2006/037BMW MOTORCYCLESR1200SFINAL DRIVE ASSEMBLY MAY LEAKOil may leak from the rear wheel final drive which if ignored could lead to contamination of the brake disc and tyre.Recall the machines that are likely to be affected and replace the oil seal and spacer.433R SERIES
12/09/06R/2006/173VOLVO TRUCKFH/FMHEADLIGHTS AND REAR LIGHT MAY BECOME DISABLEDThe NOx sensor has a built in over voltage protection which is triggered by a voltage above 32 volts. When this is over the voltage protection and is active faults codes can be produced for example Headlight and Rear Lights can be disabled. Recall affected vehicles and modify software.6c0712FH
12/09/06R/2006/173VOLVO TRUCKFH/FMHEADLIGHTS AND REAR LIGHT MAY BECOME DISABLEDThe NOx sensor has a built in over voltage protection which is triggered by a voltage above 32 volts. When this is over the voltage protection and is active faults codes can be produced for example Headlight and Rear Lights can be disabled. Recall affected vehicles and modify software.6c0712FM
13/09/06R/2006/103TOYOTAAvensis Corolla PriusSTEERING MAY FAILIt is possible that the connections at the intermediate shaft and sliding yoke of the steering column may become loose and if the symptoms are ignored steering control can be lost.Recall the vehicles that are likely to be affected and replace the steering intermediate shaft. In addition inspect the sliding yoke and intermediate shaft extension and replace if necessary. This recall is staggered starting with Prius and Corrolla. Avensis customer letters will be sent out over the next three months39372AVENSISSB1#R5#L#0E001005SB1#R5#L#0E14550701/01/200331/12/2005
13/09/06R/2006/103TOYOTAAvensis Corolla PriusSTEERING MAY FAILIt is possible that the connections at the intermediate shaft and sliding yoke of the steering column may become loose and if the symptoms are ignored steering control can be lost.Recall the vehicles that are likely to be affected and replace the steering intermediate shaft. In addition inspect the sliding yoke and intermediate shaft extension and replace if necessary. This recall is staggered starting with Prius and Corrolla. Avensis customer letters will be sent out over the next three months39372PRIUSJTDKB2#U#03000017JTDKB2#U#0313987601/08/200330/11/2005
13/09/06R/2006/103TOYOTAAvensis Corolla PriusSTEERING MAY FAILIt is possible that the connections at the intermediate shaft and sliding yoke of the steering column may become loose and if the symptoms are ignored steering control can be lost.Recall the vehicles that are likely to be affected and replace the steering intermediate shaft. In addition inspect the sliding yoke and intermediate shaft extension and replace if necessary. This recall is staggered starting with Prius and Corrolla. Avensis customer letters will be sent out over the next three months39372COROLLAJTD#X2#E#03000010JTD#X2#E#0300519401/10/200130/06/2002
13/09/06R/2006/103TOYOTAAvensis Corolla PriusSTEERING MAY FAILIt is possible that the connections at the intermediate shaft and sliding yoke of the steering column may become loose and if the symptoms are ignored steering control can be lost.Recall the vehicles that are likely to be affected and replace the steering intermediate shaft. In addition inspect the sliding yoke and intermediate shaft extension and replace if necessary. This recall is staggered starting with Prius and Corrolla. Avensis customer letters will be sent out over the next three months39372PRIUSJTDKB2#U#00001083JTDKB2#U#0013315301/08/200301/11/2005
13/09/06R/2006/103TOYOTAAvensis Corolla PriusSTEERING MAY FAILIt is possible that the connections at the intermediate shaft and sliding yoke of the steering column may become loose and if the symptoms are ignored steering control can be lost.Recall the vehicles that are likely to be affected and replace the steering intermediate shaft. In addition inspect the sliding yoke and intermediate shaft extension and replace if necessary. This recall is staggered starting with Prius and Corrolla. Avensis customer letters will be sent out over the next three months39372COROLLAJTD#Z2#E#00002615JTD#Z2#E#0001680901/10/200101/06/2002
13/09/06R/2006/103TOYOTAAvensis Corolla PriusSTEERING MAY FAILIt is possible that the connections at the intermediate shaft and sliding yoke of the steering column may become loose and if the symptoms are ignored steering control can be lost.Recall the vehicles that are likely to be affected and replace the steering intermediate shaft. In addition inspect the sliding yoke and intermediate shaft extension and replace if necessary. This recall is staggered starting with Prius and Corrolla. Avensis customer letters will be sent out over the next three months39372PRIUSJTDKB2#U#07000039JTDKB2#U#0705908501/08/200330/11/2005
13/09/06RM/2006/036BUELLULYSSES XB12XSIDE STAND MOUNTING BOLT MAY FAILThe side stand pivot bolt may come loose in operation creating a situation where either the bolt or stand may fail during normal usage. This situation can lead to a parked machine falling from its stand.Recall the vehicles that are likely to be affected to replace the original side stand and bolt assembly with redesigned components.266832XB12X15/03/200516/06/2006
13/09/06RM/2006/035BUELLULYSEES XB12XWINDSCREEN MAY DETACHCertain genuine Buell accessory tall windscreens part numbers 58214-06Y and 58214-06YA have been supplied with fixings that do not exhibit the required durability in use once installed; this could lead to a condition where the screen becomes detached striking or distracting the rider.Recall the machines that are likely to be affected to replace the original screen fixings.18831XB12X
14/09/06RSPV/2006/014AUTO-SLEEPERS LTDAmethystSEATBELT SECURITY MAY BE AFFECTEDIt has been identified that two bolts are missing from the installation of the forward facing bed box which in extreme circumstances could result in the seat belt mounting detaching from the chassis.Recalled vehicles will have the subject mountings fitted with replacement high tensile bolts54AMETHYST07/06/200628/07/2006
18/09/06R/2006/158VAUXHALLMOVANOPARKING BRAKE MAY FAILIt has been identified that cracking of the parking brake actuating levers of the rear axle disc brake calipers may lead to loss of parking brake function.Recalled vehicles will be inspected and affected parts replaced as necessary.830MOVANO01/01/200531/12/2005
19/09/06R/2006/128ALFA ROMEO147 &GT(NOT 3.2 VERSION)BRAKING EFFICIENCY MAY REDUCEThe Vehicle Dynamic Control (VDC) system does not operate properly when the space saver spare wheel is fitted. This could lead to the VDC warning lamp operating and may lead to reduced braking efficiency if the brakes are vigorously applied.Recall the vehicles that are likely to be affected to fit a new VDC electronic control unit that has upgraded software installed.3950GTZAR93700005081439ZAR9370000521011301/02/200330/11/2005
19/09/06R/2006/128ALFA ROMEO147 &GT(NOT 3.2 VERSION)BRAKING EFFICIENCY MAY REDUCEThe Vehicle Dynamic Control (VDC) system does not operate properly when the space saver spare wheel is fitted. This could lead to the VDC warning lamp operating and may lead to reduced braking efficiency if the brakes are vigorously applied.Recall the vehicles that are likely to be affected to fit a new VDC electronic control unit that has upgraded software installed.3950GTZAR93700003144007ZAR9370000332129501/02/200330/11/2005
19/09/06R/2006/128ALFA ROMEO147 &GT(NOT 3.2 VERSION)BRAKING EFFICIENCY MAY REDUCEThe Vehicle Dynamic Control (VDC) system does not operate properly when the space saver spare wheel is fitted. This could lead to the VDC warning lamp operating and may lead to reduced braking efficiency if the brakes are vigorously applied.Recall the vehicles that are likely to be affected to fit a new VDC electronic control unit that has upgraded software installed.3950147ZAR93700005144149ZAR9370000521611101/06/200428/02/2006
19/09/06R/2006/128ALFA ROMEO147 &GT(NOT 3.2 VERSION)BRAKING EFFICIENCY MAY REDUCEThe Vehicle Dynamic Control (VDC) system does not operate properly when the space saver spare wheel is fitted. This could lead to the VDC warning lamp operating and may lead to reduced braking efficiency if the brakes are vigorously applied.Recall the vehicles that are likely to be affected to fit a new VDC electronic control unit that has upgraded software installed.3950147ZAR93700003228724ZAR9370000332846801/06/200428/02/2006
19/09/06RSPV/2006/015SEGWAYPERSONAL TRANSPORTER i167 i170 i180 p133 XT GT i2 and e167REVERSE TORQUE MAY UNEXPECTEDLY APPLY TO THE WHEELSUnder certain circumstances due to a software issue the subject Sedway PT can unexpectedly apply reverse torque to the wheels which can result in the rider falling off.Recall affected machines and update software.142Segway Personal Transporter01/03/200230/09/2006
20/09/06R/2006/026ISUZU TRUCKNKR69 NKR55 NKR77SUSPENSION BALL JOINT MAY FAIL PREMATURELYIt is possible that the suspension lower ball joint may fail prematurely due to the ingress of water and detritus. Dependent on the design the lower ball joint will be replaced. If the ball joint is integral with the lower arm the assembly will be changed.1818 NKR7701/01/199403/02/2006
20/09/06R/2006/026ISUZU TRUCKNKR69 NKR55 NKR77SUSPENSION BALL JOINT MAY FAIL PREMATURELYIt is possible that the suspension lower ball joint may fail prematurely due to the ingress of water and detritus. Dependent on the design the lower ball joint will be replaced. If the ball joint is integral with the lower arm the assembly will be changed.1818 NKR5501/01/199403/02/2006
20/09/06R/2006/026ISUZU TRUCKNKR69 NKR55 NKR77SUSPENSION BALL JOINT MAY FAIL PREMATURELYIt is possible that the suspension lower ball joint may fail prematurely due to the ingress of water and detritus. Dependent on the design the lower ball joint will be replaced. If the ball joint is integral with the lower arm the assembly will be changed.1818NKR6901/01/199403/02/2006
21/09/06R/2006/110IVECODAILY S2000 WITH 8149 CNG ENGINERISK OF FIREIt has been identified that the possibility exists for the exhaust silencer to fail which can lead to overheating of a wiring harness. Recalled vehicles will have the exhaust silencer replaced and a heat shield fitted to the subject wiring harness. 64RCT08DAILYZCFC6570005366787ZCFC357100557277501/05/200231/10/2005
25/09/06R/2006/147FORDExplorer / MountaineerSPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT AND CATCH FIRE.It has been identified that the speed control deactivation switch may overheat smoke or burn.Recalled vehicles will have the subject switch renewed if necessary in addition to which a modified jumper harness will be installed.39685c983MOUNTAINEER25/04/199721/10/1998
25/09/06R/2006/147FORDExplorer / MountaineerSPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT AND CATCH FIRE.It has been identified that the speed control deactivation switch may overheat smoke or burn.Recalled vehicles will have the subject switch renewed if necessary in addition to which a modified jumper harness will be installed.39685c983EXPLORER25/04/199721/10/1998
25/09/06RSPV/2006/011AUTO-TRAIL APACHE 670 CHEY 660 CHEY 840 CARIOCA 644 CIPRO 55 AND CIPRO 85WARM AIR HOUSING MAY DANGEROUSLY OVERHEATIn exceptional circumstances a dangerous overheating of the warm air housing could occur.Recalled vehicles will be fitted with a modified warm air housing.162CHEY
25/09/06RSPV/2006/011AUTO-TRAIL APACHE 670 CHEY 660 CHEY 840 CARIOCA 644 CIPRO 55 AND CIPRO 85WARM AIR HOUSING MAY DANGEROUSLY OVERHEATIn exceptional circumstances a dangerous overheating of the warm air housing could occur.Recalled vehicles will be fitted with a modified warm air housing.162CIPRO
25/09/06RSPV/2006/011AUTO-TRAIL APACHE 670 CHEY 660 CHEY 840 CARIOCA 644 CIPRO 55 AND CIPRO 85WARM AIR HOUSING MAY DANGEROUSLY OVERHEATIn exceptional circumstances a dangerous overheating of the warm air housing could occur.Recalled vehicles will be fitted with a modified warm air housing.162APACHE
25/09/06RSPV/2006/011AUTO-TRAIL APACHE 670 CHEY 660 CHEY 840 CARIOCA 644 CIPRO 55 AND CIPRO 85WARM AIR HOUSING MAY DANGEROUSLY OVERHEATIn exceptional circumstances a dangerous overheating of the warm air housing could occur.Recalled vehicles will be fitted with a modified warm air housing.162CARIOCA
26/09/06RCOMP/2006/006MOTHERCARETRAVEL TOT CAR SEATSEAT MAY CONTAIN A SHARP EDGE/POINTMothercare has been notified of a single car seat in which a plastic point created during the production process had not been removed.As a precautionary measure all stock manufactured in the same production unit is being inspected to ensure there are no similar issues.17000 TRAVEL TOT CAR SEAT01/09/200526/09/2006
29/09/06RSPV/2007/007TRIGANO VDLChausson and ChallengerSEAT BELT MOUNTING POTENTIAL FAILUREIt has been identified that weak welding in the upper section of some vertical tubes in the rear seat frame is present in subject vehicles. This may lead in cases of impact to the seat belt becoming insecure.Recalled vehicles will have the mechanical strength of the seat frame weak points improved by the fitting of a retrofit kit.68CHALLENGER01/04/200531/08/2006
29/09/06RSPV/2007/007TRIGANO VDLChausson and ChallengerSEAT BELT MOUNTING POTENTIAL FAILUREIt has been identified that weak welding in the upper section of some vertical tubes in the rear seat frame is present in subject vehicles. This may lead in cases of impact to the seat belt becoming insecure.Recalled vehicles will have the mechanical strength of the seat frame weak points improved by the fitting of a retrofit kit.68CHAUSSON01/04/200531/08/2006
02/10/06R/2006/154HONDACIVICENGINE MAY CUT OUT AND OR FAIL TO STARTIt has been identified that the engine may fail to start or may stall and fail to restart. This situation is caused by the presence of water residue from the tank testing procedure being left on the fuel pump wiring connector block. This situation can result in electrolytic corrosion of the connector terminals which may then break thus interrupting the electrical supply to the fuel pump with subsequent loss of fuel pressure. Recalled vehicles will be checked for the presence of corrosion and or water on the fuel pump connector block. Should this situation be found the fuel pump assembly will be replaced. 3038CIVIC02/05/200628/06/2006
05/10/06R/2006/157NISSANINTERSTARPARKING BRAKE MAY FAILIt has been identified that the parking brake levers situated on the rear disc calipers may have a fissure. This carries the potential risk that loss of parking brake function may occur due to the levers breaking. Recalled vehicles will be inspected and affected parts replaced as necessary.118INTERSTARVNV*3***UB007914VNV*3***UB00936101/10/200501/01/2006
06/10/06R/2006/181PEUGEOT207SEAT BELT FIXING MAY LOOSENOn the vehicles concerned the lower fixing for the left hand front seat belt may be of an incorrect specification. This may lead to the fixing becoming loose.Recalled vehicles will have the fixing checked and corrected as necessary.51ycr207
06/10/06R/2006/175GOWERINGS MOBILITY LTDCONVERSION - CITROEN RELAY SWB HIGH ROOFSEATBELT ANCHOR MAY BE LOOSERear Wheelchair lap and diagonal upper anchor securing may be inadequateRecall affected vehicles and check/ fit belt securing device.1GOWERINGS RELAYVF7ZAAMFA17791368VF7ZAAMFA1779136801/08/200631/08/2006
10/10/06RPT/2006/002BUERSTNER UKALL MODELSWINDOWS MAY BECOME DETACHEDIt has been identified that with some windows of affected caravans the inner and outer pane may loosen due to the adhesive being subject to high UV-exposure. Should the window pane detach a danger may be caused to other road users if the vehicle were to be in motion. Recalled vehicles will have the windows checked and changed if necessary.76All models01/01/199831/12/2000
11/10/06RM/2006/040KAWASAKIZX600E6FENGINE MAY FAILThe position of the spark plug may be deeper than standard which will result in various conditions from poor running to in the worst case engine failure.Recall the vehicles that are likely to be affected to check the cylinder head Lot number and check the depth of the spark plug. Where the depth of the spark plug is incorrect it will be necessary to replace the cylinder head.190ZX600E6FJKAZX600EEA083002JKAZX600EEA083285
16/10/06RM/2006/039YAMAHAXV1600ATRANSMISSION MAY LOCK UPThe potential exists that in certain circumstances of extreme loading on the fourth gear wheel dogs this may cause them to break. Should this occur it may be possible that the transmission may lack with the potential for the rider to lose control. Recalled machines will have the affected components replaced with modified parts.372XV1600VP081*****0000301VP081*****001004701/01/199931/12/2000
16/10/06RM/2006/039YAMAHAXV1600ATRANSMISSION MAY LOCK UPThe potential exists that in certain circumstances of extreme loading on the fourth gear wheel dogs this may cause them to break. Should this occur it may be possible that the transmission may lack with the potential for the rider to lose control. Recalled machines will have the affected components replaced with modified parts.372XV1600VP081*****0010392VP081*****001203501/01/200031/12/2001
16/10/06RM/2006/039YAMAHAXV1600ATRANSMISSION MAY LOCK UPThe potential exists that in certain circumstances of extreme loading on the fourth gear wheel dogs this may cause them to break. Should this occur it may be possible that the transmission may lack with the potential for the rider to lose control. Recalled machines will have the affected components replaced with modified parts.372XV1600VP081*****0015201VP081*****001685201/01/200231/12/2002
16/10/06RM/2006/039YAMAHAXV1600ATRANSMISSION MAY LOCK UPThe potential exists that in certain circumstances of extreme loading on the fourth gear wheel dogs this may cause them to break. Should this occur it may be possible that the transmission may lack with the potential for the rider to lose control. Recalled machines will have the affected components replaced with modified parts.372XV1600VP081*****0012997VP081*****001361201/01/200131/12/2001
17/10/06R/2006/166ALFA ROMEO147 and GTCLUTCH MAY FAILOn a number of RHD ALfa Romeo 147 and GT models there is a possibility that the clip which secures the connecting pin between the clutch cylinder and the clutch pedal may become detached resulting in loss of clutch operation.Recalled vehicles will be fitted with a redesigned retaining clip.5355147ZAR93700005155403ZAR9370000526074301/03/200331/10/2005
17/10/06R/2006/166ALFA ROMEO147 and GTCLUTCH MAY FAILOn a number of RHD ALfa Romeo 147 and GT models there is a possibility that the clip which secures the connecting pin between the clutch cylinder and the clutch pedal may become detached resulting in loss of clutch operation.Recalled vehicles will be fitted with a redesigned retaining clip.5355GTZAR93700003254498ZAR9370000333464101/09/200430/04/2006
17/10/06R/2006/166ALFA ROMEO147 and GTCLUTCH MAY FAILOn a number of RHD ALfa Romeo 147 and GT models there is a possibility that the clip which secures the connecting pin between the clutch cylinder and the clutch pedal may become detached resulting in loss of clutch operation.Recalled vehicles will be fitted with a redesigned retaining clip.5355147ZAR93700003185703ZAR9370000377740401/03/200331/10/2005
17/10/06R/2006/166ALFA ROMEO147 and GTCLUTCH MAY FAILOn a number of RHD ALfa Romeo 147 and GT models there is a possibility that the clip which secures the connecting pin between the clutch cylinder and the clutch pedal may become detached resulting in loss of clutch operation.Recalled vehicles will be fitted with a redesigned retaining clip.5355GTZAR93700005156078ZAR9370000529888801/09/200430/04/2006
18/10/06RM/2006/038YAMAHAYZF - R1 FZ6 S/N FJR1300 TDM900 MT-01 XV1700PC AND XT660R/XENGINE MAY STALLThe idle speed of the engine may become intermittently unstable. In rare cases this may result in the engine stalling when the machine is stationery or at low speedRecall affected machines and check Throttle Position Sensor.If necessary fit revised part.14384MT01/01/200531/12/2005
18/10/06RM/2006/038YAMAHAYZF - R1 FZ6 S/N FJR1300 TDM900 MT-01 XV1700PC AND XT660R/XENGINE MAY STALLThe idle speed of the engine may become intermittently unstable. In rare cases this may result in the engine stalling when the machine is stationery or at low speedRecall affected machines and check Throttle Position Sensor.If necessary fit revised part.14384TDM01/01/200231/12/2005
18/10/06RM/2006/038YAMAHAYZF - R1 FZ6 S/N FJR1300 TDM900 MT-01 XV1700PC AND XT660R/XENGINE MAY STALLThe idle speed of the engine may become intermittently unstable. In rare cases this may result in the engine stalling when the machine is stationery or at low speedRecall affected machines and check Throttle Position Sensor.If necessary fit revised part.14384XT66001/01/200431/12/2005
18/10/06RM/2006/038YAMAHAYZF - R1 FZ6 S/N FJR1300 TDM900 MT-01 XV1700PC AND XT660R/XENGINE MAY STALLThe idle speed of the engine may become intermittently unstable. In rare cases this may result in the engine stalling when the machine is stationery or at low speedRecall affected machines and check Throttle Position Sensor.If necessary fit revised part.14384YZF-R101/01/200431/12/2005
18/10/06RM/2006/038YAMAHAYZF - R1 FZ6 S/N FJR1300 TDM900 MT-01 XV1700PC AND XT660R/XENGINE MAY STALLThe idle speed of the engine may become intermittently unstable. In rare cases this may result in the engine stalling when the machine is stationery or at low speedRecall affected machines and check Throttle Position Sensor.If necessary fit revised part.14384FJR130001/01/200231/12/2004
18/10/06RM/2006/038YAMAHAYZF - R1 FZ6 S/N FJR1300 TDM900 MT-01 XV1700PC AND XT660R/XENGINE MAY STALLThe idle speed of the engine may become intermittently unstable. In rare cases this may result in the engine stalling when the machine is stationery or at low speedRecall affected machines and check Throttle Position Sensor.If necessary fit revised part.14384XV170001/01/200331/12/2003
18/10/06RM/2006/038YAMAHAYZF - R1 FZ6 S/N FJR1300 TDM900 MT-01 XV1700PC AND XT660R/XENGINE MAY STALLThe idle speed of the engine may become intermittently unstable. In rare cases this may result in the engine stalling when the machine is stationery or at low speedRecall affected machines and check Throttle Position Sensor.If necessary fit revised part.14384FZ601/01/200431/12/2005
20/10/06R/2006/196VOLVO CARS80SHORT CIRCUIT TO CABIN HEATERThe supplementary cabin heater may have a short circuit which normally leads to the battery being 'drained'. In extreme cases fire may occur.Recall the vehicles that are likely to be affected to disable the heater. This is a temporary measure until the root cause has been found and a permanent fix can be developed and applied.714S8056813569
23/10/06RCT/2006/004SCHMITZ CARGOBULL UK LTDSKO+24L and SKO+27L - Part chasis model refrigerated semi-trailerKINGPIN BED PLATE MAY FAILIt has been identified during trials that in situations of extremely heavy use it may be possible for a crack to develop in the sem-i trailer bed plate just ahead of the king pin. If a crack does develop and is ignored then ultimately the risk exists that the king pin could be torn away.The subject area of the bed plate will be modified as necessary.139SKO+24L 01/01/199331/12/2002
23/10/06RCT/2006/004SCHMITZ CARGOBULL UK LTDSKO+24L and SKO+27L - Part chasis model refrigerated semi-trailerKINGPIN BED PLATE MAY FAILIt has been identified during trials that in situations of extremely heavy use it may be possible for a crack to develop in the sem-i trailer bed plate just ahead of the king pin. If a crack does develop and is ignored then ultimately the risk exists that the king pin could be torn away.The subject area of the bed plate will be modified as necessary.139 SKO+27L 01/01/199331/12/2002
24/10/06R/2006/176RENAULTCLIO III MEGANE IIGEARBOX MAY MALFUNCTIONPossible malfunction of the gearbox control causing: 1. Gearbox switching to manual mode without driver intervention; 2. gearbox changing to 3rd gear without driver intervention; 3.incorrect display of lever position on the instrument panel; 4. "Auto gearbox" warning light illuminates.Recall the vehicles that are likely to be affected to replace the automatic transmission computer.217oargMEGANE10/11/200529/05/2006
24/10/06R/2006/176RENAULTCLIO III MEGANE IIGEARBOX MAY MALFUNCTIONPossible malfunction of the gearbox control causing: 1. Gearbox switching to manual mode without driver intervention; 2. gearbox changing to 3rd gear without driver intervention; 3.incorrect display of lever position on the instrument panel; 4. "Auto gearbox" warning light illuminates.Recall the vehicles that are likely to be affected to replace the automatic transmission computer.217oargCLIO07/03/200629/05/2006
24/10/06R/2006/178RENAULTMEGANE COUPEFRONT SEATS MAY NOT LOCK INTO POSITIONThere is a possibility that the seat back of the front seats may become difficult to adjust and or not lock into position.Recall the vehicles that are likely to be affected to check that all welding to the seat back frame is present. If the welds are not all present then the seat back frame will be replaced. 173OARJMEGANE01/09/200330/09/2003
25/10/06R/2006/162IVECOEUROCARGOCAB MAY SHUDDER WHICH MAY AFFECT STEERING CONTROLIt has been identified that an insufficient tightening torque mat have been applied to the bolts of the cab to chassis front mountings. This can cause the mounting bolts to work loose and the cab to shudder which may affect steering control. Recalled vehicles will have the cab front mounting bolts checked for the correct tightening torque.12rcg11EUROCARGOZCFA80C0102453262ZCFA1AF120246381901/04/200530/06/2005
25/10/06R/2006/163IVECODAILY S2000BOLTS USED TO SECURE STEERING RACK TO FRONT AXLE MAY FAIL.The possibility exists that the bolts which secure the steering rack to the front axle may be of the incorrect grade 8.8 instead of R10. A situation which may result in failure of the bolts. The bolts of recalled vehicles will be checked for compliance with the specification and changed as necessary.21RCT15DAILYZCFC65A000D301827ZCFC358200D30612001/03/200631/03/2006
25/10/06R/2006/159AUDIA8AIR BAG MAY NOT DEPLOY IN AN IMPACTIt may be possible that the driver's airbag may not inflate in an optimum manner during a collision.Recalled vehicles will have the driver's airbag replaced.1543A8WAUZZZ4E#4N000101WAUZZZ4E#4N02646801/12/200201/05/2005
25/10/06R/2006/159AUDIA8AIR BAG MAY NOT DEPLOY IN AN IMPACTIt may be possible that the driver's airbag may not inflate in an optimum manner during a collision.Recalled vehicles will have the driver's airbag replaced.1543A8WAUZZZ4E#5N000101WAUZZZ4E#5N01720801/12/200201/05/2005
25/10/06R/2006/159AUDIA8AIR BAG MAY NOT DEPLOY IN AN IMPACTIt may be possible that the driver's airbag may not inflate in an optimum manner during a collision.Recalled vehicles will have the driver's airbag replaced.1543A8WAUZZZ4E#3N000101WAUZZZ4E#3N00989501/12/200201/05/2005
25/10/06R/2006/161IVECODAILY S2000REAR AXLE LEAF SPRING U-BOLTS MAY FAIL.It has been identified that the possibility exists that the rear axle leaf spring U-bolts may break. A situation which could affect vehicle stability. The U-bolts of affected vehicles will be checked for dimensional compliance and changed as necessary.122RCT16DAILYZCFC40C000D303514ZCFC35A200D30929501/03/200631/03/2006
25/10/06R/2006/161IVECODAILY S2000REAR AXLE LEAF SPRING U-BOLTS MAY FAIL.It has been identified that the possibility exists that the rear axle leaf spring U-bolts may break. A situation which could affect vehicle stability. The U-bolts of affected vehicles will be checked for dimensional compliance and changed as necessary.122RCT16DAILYZCF050C0005593273ZCFC50A100560062101/03/200631/03/2006
27/10/06R/2006/191CATERHAM CARSSUPER 7SUSPENSION MAY COLLAPSEThere have been a few incidents of welds failing on the rear suspension during race application only that in the worst case will lead to the suspension collapsing.Recall the vehicles that are likely to be affected to either replace the affected part or reinforce it with a bracket.38SUPER 7
30/10/06R/2006/170ALFA ROMEO156POSSIBILITY OF ENGINE BAY FIREIt has been identified that on a small number of vehicles the possibility exists there may be a short circuit situation within the engine additional heater system during the warm up period which could lead to a fire within the engine compartment.Recalled vehicles will have the electrical supply to the additional heater modified; in order to avoid the possibility of the short circuit occurring.15495076156ZAR93200000193123ZAR9320000027896801/11/200131/12/2004
30/10/06R/2006/170ALFA ROMEO156POSSIBILITY OF ENGINE BAY FIREIt has been identified that on a small number of vehicles the possibility exists there may be a short circuit situation within the engine additional heater system during the warm up period which could lead to a fire within the engine compartment.Recalled vehicles will have the electrical supply to the additional heater modified; in order to avoid the possibility of the short circuit occurring.15495076156ZAR93200001263798ZAR9320000137975801/11/200131/12/2004
31/10/06R/2006/177RENAULTSCENIC II AND MEGANE II SALOONFRONT SEATS MAY NOT LOCK INTO POSITIONThere is a possibility that the seat back of the front seats may become difficult to adjust and or not lock into position.Recall the vehicles that are likely to be affected to check that all welding to the seat back frame is present. If the welds are not all present then the seat back frame will be replaced. 5354oarkMEGANE01/09/200331/10/2003
31/10/06R/2006/177RENAULTSCENIC II AND MEGANE II SALOONFRONT SEATS MAY NOT LOCK INTO POSITIONThere is a possibility that the seat back of the front seats may become difficult to adjust and or not lock into position.Recall the vehicles that are likely to be affected to check that all welding to the seat back frame is present. If the welds are not all present then the seat back frame will be replaced. 5354oarkSCENIC01/08/200331/10/2003
02/11/06R/2006/219CADILLACCHEVROLET CORVETTE Coupe Z06ROOF PANEL MAY DETACHIt is possible for adhesive to fail allowing separation of the roof panel and its frame. If the gradual separation is ignored total separation can occur.Recall the vehicles that are likely to be affected to inspect and where necessary replace the roof panel.26CORVETTE01/12/200501/12/2006
02/11/06R/2006/219CADILLACCHEVROLET CORVETTE Coupe Z06ROOF PANEL MAY DETACHIt is possible for adhesive to fail allowing separation of the roof panel and its frame. If the gradual separation is ignored total separation can occur.Recall the vehicles that are likely to be affected to inspect and where necessary replace the roof panel.26CHEVROLET01/01/200607/12/2006
03/11/06R/2006/197VOLVO BUSB7RPOSSIBLE LOSS OF STEERING CONTROLThe ball joint of the steering link rod may detach due to wear between the pin and the housing leading to loss of directional controlRecall affected vehicles and replace link rod with new version93C8153B7R
10/11/06R/2006/202MANA69 AND A49RISK OF FIREThe guide pin in the starter solenoid switch is incorrectly fitted which may cause the starter to overheat and cause smouldering damage.Recall affected vehicles and replace starter26213900eA69
10/11/06R/2006/202MANA69 AND A49RISK OF FIREThe guide pin in the starter solenoid switch is incorrectly fitted which may cause the starter to overheat and cause smouldering damage.Recall affected vehicles and replace starter26213900eA49
10/11/06R/2006/201MANTGASTEERING WHEEL MAY FAILSteering Wheel can crack and break at hubRecall affected vehicles inspect wheel hub for cracks and if necessary replace.71226106TG-A
13/11/06RM/2006/043YAMAHAYZF - R6THROTTLE MAY STICKUnder certain circumstances the Air Filter retaining screw may work loose and fall out potentially getting caught in the throttle valve and preventing it from closing properlyRecall affected machines and replace Air Filter with one with a revised fixing2208YZF-R6RJ111 - 0000301RJ111 - 001530401/10/200601/10/2006
14/11/06R/2006/171IVECO BUSEURORIDER 391.12.29 A_N AND 391.12.35 A-NINJECTOR PIPES MAY FAIL RESULTING IN THE POSSIBILITY OF A VEHICLE FIREIt has been identified that the possibility exists that the currently fitted fuel injector pipes may fail which under certain circumstances may result in a vehicle fire.Recalled vehicles will have the injector pipes replaced with those of current the production pending the development of a redesigned pipe. Until such time as theses become available pipes will be changed on a six monthly or 100 000 km basis.During the initial stage of this recall subject vehicles will be fitted with an engine bay fire extinguisher system. 221EURORIDERZCF662P000E000485ZGA662P000E004121
20/11/06R/2006/172SUZUKIGRAND VITARAINTERCOOLER PIPE CLAMP MAY FAILThere is a possibility that the outlet pipe of the intercooler may fail. In the worst case this could lead to the diesel particulate filter catching fire.Recall the vehicles that are likely to be affected and replace the intercooler pipe with a countermeasure part.2931GRAND VITARAJSAJTD44V00100054JSAJTD44V0020537128/06/200501/08/2006
21/11/06R/2006/165TOYOTAAVENSISPOSSIBILITY OF TYRE DEFLATIONOn certain Avensis vehicles equipped with 16 inch steel wheels due to the shape of the wheel trim there is a possibility that the edge of the wheel trim may interfere with the sidewall of the tyre. Should this occur whilst the vehicle is being driven the wheel trims may rotate which could lead to interference with the tyre valve. In the worst case and if the vehicle is continuously driven in this condition loss of tyre pressure could ensue. Recalled vehicles will have the steel wheels (standard equipment) replaced with aluminium alloy wheels.39rnp/mif/037AVENSISSB1BR56L#0E163480SB1BR56L#0E16602008/05/200619/06/2006
21/11/06R/2006/165TOYOTAAVENSISPOSSIBILITY OF TYRE DEFLATIONOn certain Avensis vehicles equipped with 16 inch steel wheels due to the shape of the wheel trim there is a possibility that the edge of the wheel trim may interfere with the sidewall of the tyre. Should this occur whilst the vehicle is being driven the wheel trims may rotate which could lead to interference with the tyre valve. In the worst case and if the vehicle is continuously driven in this condition loss of tyre pressure could ensue. Recalled vehicles will have the steel wheels (standard equipment) replaced with aluminium alloy wheels.39rnp/mif/037AVENSISSB1DR56L#0E163333SB1DR56L#0E16786208/05/200619/06/2006
21/11/06R/2006/165TOYOTAAVENSISPOSSIBILITY OF TYRE DEFLATIONOn certain Avensis vehicles equipped with 16 inch steel wheels due to the shape of the wheel trim there is a possibility that the edge of the wheel trim may interfere with the sidewall of the tyre. Should this occur whilst the vehicle is being driven the wheel trims may rotate which could lead to interference with the tyre valve. In the worst case and if the vehicle is continuously driven in this condition loss of tyre pressure could ensue. Recalled vehicles will have the steel wheels (standard equipment) replaced with aluminium alloy wheels.39rnp/mif/037AVENSISSB1ED56L#0E001899SB1ED56L#0E00240408/05/200619/06/2006
21/11/06R/2006/165TOYOTAAVENSISPOSSIBILITY OF TYRE DEFLATIONOn certain Avensis vehicles equipped with 16 inch steel wheels due to the shape of the wheel trim there is a possibility that the edge of the wheel trim may interfere with the sidewall of the tyre. Should this occur whilst the vehicle is being driven the wheel trims may rotate which could lead to interference with the tyre valve. In the worst case and if the vehicle is continuously driven in this condition loss of tyre pressure could ensue. Recalled vehicles will have the steel wheels (standard equipment) replaced with aluminium alloy wheels.39rnp/mif/037AVENSISSB1DD56L#0E002416SB1DD56L#0E00315308/05/200619/06/2006
22/11/06R/2006/212PEUGEOT206FRONT RIGHT HAND SEATBELT FIXING BOLT MAY FAILIt has been identified on a small number of vehicles that the spacer for the front right-hand seat belt fixing bolt may have been incorrectly fitted. It is therefore possible that in time this could result in the fixing for the assembly becoming insecure.Recalled vehicles will have the fitting of the spacer checked for compliance with the specification. If found to be necessary the trim will be repositioned and the assembly re-tightened to the correct torque.4YDK206
22/11/06R/2006/091TOYOTALand Cruiser 90 ( Colorada)POSSIBLE LOSS OF DRIVE.Due to insufficient strength of the rear axle drive shaft flange a fracture might develop under certain driving conditions. In the worst case the flange may become detached causing the vehicle to become immobilised. Recalled vehicles will have the right and left hand rear axle drive shafts replaced.7606LANDCRUISERJT111GJ9500001033JT111GJ950011758317/04/199606/01/1999
22/11/06R/2006/091TOYOTALand Cruiser 90 ( Colorada)POSSIBLE LOSS OF DRIVE.Due to insufficient strength of the rear axle drive shaft flange a fracture might develop under certain driving conditions. In the worst case the flange may become detached causing the vehicle to become immobilised. Recalled vehicles will have the right and left hand rear axle drive shafts replaced.7606LANDCRUISERJT111VJ9500001022JT111VJ950005352217/04/199606/01/1999
22/11/06R/2006/091TOYOTALand Cruiser 90 ( Colorada)POSSIBLE LOSS OF DRIVE.Due to insufficient strength of the rear axle drive shaft flange a fracture might develop under certain driving conditions. In the worst case the flange may become detached causing the vehicle to become immobilised. Recalled vehicles will have the right and left hand rear axle drive shafts replaced.7606LANDCRUISERJT111GJ9000001019JT111GJ900002389317/04/199606/01/1999
23/11/06R/2006/208SCANIA BUSK AND N SERIESSTEERING COLUMN MAY BECOME LOOSEThe bolt securing the steering shaft to the upper steering column may become looseRecall affected vehicles and check that the securing bolt is firmly located and correctly torqued. If found loose fit new bolt and tighten to the correct torque.96RC061304K
23/11/06R/2006/208SCANIA BUSK AND N SERIESSTEERING COLUMN MAY BECOME LOOSEThe bolt securing the steering shaft to the upper steering column may become looseRecall affected vehicles and check that the securing bolt is firmly located and correctly torqued. If found loose fit new bolt and tighten to the correct torque.96RC061304N
24/11/06R/2006/174IVECOEUROCARGO MLD6REAR PASSENGER SEAT BELT MAY BE TOO SHORTIt is possible that the rear seat belt for the rear seats may be too small and not possible to fasten by certain personsRecall affected vehicles and replace Seat Belts with correct type.197rcg06EUROCARGOZCFA1AAF120241488ZCFA1EJ020248192001/08/200331/03/2006
27/11/06R/2006/213PEUGEOT407POSSIBILITY OF FUEL LEAKIt has been identified that on certain vehicles a fault may be present on the diesel fuel circuit return pipe at the location of the pressure sensor.In the manufacture of the pipe an excess of material resulted in a reduction of the pipe's internal diameter therefore restricting the fuel flow and a risk of a diesel leak from the fuel connector.Subject vehicles will have the diesel fuel delivery pressure in the injection pump checked. This will check the conformity of the pipe which in the case of nonconformity will be replaced.115YCU407
27/11/06R/2006/130TOYOTAYARIS YARIS VERSO AND PRIUSENGINE MAY STALLDue to improper moulding of the body of the crankshaft position sensor engine oil may penetrate the seal and enter the sensor wiring connector. In this condition the engine oil within the sensor's wiring connector may expand due to engine heat and could deform the sensor. In the worst case the connector may become disconnected which could cause the engine to stall while driving and restarting would not be possible.Recalled vehicles will have the crankshaft position sensor replaced.7893RNP/MIF/032YARIS31/01/200129/10/2001
27/11/06R/2006/130TOYOTAYARIS YARIS VERSO AND PRIUSENGINE MAY STALLDue to improper moulding of the body of the crankshaft position sensor engine oil may penetrate the seal and enter the sensor wiring connector. In this condition the engine oil within the sensor's wiring connector may expand due to engine heat and could deform the sensor. In the worst case the connector may become disconnected which could cause the engine to stall while driving and restarting would not be possible.Recalled vehicles will have the crankshaft position sensor replaced.7893RNP/MIF/032YARIS VERSO31/01/200108/10/2001
27/11/06R/2006/130TOYOTAYARIS YARIS VERSO AND PRIUSENGINE MAY STALLDue to improper moulding of the body of the crankshaft position sensor engine oil may penetrate the seal and enter the sensor wiring connector. In this condition the engine oil within the sensor's wiring connector may expand due to engine heat and could deform the sensor. In the worst case the connector may become disconnected which could cause the engine to stall while driving and restarting would not be possible.Recalled vehicles will have the crankshaft position sensor replaced.7893RNP/MIF/032PRIUSJT153FU1#00024214JT153FU1#0004674731/01/200108/11/2001
27/11/06R/2006/180HONDACIVIC (5 DOOR) AND CIVIC HYBRIDPOWER STEERING MAY BE LOSTThe electrical power steering warning lamp may illuminate and power assistance to the steering will be lost. The driver will not experience any symptoms prior to the failure. The electric power steering control unit will be tested and replaced as necessary8872CIVIC01/09/200501/02/2006
28/11/06R/2006/184FIATSTILOSUSPENSION COIL SPRINGS MAY BREAKUnder environmental conditions that require the intensive use of salt on the roads corrosive deposits may infiltrate the rubber plate which supports the front suspension springs initiating seats of corrosion which may lead to the spring breaking after a period of time.To avoid damage to a tyre in the event of spring breakage a plate will be fitted which will contain the spring.442215044STILOZFA19200000000001ZFA1920000064419701/10/200130/09/2006
28/11/06R/2006/207BMW1 SERIES AND 3 SERIESPOSSIBLE LOSS OF BRAKING POWER ASSISTANCEA temporary fault in the greasing system on the brake servo sealing ring could lead to the sealing ring being subject to wear. In unfavourable conditions the seal may be pressed into the brake servo housing as a consequence of increased friction. The arising leak will cause a hissing sound audible within the vehicle interior with the additional consequence that there may be a risk that loss of brake assistance will ensue.Recalled vehicles will have the brake servo replaced.2871 SERIES04/03/200614/03/2006
28/11/06R/2006/207BMW1 SERIES AND 3 SERIESPOSSIBLE LOSS OF BRAKING POWER ASSISTANCEA temporary fault in the greasing system on the brake servo sealing ring could lead to the sealing ring being subject to wear. In unfavourable conditions the seal may be pressed into the brake servo housing as a consequence of increased friction. The arising leak will cause a hissing sound audible within the vehicle interior with the additional consequence that there may be a risk that loss of brake assistance will ensue.Recalled vehicles will have the brake servo replaced.2873 SERIES04/03/200614/03/2006
01/12/06R/2007/021MERCEDES BENZVITO & VIANOSHORT CIRCUIT MAY OCCURThe battery to starter motor cable is routed close to the exhaust. In some circumstances the insulation might melt.Recall the vehicles that are likely to be affected to fit an additional cable tie to the battery to starter motor cable.77C095VITO
01/12/06R/2007/021MERCEDES BENZVITO & VIANOSHORT CIRCUIT MAY OCCURThe battery to starter motor cable is routed close to the exhaust. In some circumstances the insulation might melt.Recall the vehicles that are likely to be affected to fit an additional cable tie to the battery to starter motor cable.77C095VIANO
04/12/06RM/2006/046TRIUMPHSPRINT ST1050 & SPRINT ST1050 WITH ABSREAR SUSPENSION BOLT MAY SHEARIt has been identified following engineering investigation that the rear suspension drag link to drop link sleeves and bolt as fitted to a number of models requires replacement. If left the bolt may bend or in the worst case shear. Should the bolt shear this would result in the machine's rear end dropping until the rear tyre came into contact with the underside of the rear mudguard. Subject machines will have the suspension link sleeve and bolt replaced.3057SPRINT ST01/11/200430/11/2006
05/12/06R/2006/210FERRARIF430BRAKE/CLUTCH FLUID MAY LEAKThere is a possibility that the clutch master cylinder inlet union might fail causing a loss of clutch/brake fluid and possible gear selection problems.Recall the vehicles that are likely to be affected and replace the clutch master cylinder inlet union with one that conforms to specification.91F430ZFFEZ59C000144361ZFFEW59A560149625
05/12/06R/2006/182MERCEDES BENZSMART FORTWOSEAT BELT FASTENINGS MAY NOT BE SECUREThe seat belt fastenings may not be secure.Recall the vehicles that are likely to be affected to inspect the fastenings and replace where necessary.10SO36SMART FORTWO
05/12/06R/2006/153MERCEDES BENZVITO & VIANOAIRBAG MAY NOT DEPLOYIt has been identified that due to a faulty control unit the airbag might not deploy in the event of a collision.Recalled vehicles will be fitted with a modified control unit. 3203CO80VITO
05/12/06R/2006/153MERCEDES BENZVITO & VIANOAIRBAG MAY NOT DEPLOYIt has been identified that due to a faulty control unit the airbag might not deploy in the event of a collision.Recalled vehicles will be fitted with a modified control unit. 3203CO80VIANO
08/12/06R/2006/146CHRYSLERVOYAGERHANDBRAKE MAY FAILIt has been identified that the handbrake may fail.Recalled vehicles will have the handbrake assembly replaced.11200F13VOYAGER
08/12/06R/2006/146CHRYSLERVOYAGERHANDBRAKE MAY FAILIt has been identified that the handbrake may fail.Recalled vehicles will have the handbrake assembly replaced.11200F13VOYAGER
08/12/06R/2006/186MERCEDES BENZACTROSSTEERING SHAFT MAY LOOSENThe steering column shaft may not have been tightened correctly. If left this will progress to steering wheel free movement and knocking noise. Ultimately there will be a loss of directional control.Recall the vehicles that are likely to be affected to check the steering shaft for security. If the steering shaft is insecure the shaft must be replaced.16C087ACTROS RANGE
08/12/06R/2006/149MERCEDES BENZACTOS & AXORVEHICLE STABILITY CONTROL MAY MALFUNCTIONThe intelligent stability control unit may not function correctly.Recalled vehicles will have the intelligent stability control unit replaced.9CO75ACTOS
08/12/06R/2006/149MERCEDES BENZACTOS & AXORVEHICLE STABILITY CONTROL MAY MALFUNCTIONThe intelligent stability control unit may not function correctly.Recalled vehicles will have the intelligent stability control unit replaced.9CO75AXOR
08/12/06R/2006/145CHRYSLERVOYAGERWINDSCREEN WIPERS MAY FAIL TO OPERATEThe windscreen wipers may fail to operate.Recalled vehicles will have the windscreen wiper motor replaced.1628F10VOYAGER
11/12/06R/2006/141MERCEDES BENZCL & SINSTRUMENT CLUSTER MAY NOT ILLUMINATE.Instrument cluster may not illuminate at all times.Recall vehicles and check the function of the instrument panel. If found to be faulty the instrument panel will be changed.5940PO74S CLASS01/01/200531/12/2005
11/12/06R/2006/141MERCEDES BENZCL & SINSTRUMENT CLUSTER MAY NOT ILLUMINATE.Instrument cluster may not illuminate at all times.Recall vehicles and check the function of the instrument panel. If found to be faulty the instrument panel will be changed.5940PO74CL CLASS01/01/200531/12/2005
11/12/06R/2006/183MERCEDES BENZC CLASSENGINE MAY CUT OUTA fuse within an electronic control module may become loose. This can result in the vehicle failing to start. In the worst case the engine may cut out whilst the vehicle is being driven. Recalled vehicles will have the subject module replaced.29PO80C CLASS
11/12/06R/2006/214CITROENC6POSSIBILITY OF FUEL LEAKIt has been identified that on certain vehicles a fault may be present on the diesel fuel circuit return pipe ay the location of the pressure sensor.In the manufacture of the pipe an excess of material resulted in a reduction of the pipe's internal diameter therefore restricting the fuel flow and a risk of a diesel leak from the fuel connector. Subject vehicles will have the diesel fuel delivery pressure in the injection pump checked. This will check the conformity of the pipe which in the case of nonconformity will be replaced.126XZSC6VF7******78004042VF7******7800564523/05/200619/07/2006
12/12/06RM/2006/042HONDA MOTORCYCLESNT700VA - 6REAR BRAKE PIPE NUT MAY NOT BE TORQUED CORRECTLYThere is a possibility that a brake pipe nut on the rear brake system may be incorrectly torqued which may lead to loss of brake fluid and loss of brake efficiencyRecall affected machines and check and if required reapply correct torque to brake pipe nut 840NT700VTMRC52B*6E000002VTMRC52B*6E008941
14/12/06R/2007/006VOLVO CARS40 ENGINE MAY FAILIt has been identified that due to a possible communication error between the Central Electronic Module (CEM)and the Engine Control Module (ECM) the engine may over run and break down.Recalled vehicles will have new software downloaded into the CEM1S40YV1MS765262177211YV1MS765262177211
15/12/06R/2006/190CHRYSLERWRANGLERVEHICLE MAY STALLThe clutch pedal push rod may break causing the clutch function to be lost.Recall the vehicles that are likely to be affected to replace the clutch pedal push rod plastic spacer foam seal and interlock switch cover.62F22WRANGLER01/01/200530/09/2006
15/12/06R/2006/150JEEPCHEROKEEENGINE MAY CUT OUT AND OR FAIL TO RESTARTIt has been identified that the wireless control module may fail with the result that the engine may fail to start or cut out.Recalled vehicles will have the wireless control module replaced.3300F20CHEROKEE
15/12/06R/2006/151CHRYSLER300EXHAUST EMISSIONS MAY BE INCORRECTIt has been identified that a number of vehicles may have a faulty absolute emissions sensor.Recalled vehicles will have the manifold absolute pressure sensor replaced.320F27300
15/12/06R/2006/188CHRYSLERDODGE RAMCONCERN THAT SEATBELT WILL NOT SECURE CHILDSEATIt has been identified that the front passenger seat belts may not tighten on certain models of child seat. Recalled vehicles will have the front passenger seat belts replaced.50F41DODGE RAM01/01/200530/09/2006
15/12/06R/2006/189CHRYSLERDODGE RAMFRONT PASSENGER AIRBAG MAY DEPLOY INCORRECTLYIt has been identified that the front passenger air bag may deploy with too much force when certain rear facing child seats are installed.Recalled vehicles will have the front passenger cushions replaced and the occupant restraint system re-programmed.39F40DODGE RAM01/01/200530/09/2006
15/12/06R/2006/185CHRYSLERJEEP - GRAND CHEROKEEENGINE MAY OVERHEATThe cooling fan blades may fracture and separate from the fan which will in certain circumstances allow the engine to overheat.Recall the vehicles that are likely to be affected to replace the fan assembly.1499F25GRAND CHEROKEE01/01/199931/12/2003
15/12/06R/2006/185CHRYSLERJEEP - GRAND CHEROKEEENGINE MAY OVERHEATThe cooling fan blades may fracture and separate from the fan which will in certain circumstances allow the engine to overheat.Recall the vehicles that are likely to be affected to replace the fan assembly.1499F25JEEP01/01/199931/12/2003
15/12/06R/2006/143CHRYSLERPT CRUISERDIRECTION INDICATORS MAY NOT FUNCTION CORRECTLYIt has been identified that the direction indicators may not function correctly.Recalled vehicles will have the indicator power module reprogrammed.3043F33PT CRUSIER
15/12/06R/2006/142MERCEDES BENZVITO & VIANOFUEL MAY LEAKIt has been identified that the possibility exists that a fuel line may not have been fitted correctly and may leak. Recalled vehicles will be checked for the presence of fuel leaks if evident the fuel line and fittings will be replaced. 102PO70VIANO01/01/200615/08/2006
15/12/06R/2006/142MERCEDES BENZVITO & VIANOFUEL MAY LEAKIt has been identified that the possibility exists that a fuel line may not have been fitted correctly and may leak. Recalled vehicles will be checked for the presence of fuel leaks if evident the fuel line and fittings will be replaced. 102PO70VITO01/01/200615/08/2006
19/12/06RM/2006/049KAWASAKIVN900B6F/B7FLAMP BRACKET MAY BECOME DETACHEDOn some eligible units the signal lamp bracket may crack due to vibration and rough riding conditions. If this condition is not corrected the bracket with the attached license plate could become detached from the motorcycle creating a road hazard.Recall the vehicles that are likely to be affected to replace the signal lamp bracket.173DAA200VN900KJAVN900BBA000453JKAVN900BBA010129
19/12/06RM/2006/049KAWASAKIVN900B6F/B7FLAMP BRACKET MAY BECOME DETACHEDOn some eligible units the signal lamp bracket may crack due to vibration and rough riding conditions. If this condition is not corrected the bracket with the attached license plate could become detached from the motorcycle creating a road hazard.Recall the vehicles that are likely to be affected to replace the signal lamp bracket.173DAA200VN900JKAVN900BBA014014JKAVN900BBA016364
19/12/06R/2006/225CITROENC2 C3 and C3 PlurielBRAKING EFFICIENCY MAY REDUCEIf the battery voltage is abnormally low the antilock braking system electronic control unit may not perform to specification which in rare cases may cause a reduction in braking efficiency.Recall the vehicles that are likely to be affected to replace the Electronic Control Unit.4032XZTC2VF7******97403721VF7******9741744615/06/200630/08/2006
19/12/06R/2006/225CITROENC2 C3 and C3 PlurielBRAKING EFFICIENCY MAY REDUCEIf the battery voltage is abnormally low the antilock braking system electronic control unit may not perform to specification which in rare cases may cause a reduction in braking efficiency.Recall the vehicles that are likely to be affected to replace the Electronic Control Unit.4032XZTC3VF7******28090704VF7******2875582221/06/200631/08/2006
20/12/06RM/2006/045HONDA MOTORCYCLESSCV 100FINCORRECT TORQUE SETTING COULD RESULT IN WHEEL RIM STUD BREAKAGEIt is possible that the front and or rear wheel rim nuts were not correctly tightened at the factory which could result in loosening of the nuts and continued riding in this situation could result in wheel rim stud damage.Recall the vehicles that are likely to be affected to check and where necessary tighten the nuts to specification.3536SCV100FME4JF11A058010390ME4JF11A05802401601/01/200527/11/2006
22/12/06R/2006/199BMWE34 TouringSTEERING LOCK MAY INADVERTENTLY ENGAGEThe control cam of the steering lock may break. This is most likely to occur as the vehicle is started or parked. However the possibility of this occurring whilst the vehicle is in motion cannot be ruled out. In this event the steering lock could engage with the effect that it would no longer be possible to steer the vehicle.Recall affected vehicles check manufacturer of lock and if necessary replace steering lock.22223 SERIES01/11/199501/11/1996
22/12/06R/2007/001VOLVO TRUCKFH & FMTAG AXLE HUB MAY DISLODGEIt has been identified that due to a misalignment of the weld and poor root penetration of the weld fillet material the TAG axle hub may dislodge from the axle.Affected vehicles will have the TAG axle replaced.21C0770FH
22/12/06R/2007/001VOLVO TRUCKFH & FMTAG AXLE HUB MAY DISLODGEIt has been identified that due to a misalignment of the weld and poor root penetration of the weld fillet material the TAG axle hub may dislodge from the axle.Affected vehicles will have the TAG axle replaced.21C0770FM
22/12/06R/2006/204VOLVO BUSB7TLPOSSIBLE FAILURE OF OFFSIDE REAR BRAKE CAMSHAFTIt has been identified that the possibility exists that the offside rear brake camshaft may be subject to failure caused by excessive force imparted due to the upgrading of the spring brake chamber. In the event of camshaft failure braking effort will be lost at the affected wheel station.Recalled vehicles will have both rear spring brake actuators changed.1611S8210B7TL01/09/200231/05/2005
31/12/06RM/2006/048APRILIASPORT CITY 125 OR 200POSSIBILITY OF A FUEL LEAKIt has been identified that some Sport City machines could display a problem with the fuel level sensor ring nut which may under certain conditions result in a fuel leak.On machines which are likely to develop the problem the fuel tank will be changed.9SPORT CITYZD4VB000#6S001568ZD4VB000#6S00250301/01/200507/12/2006