Safety Recalls 2007

Launch Date	Recalls Number	Make	Recalls Model Information	Concern	Defect	Remedy	Vehicle Numbers	Manufacturer Ref	Model	VIN Start	VIN End	Build Start	Build End
Search Launch Date	Search Recalls Number	Search Make	Search Recalls Model Information	Search Concern	Search Defect	Search Remedy	Search Vehicle Numbers	Search Manufacturer Ref	Search Model	Search VIN Start	Search VIN End	Search Build Start	Search Build End
01/01/07	R/2007/020	MERCEDES BENZ	SPRINTER	WHEEL FLANGES MAY SPLIT	The wheel flanges may not be of sufficient strength and may split.	Recall the vehicles that are likely to be affected to fit modified wheels.	1	C097	SPRINTER
01/01/07	R/2006/218	LAND ROVER	RANGE ROVER	BRAKE FLUID MAY LEAK FROM BRAKE PIPE	Brake fluid may leak from either the right hand front or left hand front brake caliper bridge pipe	Recall affected vehicles and replace the caliper bridge pipe on all four calipers with a revised corrosion resistant part.	23	A054	RANGE ROVER	SALLMAMA42A100085	SALLMAM546A212895	04/07/2002	03/10/2006
01/01/07	R/2006/217	JAGUAR	XJ	BRAKE FLUID MAY LEAK FROM BRAKE PIPE	Brake fluid may leak from either the right hand front or left hand front brake caliper bridge pipe	Recall affected vehicles and replace the caliper bridge pipe on all four calipers with a revised corrosion resistant pipe	7		XJ	SAJAC91P45SG43477	SAJAA91PO5SG47273	16/12/2005	31/10/2006
02/01/07	RSPV/2006/016	KATO	MOBILE CRANE (MITSUBISHI FUSO CHASSIS)	CLUTCH MAY FAIL	There is a possibility that the clutch housing may crack which could in the worst case lead to the gearbox falling out of the chassis.	Recall the vehicles that are likely to be affected to change the clutch housing to a cast type. If cracked housing are found it may also be necessary to also fit a new flywheel housing.	150		VARIOUS
02/01/07	RSPV/2006/017	KATO	MOBILE CRANES (MITSUBISHI FUSO CHASSIS)	WHEEL MAY DETACH	There is a possibility that the front and or rear wheel hubs may crack which in the worst case could lead to wheel loss.	Recall the vehicles that are likely to be affected to inspect and dependant on type change the wheel hubs.	97		VARIOUS
03/01/07	R/2006/228	MAN	TGA ECT (ADR VEHICLES)	ELECTRICAL SHORT CIRCUIT MAY OCCUR	Some electrical plugs connected to the battery master switch may have been fitted with inadequate sealing to prevent water ingress to the electrical terminals. Water ingress in this area can lead to a total loss of vehicle electicals.	Recall the vehicles that are likely to be affected to water proof the affected terminals.	144	SI229302	ECT
03/01/07	R/2006/228	MAN	TGA ECT (ADR VEHICLES)	ELECTRICAL SHORT CIRCUIT MAY OCCUR	Some electrical plugs connected to the battery master switch may have been fitted with inadequate sealing to prevent water ingress to the electrical terminals. Water ingress in this area can lead to a total loss of vehicle electicals.	Recall the vehicles that are likely to be affected to water proof the affected terminals.	144	SI229302	TG-A
08/01/07	RM/2006/047	HARLEY DAVIDSON	DYNA - GN1 GP1 GV1 GW1 GX1	BATTERY TERMINALS MAY SHORT AGAINST BATTERY COVER	It is possible that under normal riding conditions a battery securing bolt may loosen allowing the battery to move. This can lead to the protective boot on the battery postive abrading through and "shorting" on the battery cover causing sparks and possibly fire.	Recall the vehicles that are likely to be affected to replace the centre battery securing bolt with a new bolt that has a locking patch on the threads.	490	126	DYNA			17/06/2005	06/02/2006
08/01/07	RM/2006/047	HARLEY DAVIDSON	DYNA - GN1 GP1 GV1 GW1 GX1	BATTERY TERMINALS MAY SHORT AGAINST BATTERY COVER	It is possible that under normal riding conditions a battery securing bolt may loosen allowing the battery to move. This can lead to the protective boot on the battery postive abrading through and "shorting" on the battery cover causing sparks and possibly fire.	Recall the vehicles that are likely to be affected to replace the centre battery securing bolt with a new bolt that has a locking patch on the threads.	490	126	DYNA			17/06/2005	06/02/2006
10/01/07	RM/2006/050	DUCATI	SPORT 1000 SPORT CLASSIC PS 1000 & GT1000	ENGINE MAY STALL	It has been identified that on affected machines the fuel hose may detach from either the fuel pump or the filter. This can result in the engine failing to start or stalling.	Affected machines will have the fuel hose clips tightened to a modified torque setting.	57		SPORT CLASSIC	ZDMC100AA6B004761	ZDMC103AA6B007155
10/01/07	RM/2006/050	DUCATI	SPORT 1000 SPORT CLASSIC PS 1000 & GT1000	ENGINE MAY STALL	It has been identified that on affected machines the fuel hose may detach from either the fuel pump or the filter. This can result in the engine failing to start or stalling.	Affected machines will have the fuel hose clips tightened to a modified torque setting.	57		SPORT 1000	ZDMC100AA6B004761	ZDMC103AA6B007155
10/01/07	RM/2006/050	DUCATI	SPORT 1000 SPORT CLASSIC PS 1000 & GT1000	ENGINE MAY STALL	It has been identified that on affected machines the fuel hose may detach from either the fuel pump or the filter. This can result in the engine failing to start or stalling.	Affected machines will have the fuel hose clips tightened to a modified torque setting.	57		GT 1000	ZDMC1900AA6B004761	ZDMC103AA6B007155
10/01/07	R/2007/003	FORD	SMAX & GALAXY	HEATED WINDSCREEN EARTH POINT MAY NOT BE TIGHTENED - RISK OF BURN DAMAGE TO TRIM	It has been identified that on subject vehicles the heated windscreen earthing point may not have been tightened to the specified torque. An incorrect torque may lead to electrical arcing and in extreme cases this arcing may cause scorching or burning of the surrounding trim components.	Recalled vehicles will have the subject earthing point inspected for correct installation and torque.	5153		GALAXY			01/12/2005	28/06/2006
10/01/07	R/2007/003	FORD	SMAX & GALAXY	HEATED WINDSCREEN EARTH POINT MAY NOT BE TIGHTENED - RISK OF BURN DAMAGE TO TRIM	It has been identified that on subject vehicles the heated windscreen earthing point may not have been tightened to the specified torque. An incorrect torque may lead to electrical arcing and in extreme cases this arcing may cause scorching or burning of the surrounding trim components.	Recalled vehicles will have the subject earthing point inspected for correct installation and torque.	5153		S-MAX			01/12/2005	28/06/2006
12/01/07	RCOMP/2007/001	ARVINMERITOR	BRAKE PAD KIT - MDP 5076	PADS MAY SPARK UNDER BRAKING	When the brakes are applied sparks emanate from the brake pads.	Recall the ADR and IP regulation vehicles that are likely to be affected to replace the brake pads.	2570		MDP5076			01/01/2005	31/12/2005
15/01/07	R/2006/205	VW	Transporter 5	2ND ROW SEAT BACKREST MAY NOT LATCH CORRECTLY	The back-rest of the 2nd seat row may not completely latch in. In an accident this could increase the risk of injury because the seat belts are attached to the back-rest.	Recall the vehicles that are likely to be affected to replace the bowden cable of the double seat bench.	4524	72C3	TRANSPORTER	WV2ZZZ7HZ5X000029	WV2ZZZ7HZ5X031776	01/12/2003	31/05/2006
15/01/07	R/2006/205	VW	Transporter 5	2ND ROW SEAT BACKREST MAY NOT LATCH CORRECTLY	The back-rest of the 2nd seat row may not completely latch in. In an accident this could increase the risk of injury because the seat belts are attached to the back-rest.	Recall the vehicles that are likely to be affected to replace the bowden cable of the double seat bench.	4524	72C3	TRANSPORTER	WV2ZZZ7HZ4X026035	WV2ZZZ7HZ4X042607	01/12/2003	31/05/2006
15/01/07	R/2006/205	VW	Transporter 5	2ND ROW SEAT BACKREST MAY NOT LATCH CORRECTLY	The back-rest of the 2nd seat row may not completely latch in. In an accident this could increase the risk of injury because the seat belts are attached to the back-rest.	Recall the vehicles that are likely to be affected to replace the bowden cable of the double seat bench.	4524	72C3	TRANSPORTER	WV2ZZZ7HZ4H000154	WV2ZZZ7HZ4H111920	01/12/2003	31/05/2006
15/01/07	R/2006/205	VW	Transporter 5	2ND ROW SEAT BACKREST MAY NOT LATCH CORRECTLY	The back-rest of the 2nd seat row may not completely latch in. In an accident this could increase the risk of injury because the seat belts are attached to the back-rest.	Recall the vehicles that are likely to be affected to replace the bowden cable of the double seat bench.	4524	72C3	TRANSPORTER	WV2ZZZ7HZ6X000200	WV2ZZZ7HZ6Z037493	01/12/2003	31/05/2006
15/01/07	R/2006/205	VW	Transporter 5	2ND ROW SEAT BACKREST MAY NOT LATCH CORRECTLY	The back-rest of the 2nd seat row may not completely latch in. In an accident this could increase the risk of injury because the seat belts are attached to the back-rest.	Recall the vehicles that are likely to be affected to replace the bowden cable of the double seat bench.	4524	72C3	TRANSPORTER	WV2ZZZ7HZ5H000025	`WV2ZZZ7H5H108546	01/12/2003	31/05/2006
15/01/07	R/2006/205	VW	Transporter 5	2ND ROW SEAT BACKREST MAY NOT LATCH CORRECTLY	The back-rest of the 2nd seat row may not completely latch in. In an accident this could increase the risk of injury because the seat belts are attached to the back-rest.	Recall the vehicles that are likely to be affected to replace the bowden cable of the double seat bench.	4524	72C3	TRANSPORTER	WV2ZZZ7HZ7X000002	WV2ZZZ7HZ7X000002	01/12/2003	31/05/2006
15/01/07	R/2006/205	VW	Transporter 5	2ND ROW SEAT BACKREST MAY NOT LATCH CORRECTLY	The back-rest of the 2nd seat row may not completely latch in. In an accident this could increase the risk of injury because the seat belts are attached to the back-rest.	Recall the vehicles that are likely to be affected to replace the bowden cable of the double seat bench.	4524	72C3	TRANSPORTER	WV#ZZZ7HZ6H000027	WV#ZZZ7HZ6H141328	01/12/2003	31/05/2006
15/01/07	RM/2007/001	BMW MOTORCYCLES	K1200S K1200R & K1200GT	OIL LEAKAGE MAY OCCUR	It has been identified that frequent short trip usage at low ambient temperatures causes condensation in the engine oil this condenses at the outlet port of the oil-tank breather. If temperature falls below 0 degrees Celsius this may cause condesate to freeze and block the breather line to the oil tank. The engine's lubrication system configuration means that the suction pump's oil delivery rate is higher than that of the delivery pump consequently the over pressure produced can cause the oil tank to rupture allowing oil to escape and contaminate the rear tyre.	Recalled machines will have the oil tank cap replaced.	2128		K SERIES			01/01/2005	22/01/2007
17/01/07	R/2007/008	MASERATI	QUATTROPORTE	REAR DOOR SAFETY LOCK INSTRUCTIONS IN MANUAL INCORRECT.	Due to a printing error in the Owner's Manual and Quick Reference Guide the operation of the rear door child safety locks is incorrectly detailed. As a consequence the driver may not operate the door child safety locks correctly.	Recalled vehicles will have the information pertaining to the operation of the rear door child safety locks updated.	420	158	QUATTROPORTE	ZAMCD39C000021048	ZAMCD39C000027527
17/01/07	R/2007/016	SCANIA TRUCK	ALL MODELS (TRUCKS AND BUSES)	TRACK ROD BALL JOINT CLAMP BOLT MAY NOT BE TO THE CORRECT TORQUE	It has been identified that the torque setting of the track rod ball joint clamp bolts may be insufficient.	Recalled vehicles will have the clamp bolts checked and re-torqued as necessary.	113	60702	VARIOUS
18/01/07	R/2006/215	IVECO	NEW DAILY 2006	POSSIBLE LOSS OF STEERING	The possibility exists that the steering input shaft may be incorrectly secured to the steering rack. This is a situation which if left un-rectified could lead to steering failure.	Subject vehicles will have the presence of the steering shaft retaining screw and green marker paint (indicating the correct tightening torque for the screw) checked. If the screw or paint mark are missing the situation will be rectified to conform to specification.	2179	RCT26	DAILY	ZCFC297200D318827	ZCFC65D000D329717	04/08/2006	14/11/2006
22/01/07	R/2007/009	SUZUKI	IGNIS AND SWIFT	BRAKES MAY FAIL	Under certain conditions there is a possibility that one of the two brake circuits may fail.	Recall the vehicle that are likely to be affected to replace the brake master cylinder.	2	R07/02	SWIFT			19/09/2005	23/09/2005
22/01/07	R/2007/009	SUZUKI	IGNIS AND SWIFT	BRAKES MAY FAIL	Under certain conditions there is a possibility that one of the two brake circuits may fail.	Recall the vehicle that are likely to be affected to replace the brake master cylinder.	2	R07/02	IGNIS			19/09/2005	23/09/2005
22/01/07	R/2007/005	VOLVO CAR	C70	WEIGHT INFORMATION LABEL HAS BEEN SUPPLIED WITH INCORRECT INFORMATION	On subject vehicles it has been identified that the wrong information has been given on the product label in respect of the maximum permitted front axle weight.	Recalled vehicles will have the label (which is a legal requirement) replaced.	181		C70
22/01/07	R/2007/019	VOLVO TRUCK	FH/FM	CAB HEATER DOES NOT MEET LEGLISLATION REQUIREMENTS	Some ADR vehicles have a common cab heater assembled instead of a cab heater for ADR vehicles. Because of this the ADR vehicles do not fulfil the ADR Regulations.	Recall the vehicles that are likely to be affected to replace the cab heater if the vehicle has been fitted with the wrong specification heater.	18	c0792	FM
22/01/07	R/2007/019	VOLVO TRUCK	FH/FM	CAB HEATER DOES NOT MEET LEGLISLATION REQUIREMENTS	Some ADR vehicles have a common cab heater assembled instead of a cab heater for ADR vehicles. Because of this the ADR vehicles do not fulfil the ADR Regulations.	Recall the vehicles that are likely to be affected to replace the cab heater if the vehicle has been fitted with the wrong specification heater.	18	c0792	FH
24/01/07	R/2007/014	PEUGEOT	407 & 607	FUEL LEAK MAY OCCUR	On subject vehicles the fitting of the diesel high pressure delivery pipe may be constricted. Should this be the case a fuel leak may occur.	Recalled vehicles will have the subject pipe checked and changed if found to be fitted incorrectly.	45	YCN	407
25/01/07	RCOMP/2007/002	WABCO	PREV VALVE	UNINDENTED APPLICATION OF THE BRAKES	It has been identified that in some cases overlapping of tolerances has the potential to make the black button of the PREV to stick in the pushed-in position when the trailer is coupled to the tractor unit. When this malfunction occurs the red warning lamp or signal for the trailer braking system on the dashboard of the truck will alert the driver that the reservoir air pressure in the trailer is dropping below 4.5 Bar. If this pressure falls below 2.5 Bar this will cause unintended braking of the vehicle.	To address the concern Wabco under the terms of the Code will contact customers who will be provided with a valve repair kit.	1294		PREV VALVE
26/01/07	R/2006/220	FIAT	IDEA	FRONT SUSPENSION CROSS MEMBER MAY FRACTURE	It has been identified that the chassis front cross member may have a weld which does not conform to specification. This may lead to a creaking noise being heard under braking and could in time lead to the cross member cracking in the area of it's mounting to the vehicle's body.	Recalled vehicles will have the front cross member replaced.	45		IDEA	ZFA35000000080810	ZFA35000000087024	01/03/2005	31/03/2005
29/01/07	R/2007/013	MAN	TGA	STEERING MAY FAIL	It has been identified that a number of vehicles have been fitted with a defective drag link. This has the potential to cause the steering to fail.	Affected vehicles will have the drag link replaced.	120	SI230104	TG-A
31/01/07	R/2006/216	IVECO	Stralis	CAB MAY SHUDDER UNDER EXTREME OPERATING CONDITIONS	Possibility that front Cab mounting bolts may be missing resulting in that Cab may shudder under extreme operating conditions.	Recall affected vehicles and fit new Cab mounting bolts	114	RCV36	STRALIS	WJMS2NUH004314789	WJMS2NUH043211554	01/05/2006	01/10/2006
31/01/07	R/2007/051	VOLVO TRUCK	FH/FM	GEARBOX HEAT SHIELD IS NOT AS PER SPECIFICATION	The incorrect gearbox heat shield has been assembled which does not fulfil the manufacturers demand regarding fire resistance.	Recall the vehicles that are likely to be affected to replace the heat shield.	3	c0802	FH
31/01/07	R/2007/051	VOLVO TRUCK	FH/FM	GEARBOX HEAT SHIELD IS NOT AS PER SPECIFICATION	The incorrect gearbox heat shield has been assembled which does not fulfil the manufacturers demand regarding fire resistance.	Recall the vehicles that are likely to be affected to replace the heat shield.	3	c0802	FM
31/01/07	RCOMP/2007/005	ISRINGHAUSEN (GB)LTD	PASSENGER SEAT BELT ATTACHMENT	SEAT BELT STALK MAY FAIL	The possibility exists that the seatbelt stalk mountings may fail inder extreme load conditions.	Recalled vehicles will have the seatbelt stalk attachment bracket bolted directly to the seat frame.	493		PASSENGER SEAT BELT ATTACHMENT
01/02/07	R/2007/017	MERCEDES BENZ	VITO & VIANO	FUEL MAY LEAK	In the event of the vehicle being involved in an accident fuel may leak from the fuel tank.	Recalled vehicles will have the production date of the fuel tank checked. The tank will be replaced if found to be within the affected range.	72	C103	VITO
01/02/07	R/2007/017	MERCEDES BENZ	VITO & VIANO	FUEL MAY LEAK	In the event of the vehicle being involved in an accident fuel may leak from the fuel tank.	Recalled vehicles will have the production date of the fuel tank checked. The tank will be replaced if found to be within the affected range.	72	C103	VIANO
01/02/07	R/2006/229	MERCEDES BENZ	Sprinter	ELECTRICAL SHORT CIRCUIT MAY OCCUR	Wiring harness from starter to alternator may detach power supply will fail and wiring may short circuit.	Recall affected vehicles check and if necessary replace harness.	1145	C102	SPRINTER			01/12/2006	01/12/2006
02/02/07	R/2006/224	FIAT	MULTIPLA - PETROL	POSSIBILITY OF A FUEL LEAK AND RISK OF FIRE	Due to the incorrect profiling of a rigid fuel pipe at the quick fit connection with the flexible fuel pipe for the injection manifold. The possibility exists that a fuel leak may develop at the connector and result in a fire in the engine compartment.	Recalled vehicles will have a locking insert fitted within the quick fit connector in order to prevent the connector from becoming loose.	14		MULTIPLA	ZFA18600002278144	ZFA18600002289211	01/06/2006	31/10/2006
05/02/07	RM/2006/051	RIEJU	RS2 125 MATRIX	RISK OF FIRE	Starter relay contacts may short circuit due to vibration.	Recall affected machines and fit rubber mounting for starter relay.	128		RIEJU	VTPRS4T0200600150	VTPRS4TO200600049	01/12/2005	01/12/2006
05/02/07	RM/2007/002	APRILIA	PEGAS0 650 & TRAIL	ENGINE MAT STALL	Engine may stall and/or exhibit abnormal running.	Recall affected machines check and if necessary replace throttle body TPS sensor.	85		PEGASO 650			01/01/2004	31/12/2005
05/02/07	RM/2007/002	APRILIA	PEGAS0 650 & TRAIL	ENGINE MAT STALL	Engine may stall and/or exhibit abnormal running.	Recall affected machines check and if necessary replace throttle body TPS sensor.	85		TRIAL			01/01/2004	31/12/2005
07/02/07	R/2007/024	VAUXHALL	CORSA D	STEERING CONTROL MAY BE LOST	It has been identified that on a certain number of 2007 model year vehicles the front lower suspension control arms might fracture near the bushing due to a production deviation during the welding process. The control arm may then lack rigidity; which may impair driving stability. In the worst case the driver may loose control of the vehicle.	Subject vehicles will have the control arm welds checked and replaced as necessary.	26502	06C007	CORSA
08/02/07	R/2007/038	OPTARE	SOLO	DRIVER'S SEAT MAY COLLAPSE SHOULD THE ADJUSTING MECHANISM BE SUBJECT TO WEAR.	It has been identified that under intensive operational conditions the driver's seat mechanism can wear and allow the seat to collapse.	Recalled vehicles will have the driver's seat exchanged.	480		SOLO	191230	192600	01/01/2004	31/01/2007
12/02/07	R/2007/030	VW	GOLF GOLF PLUS DIESEL	HEATING ELEMENT MAY OVERHEAT	The additional air heater heating element earth connection may overheat and in the most unfavourable cases may lead to a fire.	Recall the vehicles that are likely to be affected to check that the earth connection is sufficiently tight.	4842		GOLF	WVWZZZ1KZ7W534410	WVWZZZ1KZ7W582714	06/11/2006	12/01/2007
12/02/07	R/2007/030	VW	GOLF GOLF PLUS DIESEL	HEATING ELEMENT MAY OVERHEAT	The additional air heater heating element earth connection may overheat and in the most unfavourable cases may lead to a fire.	Recall the vehicles that are likely to be affected to check that the earth connection is sufficiently tight.	4842		GOLF	WVWZZZ1KZ7W087591	WVWZZZ1KZ7W159870	06/11/2006	12/01/2007
13/02/07	R/2007/031	VOLVO CAR	S80 & XC90	ENGINE MALFUNCTION LIGHT MAY ILLUMINATE	On petrol engined vehicles it has been found that the PCV (Positive Crank Ventilation) nipple may crack or become loose resulting in an air leak. This could cause a whistling sound and may cause the engine malfunction lamp to operate.	Recall the vehicles that are likely to be affected to replace the PCV nipple.	1139		XC90	690	85505
13/02/07	R/2007/031	VOLVO CAR	S80 & XC90	ENGINE MALFUNCTION LIGHT MAY ILLUMINATE	On petrol engined vehicles it has been found that the PCV (Positive Crank Ventilation) nipple may crack or become loose resulting in an air leak. This could cause a whistling sound and may cause the engine malfunction lamp to operate.	Recall the vehicles that are likely to be affected to replace the PCV nipple.	1139		S80	297000	366078
14/02/07	R/2006/135	RENAULT	RENAULT 21	RISK OF FIRE	It has been identified that the potential exists for the generation of an oil leak caused by the turbo oil supply pipe becoming loose. Should an oil leak from this component occur the possibility exists that a fire could ensue.	Recalled vehicles will have the turbo oil supply pipe checked and replaced as necessary.	270	oap9	21			01/01/1987	31/05/1993
16/02/07	RM/2007/014	BMW MOTORCYCLES	F650 GS DAKAR	SIDE STAND MAY DETACH	Due to a possibly misaligned weld the side stand may not be able to retain its load bearing capability in all circumstances.	Recall the machines that are likely to be affected to replace the frame bottom section.	48	462700	F SERIES
16/02/07	RM/2007/008	KAWASAKI	ER650- B6F & ER650-B7F	FRONT BRAKE MAY FAIL	It has been identified that the routing of the front brake hose may be incorrect as a result of manufacture or service due to an error in the service manual. This can cause the hose to contact the underside of the ignition switch body or the screw situated at the right hand side of the steering head. Continued use in this condition can lead to damage of the front brake hose with eventual leakage and resulting in the possibility of brake failure.	Recalled machines will have the front brake hose checked for routing position of the damper and condition. The hose damper will be repositioned as required and the hose replaced should this prove to be necessary.	147		ER650	JKAER650AB009336	JKAER650ABA040258
16/02/07	R/2007/034	BENTLEY MOTOR CARS	AZURE ARNARGE R T RL AND LIMOUSINE	ROAD WHEEL MAY BECOME DETACHED	It has been identified that affected vehicles have been fitted with wheel retaining bolts which do not conform to the dimensional specification. This can result in the wheel bolts becoming loose with the possibility that a wheel might detach.	Affected vehicles will be fitted with wheel bolts manufactured to the correct dimensional specification.	129	AGS EJD	ARNAGE			01/02/2005	31/08/2006
16/02/07	R/2007/034	BENTLEY MOTOR CARS	AZURE ARNARGE R T RL AND LIMOUSINE	ROAD WHEEL MAY BECOME DETACHED	It has been identified that affected vehicles have been fitted with wheel retaining bolts which do not conform to the dimensional specification. This can result in the wheel bolts becoming loose with the possibility that a wheel might detach.	Affected vehicles will be fitted with wheel bolts manufactured to the correct dimensional specification.	129	AGS EJD	AZURE			01/02/2005	31/08/2006
19/02/07	RM/2007/006	YAMAHA	MT-03	SIDE STAND MAY FAIL	Under certain circumstances the side-stand bracket may break possibly causing the motorcycle to fall over if resting on the stand at the time.	Recall the machines that are likely to be affected to replace the side stand bracket and to check and where necessary replace the wiring harness.	634		MT	RM021000000000301	RM021000000008715
19/02/07	RM/2007/005	YAMAHA	MT-03	WATER INGRESS INTO MAIN WIRING HARNESS	It has been identified that under certain circumstances such as heavy rain or cleaning with a high pressure washer. Water may enter the main wiring harness giving the potential to create engine running problems.	Recalled machines will have the subject wiring checked and replaced as necessary.	634		MT	RM021000000000301	RM021000000008715
19/02/07	RM/2007/011	DUCATI	1098 Superbike	CAMBELT MOBILE TENSIONER MAY FAIL	It has been identified that the cambelt tensioners can lock against the cylinder cover which can result in damage to the cambelt.	Recalled machines will have the tensioners replaced.	72	717	1098SBK
19/02/07	RM/2007/007	DUCATI	1098 SBK	FUEL MAY LEAK	It has been identified that on the subject machines the clamps on the fuel supply lines may not have been tightened to the correct torque. Should the torque be incorrect a fuel leak may ensue.	Recalled machines will have the fuel line clamps checked and tightened to the correct torque as necessary.	69		1098SBK
21/02/07	R/2007/041	RENAULT TRUCKS UK LTD	PREMIUM DXI EURO 4 AND LANDER EURO 3 RTI	FIFTH WHEEL SUBFRAME MOUNTING BOLTS INCORRECTLY TIGHTENED	It has been identified that during production the fifth wheel sub-frame mounting bolts were not tightened to the correct torque.	Recalled vehicles will have the subject bolts checked for the correct torque.	4	ITC	PREMIUM RANGE			30/05/2006	05/02/2007
21/02/07	R/2007/037	PEUGEOT	Boxer III	HANDBRAKE ASSEMBLY MAY BECOME INSECURE	It has been identified that the welding operation on the sleeve end panel of the handbrake system may not have been correctly carried out. This could result in greatly reduced handbrake efficiency.	Recalled vehicles will have the subject assembly strengthened.	15	YDC	BOXER III
21/02/07	R/2007/036	RENAULT TRUCKS UK LTD	MIDLUM DCi/DXI EURO 3 EURO 4.	RISK OF REAR WHEELS LOCKING UP WHEN DRIVING.	Water may be present in the rear brake actuators which in certain circumstances can cause the rear brakes to lock up when driving.	Recall the vehicles that are likely to be affected to drain any water from the rear brake actuators.	364		EURO4			01/06/2006	08/02/2007
21/02/07	R/2007/036	RENAULT TRUCKS UK LTD	MIDLUM DCi/DXI EURO 3 EURO 4.	RISK OF REAR WHEELS LOCKING UP WHEN DRIVING.	Water may be present in the rear brake actuators which in certain circumstances can cause the rear brakes to lock up when driving.	Recall the vehicles that are likely to be affected to drain any water from the rear brake actuators.	364		EURO3			01/06/2006	08/02/2007
21/02/07	R/2007/036	RENAULT TRUCKS UK LTD	MIDLUM DCi/DXI EURO 3 EURO 4.	RISK OF REAR WHEELS LOCKING UP WHEN DRIVING.	Water may be present in the rear brake actuators which in certain circumstances can cause the rear brakes to lock up when driving.	Recall the vehicles that are likely to be affected to drain any water from the rear brake actuators.	364		MIDLUM DCi/DXI			01/06/2006	08/02/2007
21/02/07	R/2007/039	PEUGEOT	407	RISK OF FIRE	There is a possibility of a non conformity of the engine cooling motor fan unit which can result in a failure of the unit or exceptionally in local overheating that can result in combustion of the unit.	Recall affected vehicles and replace the motor fan unit.	896		407			15/02/2006	31/08/2006
22/02/07	R/2006/223	MERCEDES BENZ	SPRINTER	SUSPENSION SPRING MAY FRACTURE	It has been identified that during manufacture insufficient wax was applied to the front of the rear axle road springs. This in extreme circumstances can lead to failure of the spring.	Recalled vehicles will have the rear road spring front mounting brackets replaced.	4	C100	SPRINTER
23/02/07	R/2007/015	FORD	TRANSIT	POSSIBLE PARTIAL DETACHMENT OF FRONT SUSPENSION LOWER ARM.	It has been identified that a number of vehicles have been produced with front suspension lower arm bolts which may have been tightened to an incorrect torque. In this condition failure of a bolt may result in partial detachment of the arm from the subframe which could adversely affect the steering and stability control.	Recalled vehicles will have the subject bolts checked for correct torque and tightened if necessary. Should any bolt be found to be damaged it will be replaced.	846	6U060	TRANSIT			05/07/2006	12/07/2006
27/02/07	RM/2007/004	HARLEY DAVIDSON	SPORTSTER XL883 XL883C XL883R XL883L XL1200C XL1200R XL1200L & XL50	STEERING MAY BE IMPEDED	Front fender may contact Voltage Regulator and impede steering operation.	Recall affected machines and relocate Voltage Regulator	753	128	SPORTSTER			24/05/2006	14/11/2006
27/02/07	RM/2007/003	HARLEY DAVIDSON	FXDWGI & FXDWG	HANDLEBARS MAY CRACK	Handlebars bearing part No 59782-06/A may crack and eventually fracture	Recall affected machines and fit replacement handlebars bearing part No 59782-06B	125	127	FXD			17/06/2005	04/12/2006
01/03/07	RSPV/2007/003	HONDA POWER EQUIPMENT	TRX45OER & TRX450R	POTENTIAL LOSS OF VEHICLE CONTROL	It has been identified that the front suspension ball joints may separate causing loss of control.	Recalled machines will have the front suspension ball joints replaced with quality assured items.	20		TRX	JH2TE32U*6K000001	JH2TR32U*6K000211
01/03/07	RSPV/2007/003	HONDA POWER EQUIPMENT	TRX45OER & TRX450R	POTENTIAL LOSS OF VEHICLE CONTROL	It has been identified that the front suspension ball joints may separate causing loss of control.	Recalled machines will have the front suspension ball joints replaced with quality assured items.	20		TRX	JH2TE32U*6K000212	JH2TE32U*6K000227
01/03/07	R/2006/211	JEEP	GRAND CHEROKEE	FRONT SEAT HEATING ELEMENTS MAY OVERHEAT	It has been identified that the front seat heating elements may overheat. This in extreme circumstances may result in an interior fire.	Recalled vehicles will have both front seat heating elements replaced.	6148	F17	GRAND CHEROKEE			01/01/2002	31/12/2005
01/03/07	RSPV/2007/001	LUNAR	2.5 GT	ROOF LIGHT IN OVERHEAD CAB MAY BECOME DETACHED	Roof light in vehicle overhead cab pod may become detached and possibly be a danger to other road users.	Recall the vehicles that are likely to be affected to test and where necessary re-bond the roof light.	2		2.5 GT			30/01/2006	08/02/2006
01/03/07	R/2007/018	MERCEDES BENZ	UNIMOG	MALFUNCTION OF CLUTCH CONTROL MAY LEAD TO BRAKE FAILURE	A malfunction within the clutch control may occur which if 1st or 2nd gear is selected it may not be possible to stop the vehicle using the service brake.	Recalled vehicles will have the gear control unit replaced. Additionally following checking the clutch control unit may also require replacement.	23	U010	UNIMOG
05/03/07	R/2006/221	VW	PASSAT	WIPERS MAY DETACH	It has been identified that on some Passat vehicles the windscreen wipers may fail to operate because of a software fault.	Affected vehicles will have a cap for the windscreen wiper motor fitted	43357	92B6	SHARAN	WVWZZZ7MZ2V019567	WVWZZZ7MZ2V033866	06/11/2001	26/11/2001
05/03/07	R/2006/221	VW	PASSAT	WIPERS MAY DETACH	It has been identified that on some Passat vehicles the windscreen wipers may fail to operate because of a software fault.	Affected vehicles will have a cap for the windscreen wiper motor fitted	43357	92B6	PASSAT	WVW**3C69000001	WVW**3C69999999	01/04/2005	31/08/2006
05/03/07	R/2006/221	VW	PASSAT	WIPERS MAY DETACH	It has been identified that on some Passat vehicles the windscreen wipers may fail to operate because of a software fault.	Affected vehicles will have a cap for the windscreen wiper motor fitted	43357	92B6	PASSAT	WVW**3C6E000001	WVW**3C7E057666	01/04/2005	31/08/2006
05/03/07	R/2006/221	VW	PASSAT	WIPERS MAY DETACH	It has been identified that on some Passat vehicles the windscreen wipers may fail to operate because of a software fault.	Affected vehicles will have a cap for the windscreen wiper motor fitted	43357	92B6	PASSAT	WVW**3C6Z000001	WVW**3C6Z999999	01/04/2005	31/08/2006
05/03/07	R/2006/221	VW	PASSAT	WIPERS MAY DETACH	It has been identified that on some Passat vehicles the windscreen wipers may fail to operate because of a software fault.	Affected vehicles will have a cap for the windscreen wiper motor fitted	43357	92B6	PASSAT	wvw**3C7E000001	WVW**3C7E057666	01/04/2005	31/08/2006
05/03/07	R/2006/221	VW	PASSAT	WIPERS MAY DETACH	It has been identified that on some Passat vehicles the windscreen wipers may fail to operate because of a software fault.	Affected vehicles will have a cap for the windscreen wiper motor fitted	43357	92B6	PASSAT	WVW**3C7Z000001	WVW**3C7Z000302	01/04/2005	31/08/2006
05/03/07	R/2006/221	VW	PASSAT	WIPERS MAY DETACH	It has been identified that on some Passat vehicles the windscreen wipers may fail to operate because of a software fault.	Affected vehicles will have a cap for the windscreen wiper motor fitted	43357	92B6	PASSAT	WVW**3C6P000001	WVW**3C6P999999	01/04/2005	31/08/2006
05/03/07	R/2006/221	VW	PASSAT	WIPERS MAY DETACH	It has been identified that on some Passat vehicles the windscreen wipers may fail to operate because of a software fault.	Affected vehicles will have a cap for the windscreen wiper motor fitted	43357	92B6	PASSAT	WVW**3C5P000001	WVW**3C7P036002	01/04/2005	31/08/2006
05/03/07	R/2006/221	VW	PASSAT	WIPERS MAY DETACH	It has been identified that on some Passat vehicles the windscreen wipers may fail to operate because of a software fault.	Affected vehicles will have a cap for the windscreen wiper motor fitted	43357	92B6	PASSAT	WVW**3C79000001	WVW**3C79000014	01/04/2005	31/08/2006
05/03/07	R/2006/221	VW	PASSAT	WIPERS MAY DETACH	It has been identified that on some Passat vehicles the windscreen wipers may fail to operate because of a software fault.	Affected vehicles will have a cap for the windscreen wiper motor fitted	43357	92B6	PASSAT	WVW**3C7P000001	WVW**3C7P036002	01/04/2005	31/08/2006
06/03/07	R/2007/025	HONDA	CIVIC HYBRID	ENGINE MAY CUT OUT	It has been established that when the rear seat is occupied the deformation of the seat back may cause a brief interference between a protection plate and an electrical connector. This can result in the main fuse blowing causing the engine to cut out.	Recalled vehicles will have an additional plastic cover placed over the subject electrical connector.	569		CIVIC			01/09/2005	11/09/2005
09/03/07	R/2007/032	MAZDA	PREMACY MAZDA 6 AND MAZDA 6 ESTATE	AIR BAG MAY FAIL	The airbag warning lamp may illuminate. Airbag activation system is disabled. In worst case the airbag may be activated unintentionally.	Recall the vehicles that are likely to be affected to replace the central processing unit.	2265		PREMACY	JMZCP19**21300011	JMZCP19**21316449	17/07/2001	31/01/2002
09/03/07	R/2007/032	MAZDA	PREMACY MAZDA 6 AND MAZDA 6 ESTATE	AIR BAG MAY FAIL	The airbag warning lamp may illuminate. Airbag activation system is disabled. In worst case the airbag may be activated unintentionally.	Recall the vehicles that are likely to be affected to replace the central processing unit.	2265		PREMACY	JMZCP19**01169960	JMZCP19**01316419	12/07/2001	31/01/2002
09/03/07	R/2007/032	MAZDA	PREMACY MAZDA 6 AND MAZDA 6 ESTATE	AIR BAG MAY FAIL	The airbag warning lamp may illuminate. Airbag activation system is disabled. In worst case the airbag may be activated unintentionally.	Recall the vehicles that are likely to be affected to replace the central processing unit.	2265		6	JMZGG1***31107869	JMZGG1***31118272	11/05/2002	24/06/2002
09/03/07	R/2007/032	MAZDA	PREMACY MAZDA 6 AND MAZDA 6 ESTATE	AIR BAG MAY FAIL	The airbag warning lamp may illuminate. Airbag activation system is disabled. In worst case the airbag may be activated unintentionally.	Recall the vehicles that are likely to be affected to replace the central processing unit.	2265		6 Estate	JMZGY19R231100112	JMZGY19R231101059	07/06/2002	22/06/2002
09/03/07	R/2007/032	MAZDA	PREMACY MAZDA 6 AND MAZDA 6 ESTATE	AIR BAG MAY FAIL	The airbag warning lamp may illuminate. Airbag activation system is disabled. In worst case the airbag may be activated unintentionally.	Recall the vehicles that are likely to be affected to replace the central processing unit.	2265		6 Estate	JMZGY19R201100116	JMZGY19F201100118	07/06/2002	07/06/2002
09/03/07	R/2007/032	MAZDA	PREMACY MAZDA 6 AND MAZDA 6 ESTATE	AIR BAG MAY FAIL	The airbag warning lamp may illuminate. Airbag activation system is disabled. In worst case the airbag may be activated unintentionally.	Recall the vehicles that are likely to be affected to replace the central processing unit.	2265		6	JMZGG1***01106593	JMZGG1***01118326	24/04/2002	24/06/2002
09/03/07	R/2007/011	FIAT	DUCATO (WITH DROPSIDE)	DROPSIDE PANEL MAY DETACH	It has been identified that the possibility exists that breakage of the dropside hinge fastening plate may occur on vehicles fitted with a factory installed dropside body. This can result in the detachment of the dropside panel.	Subject vehicles will be recalled at which time the hinge fastening plates will be changed.	29		DUCATO	ZFA24400007828525	ZFA24400007837578	01/05/2006	31/07/2006
09/03/07	RM/2007/013	YAMAHA	XV1700PC	ENGINE MAY STALL	In extreme circumstances vibration may cause the pick up coil lead wires to break causing the engine to stall.	Recalled machines will be fitted with a modified pick up coil.	117		XV1700	VP14E000000005350	VP14E000000007780
12/03/07	R/2007/010	SUZUKI	IGNIS	AIRBAG MAY DEPLOY IRREGULARLY	The airbag may deploy in an irregular fashion and possibly cause the passenger personal injury.	Recall the vehicles that are likely to be affected to replace the airbag bracket with a countermeasure part.	4008	R07/01	IGNIS	JSAFHV81S00100028	JSAFHV81S00104982	01/03/2003	03/09/2006
12/03/07	R/2007/010	SUZUKI	IGNIS	AIRBAG MAY DEPLOY IRREGULARLY	The airbag may deploy in an irregular fashion and possibly cause the passenger personal injury.	Recall the vehicles that are likely to be affected to replace the airbag bracket with a countermeasure part.	4008	R07/01	IGNIS	JSAFHX51S00157388	JSAFHX51S00159422	01/03/2003	03/09/2006
12/03/07	R/2007/010	SUZUKI	IGNIS	AIRBAG MAY DEPLOY IRREGULARLY	The airbag may deploy in an irregular fashion and possibly cause the passenger personal injury.	Recall the vehicles that are likely to be affected to replace the airbag bracket with a countermeasure part.	4008	R07/01	IGNIS	JSAFHV51S00151524	JSAFHV51S00172573	01/03/2003	03/09/2006
12/03/07	R/2007/052	VOLVO TRUCK	FL/FE	CAB MAY TILT UNEXPECTEDLY	It has been identified that some vehicles may have left the production facility with insufficient torque having been applied to the lower fixation of the cab tilt cylinder.	Recalled vehicles will have the torque of the fixing checked and adjusted as necessary.	49	c0812	FE
12/03/07	R/2007/052	VOLVO TRUCK	FL/FE	CAB MAY TILT UNEXPECTEDLY	It has been identified that some vehicles may have left the production facility with insufficient torque having been applied to the lower fixation of the cab tilt cylinder.	Recalled vehicles will have the torque of the fixing checked and adjusted as necessary.	49	c0812	FL
12/03/07	R/2007/026	ALFA ROMEO	159	ROOF BARS MAY FAIL	It has been identified that certain after market roof cross rails (not supplied by Alfa Romeo) could set up resonance frequencies within the rail that could in time lead to breakage of the longitudinal roof rails.	Recalled vehicles will be fitted with a new set of longitudinal roof rails.	81		159	ZAR93900007001091	ZAR93900007058612	01/01/2005	31/08/2006
12/03/07	R/2007/026	ALFA ROMEO	159	ROOF BARS MAY FAIL	It has been identified that certain after market roof cross rails (not supplied by Alfa Romeo) could set up resonance frequencies within the rail that could in time lead to breakage of the longitudinal roof rails.	Recalled vehicles will be fitted with a new set of longitudinal roof rails.	81		159	ZAR93900007001091	ZAR93900007058612	01/07/2005	31/08/2006
13/03/07	RM/2007/010	HARLEY DAVIDSON	XL883 XL883L XL883R XL1200L XL1200R XL50 FXD FXDB FXDC FXDL	INCORRECT FRONT TIRE FITTED TO THE VEHICLES WHICH MAY CAUSE PERFORMANCE ISSUES.	A tyre (90/90-19) which is a size that has not been tested on these machines has been fitted to front wheel. This could lead to the machine not performing to expectations and the possibility of an accident.	Recall the machines that are likely to be affected to replace the front tyre for one of the correct size (100/90-19).	32	129	XL883			26/10/2006	30/10/2006
13/03/07	RM/2007/010	HARLEY DAVIDSON	XL883 XL883L XL883R XL1200L XL1200R XL50 FXD FXDB FXDC FXDL	INCORRECT FRONT TIRE FITTED TO THE VEHICLES WHICH MAY CAUSE PERFORMANCE ISSUES.	A tyre (90/90-19) which is a size that has not been tested on these machines has been fitted to front wheel. This could lead to the machine not performing to expectations and the possibility of an accident.	Recall the machines that are likely to be affected to replace the front tyre for one of the correct size (100/90-19).	32	129	XL1200L			26/10/2006	30/10/2006
13/03/07	RM/2007/010	HARLEY DAVIDSON	XL883 XL883L XL883R XL1200L XL1200R XL50 FXD FXDB FXDC FXDL	INCORRECT FRONT TIRE FITTED TO THE VEHICLES WHICH MAY CAUSE PERFORMANCE ISSUES.	A tyre (90/90-19) which is a size that has not been tested on these machines has been fitted to front wheel. This could lead to the machine not performing to expectations and the possibility of an accident.	Recall the machines that are likely to be affected to replace the front tyre for one of the correct size (100/90-19).	32	129	FXD			26/10/2006	30/10/2006
13/03/07	RM/2007/010	HARLEY DAVIDSON	XL883 XL883L XL883R XL1200L XL1200R XL50 FXD FXDB FXDC FXDL	INCORRECT FRONT TIRE FITTED TO THE VEHICLES WHICH MAY CAUSE PERFORMANCE ISSUES.	A tyre (90/90-19) which is a size that has not been tested on these machines has been fitted to front wheel. This could lead to the machine not performing to expectations and the possibility of an accident.	Recall the machines that are likely to be affected to replace the front tyre for one of the correct size (100/90-19).	32	129	XL883L			26/10/2006	30/10/2006
13/03/07	RM/2007/010	HARLEY DAVIDSON	XL883 XL883L XL883R XL1200L XL1200R XL50 FXD FXDB FXDC FXDL	INCORRECT FRONT TIRE FITTED TO THE VEHICLES WHICH MAY CAUSE PERFORMANCE ISSUES.	A tyre (90/90-19) which is a size that has not been tested on these machines has been fitted to front wheel. This could lead to the machine not performing to expectations and the possibility of an accident.	Recall the machines that are likely to be affected to replace the front tyre for one of the correct size (100/90-19).	32	129	XL50			26/10/2006	30/10/2006
13/03/07	RM/2007/010	HARLEY DAVIDSON	XL883 XL883L XL883R XL1200L XL1200R XL50 FXD FXDB FXDC FXDL	INCORRECT FRONT TIRE FITTED TO THE VEHICLES WHICH MAY CAUSE PERFORMANCE ISSUES.	A tyre (90/90-19) which is a size that has not been tested on these machines has been fitted to front wheel. This could lead to the machine not performing to expectations and the possibility of an accident.	Recall the machines that are likely to be affected to replace the front tyre for one of the correct size (100/90-19).	32	129	FXDL			26/10/2006	30/10/2006
13/03/07	RM/2007/010	HARLEY DAVIDSON	XL883 XL883L XL883R XL1200L XL1200R XL50 FXD FXDB FXDC FXDL	INCORRECT FRONT TIRE FITTED TO THE VEHICLES WHICH MAY CAUSE PERFORMANCE ISSUES.	A tyre (90/90-19) which is a size that has not been tested on these machines has been fitted to front wheel. This could lead to the machine not performing to expectations and the possibility of an accident.	Recall the machines that are likely to be affected to replace the front tyre for one of the correct size (100/90-19).	32	129	XL883R			26/10/2006	30/10/2006
13/03/07	RM/2007/010	HARLEY DAVIDSON	XL883 XL883L XL883R XL1200L XL1200R XL50 FXD FXDB FXDC FXDL	INCORRECT FRONT TIRE FITTED TO THE VEHICLES WHICH MAY CAUSE PERFORMANCE ISSUES.	A tyre (90/90-19) which is a size that has not been tested on these machines has been fitted to front wheel. This could lead to the machine not performing to expectations and the possibility of an accident.	Recall the machines that are likely to be affected to replace the front tyre for one of the correct size (100/90-19).	32	129	FXDB			26/10/2006	30/10/2006
13/03/07	RM/2007/010	HARLEY DAVIDSON	XL883 XL883L XL883R XL1200L XL1200R XL50 FXD FXDB FXDC FXDL	INCORRECT FRONT TIRE FITTED TO THE VEHICLES WHICH MAY CAUSE PERFORMANCE ISSUES.	A tyre (90/90-19) which is a size that has not been tested on these machines has been fitted to front wheel. This could lead to the machine not performing to expectations and the possibility of an accident.	Recall the machines that are likely to be affected to replace the front tyre for one of the correct size (100/90-19).	32	129	FXDC			26/10/2006	30/10/2006
13/03/07	RM/2007/010	HARLEY DAVIDSON	XL883 XL883L XL883R XL1200L XL1200R XL50 FXD FXDB FXDC FXDL	INCORRECT FRONT TIRE FITTED TO THE VEHICLES WHICH MAY CAUSE PERFORMANCE ISSUES.	A tyre (90/90-19) which is a size that has not been tested on these machines has been fitted to front wheel. This could lead to the machine not performing to expectations and the possibility of an accident.	Recall the machines that are likely to be affected to replace the front tyre for one of the correct size (100/90-19).	32	129	XL1200R			26/10/2006	30/10/2006
13/03/07	R/2007/058	VOLVO CAR	S60 V70 XC70 AND XC90	FIRE MAY OCCUR	The electric cooling fan control unit's metal cover may not have the correct corrosion protection. Should corrosion occur water may enter the control unit causing an electrical malfunction and in extreme cases cause a fire in the engine compartment.	Recall the vehicles that are likely to be affected to fit an improved fan assembly.	388		V70	640517	643625
13/03/07	R/2007/058	VOLVO CAR	S60 V70 XC70 AND XC90	FIRE MAY OCCUR	The electric cooling fan control unit's metal cover may not have the correct corrosion protection. Should corrosion occur water may enter the control unit causing an electrical malfunction and in extreme cases cause a fire in the engine compartment.	Recall the vehicles that are likely to be affected to fit an improved fan assembly.	388		XC70	266511	268052
13/03/07	R/2007/058	VOLVO CAR	S60 V70 XC70 AND XC90	FIRE MAY OCCUR	The electric cooling fan control unit's metal cover may not have the correct corrosion protection. Should corrosion occur water may enter the control unit causing an electrical malfunction and in extreme cases cause a fire in the engine compartment.	Recall the vehicles that are likely to be affected to fit an improved fan assembly.	388		S60	622372	624377
13/03/07	R/2007/058	VOLVO CAR	S60 V70 XC70 AND XC90	FIRE MAY OCCUR	The electric cooling fan control unit's metal cover may not have the correct corrosion protection. Should corrosion occur water may enter the control unit causing an electrical malfunction and in extreme cases cause a fire in the engine compartment.	Recall the vehicles that are likely to be affected to fit an improved fan assembly.	388		XC90	362278	366398
14/03/07	R/2006/195	MITSUBISHI	GRANDIS (XP)	REAR SEAT MAY FAIL DURING REAR IMPACT	In the event of a rear end accident it is possible that the reclining mechanism of the second row seat could fail which may result in personal injury if the seat was occupied at the time.	Recall the vehicles that are likely to be affected to fit improved reclining adjusters to the second row seats.	90	R3013610	GRANDIS			08/12/2005	18/01/2006
14/03/07	R/2006/194	MITSUBISHI	LANCER "E-CAR"	OIL MAY LEAK	The Oil Cooler hose may fracture causing an oil leak	Recall affected vehicles and check gap between towing hook and oil cooler hose. If less than 15mm install modified pipe. If more than 15mm check pipe for damage and if necessary replace.	3	R3009700 & R3009710	LANCER
14/03/07	R/2006/192	MITSUBISHI	SPACE WAGON (CZL)	ENGINE MAY OVERHEAT	Upper coolant hose may detach causing loss of coolant.	Recall affected vehicles and fit new coolant hose and clamps.	257	R3010810	SPACE WAGON
14/03/07	R/2006/227	MITSUBISHI	SPACE RUNNER TURBO (DZ RVR)	AIR INLET INTERCOOLER MOUNTS MAY CRACK	The mountings for the intercooler air inlet (bonnet air intake garnish) is inappropriate and heat from the engine may cause mount deformation resulting in increased stress on the mounts. This condition could cause the mounts to crack and in a worst case scenario the bonnet air intake garnish could fall off potentially creating a traffic obstruction.	Recall the vehicles that are likely to be affected to fit new air intake garnish mountings.	10		SPACE RUNNER			01/01/1997	31/12/2002
14/03/07	R/2010/180	MERCEDES BENZ	SPRINTER	CRASH SIGNAL PROTOCOL MAY NOT OCCUR IN THE EVENT OF A COLLISION	A software error may exist in the airbag control unit which can prevent a crash signal being generated in the event of a rear-end collision. As a result automatic unlocking of the doors and switching on of the hazard lamps cannot be assured.	The recalled vehicles will have the airbag control unit replaced.	1	C078	SPRINTER	WDB9061352N300686	WDB9061352N300686
19/03/07	R/2006/226	LAND ROVER	DISCOVERY 3 - PETROL VARIANT	POSSIBILITY OF FUEL LEAKAGE	It has been identified that on vehicles fitted with fuel tanks which incorporate an internal breather pipe the breather pipe may not be to specification. This may result in swelling and cracking of a grommet and detachment of the breather pipe from a connector tube. In this condition fuel may enter the breather pipe resulting in MIL illumination fuel odour and drivability concerns such as hesitation misfiring stalling rough running or difficult starting. In the worst case fuel may be discharged onto the ground.	Recalled vehicles will have the fuel tank replaced.	103	P001	DISCOVERY	SALLAAA445A342834	SALLAAA546A359153	03/05/2005	28/09/2005
19/03/07	RM/2006/032	PIAGGIO	DERBI - GP1 50	SHOCK ABSORBER MAY DETACH	In extreme circumstances it is possible that the upper shock absorber support can shear causing the vehicle to drop down suddenly at the rear and leading to a likely loss of control of the vehicle.	Recall the vehicles that are likely to be affected to fit a repair kit that supports the upper shock absorber mounting bracket.	102		DERBI GP1 50
22/03/07	RM/2007/009	BUELL	XB12X	ENGINE MAY CUT OUT WITHOUT WARNING	A result of the vibration at the mounting location and the mis-routing of various wires the bank angle sensor can give a false "tip" signal which causes the engine to cut out. This could in certain circumstances cause an accident.	Recall the machines that are likely to be affected to move the bank angle sensor from the original location on the battery tray to the current production location on the seat latch.	518	833	XB12X			24/03/2005	05/10/2006
22/03/07	R/2007/062	NISSAN	QASHQAI	POTENTIAL LOSS OF VEHICLE CONTROL	It has been identified that the front suspension lower ball joints on some of the subject vehicles have not been fully seated into the hub. This has resulted in the securing bolt not fitting into the groove in the ball joint shank. If the situation goes uncorrected the ball joint could detach which could result in loss of vehicle control.	Recalled vehicles will be checked for correct location of the ball joint and rectified as necessary.	945		QASHQAI	SJNF*J101013272	SJNF**J10U1022002	12/02/2007	05/03/2007
26/03/07	R/2007/056	PORSCHE	911 GT3 AND 911 GT3RS (997)	SEAT BUCKLE MAY NOT DE-LATCH FOLLOWING AN IMPACT	It has been identified that the possibility exists that a faulty seat belt buckle has been installed as part of the six- point seat belt harness. If a faulty buckle has been installed it may not be possible open the buckle following an accident if the belt straps have been subject to a tensile load thus requiring the seat belt straps to be cut before the occupant could leave the vehicle.	Subject vehicles will have the seat belt buckle checked for the production date and replaced as necessary.	48	W721	911
27/03/07	R/2007/054	MAN	TGA (Right Hand Drive)	STEERING DRAG ARM MAY FAIL	It is possible that some right hand drive TGA vehicles may have been fitted with a steering drag arms that have not necessarily crack tested. If this notice is ignored and the remedial check/repair work is not carried out this could possibly lead to the steering failing.	Recall all affected vehicles to check and if necessary replace the effected parts with quality assured items.	111	SI236104	TG-A
01/04/07	RM/2007/017	MOTO GUZZI	CALIFORNIA 1100 EV AND CALIFORNIA 1100 STONE	LOSS OF CONTROL MAY OCCUR	The front fork bottom yoke may fail causing loss of control of the motorcycle.	Recall the machines that are likely to be affected to check the manufacturing batch code and where necessary replace the front fork bottom yoke.	154		CALIFORNIA	ZGUKDC11#2M111344	ZGUKDC4K#3M111512
01/04/07	RM/2007/017	MOTO GUZZI	CALIFORNIA 1100 EV AND CALIFORNIA 1100 STONE	LOSS OF CONTROL MAY OCCUR	The front fork bottom yoke may fail causing loss of control of the motorcycle.	Recall the machines that are likely to be affected to check the manufacturing batch code and where necessary replace the front fork bottom yoke.	154		CALIFORNIA	ZGUKDD00#3M111629	ZGUKDD02#3M111251
01/04/07	RM/2007/017	MOTO GUZZI	CALIFORNIA 1100 EV AND CALIFORNIA 1100 STONE	LOSS OF CONTROL MAY OCCUR	The front fork bottom yoke may fail causing loss of control of the motorcycle.	Recall the machines that are likely to be affected to check the manufacturing batch code and where necessary replace the front fork bottom yoke.	154		CALIFORNIA	ZGUKDB2K#3M200010	ZGUKDB2K#3M200035
01/04/07	R/2006/187	CHRYSLER	JEEP	BALL JOINTS MAY FAIL	It has been identified that the front suspension ball joints may suffer from water ingress that can cause the joint to corrode and separate.	Recalled vehicles will have the front suspension ball joints replaced.	16571	F23	JEEP			01/01/2001	30/09/2006
02/04/07	R/2010/179	MERCEDES BENZ	Sprinter	SHORT CIRCUIT MAY OCCUR	It is possible that an incorrect size terminal may have been fitted to the starter wiring harness. It could result in the wiring not being crimped correctly and cause a detachment of the wiring which could result in a short circuit.	Recall all affected vehicles and replace the starter-alternator wiring harness.	9	C110	SPRINTER
02/04/07	RSPV/2007/005	GEIST	LIBERTY MOTORHOME	TYRE VALVES MAY FAIL	It has been identified that the tyre valves may degrade leading to a risk of tyre blow out.	Recalled vehicles will have their tyres fitted with steel valves.	42		LIBERTY
05/04/07	R/2007/061	HONDA	ACCORD FR-V AND JAZZ	ENGINE MAY CUT OUT	The fuel pump relay may fail which will result in either the engine not starting or stalling.	Recall the vehicles that are likely to be affected to check and where necessary place the fuel pump relay.	6113		JAZZ			01/05/2005	31/05/2005
05/04/07	R/2007/061	HONDA	ACCORD FR-V AND JAZZ	ENGINE MAY CUT OUT	The fuel pump relay may fail which will result in either the engine not starting or stalling.	Recall the vehicles that are likely to be affected to check and where necessary place the fuel pump relay.	6113		FR-V			01/05/2005	31/05/2005
05/04/07	R/2007/061	HONDA	ACCORD FR-V AND JAZZ	ENGINE MAY CUT OUT	The fuel pump relay may fail which will result in either the engine not starting or stalling.	Recall the vehicles that are likely to be affected to check and where necessary place the fuel pump relay.	6113		ACCORD			01/05/2005	31/05/2005
05/04/07	R/2007/067	SCANIA TRUCK	PANEL R CABS	CLOSE PROXIMITY MIRROR MAY FAIL	Due to a fault within the raw material the close proximity mirror may fail due to vibration.	The close proximity mirrors will be replaced on subject vehicles.	592	61803	R SERIES
09/04/07	R/2007/063	FORD	TRANSIT CONNECT	WHEEL NUTS COULD CRACK	It has been identified due to incorrect heat treatment that the wheel nuts may become brittle and develop a crack in the conical washer.	Recalled vehicles will have the wheel nuts replaced.	222	6u079	CONNECT			21/10/2006	03/11/2006
11/04/07	R/2010/178	MERCEDES BENZ	G WAGON	DIRECTIONAL CONTROL MAY BE AFFECTED	It is possible that the differential lock switches may have been supplied with a defective printed circuit board. This could result in the differential not engaging turning off without warning or in the worst case the differential may engage without warning which could affect directional control of the vehicle.	Recall all affected vehicles and replace the differential switches.	1	P087	G WAGON	WDB4633411X168116	WDB4633411X168116
13/04/07	R/2007/044	RENAULT	CLIO III & MODUS	STOP LIGHT FAILURE	Under particular circumstances of use the potential exists for the stop light switch to melt due to overheating of the grease in the circuit switches with the potential for coking of the contacts. This can result in failure of the stop lights and overheating at the pedal floor or smoke in the passenger compartment.	Recalled vehicles will have the stop light switch replaced.	4234	OAU6	MODUS			14/12/2005	16/02/2006
13/04/07	R/2007/044	RENAULT	CLIO III & MODUS	STOP LIGHT FAILURE	Under particular circumstances of use the potential exists for the stop light switch to melt due to overheating of the grease in the circuit switches with the potential for coking of the contacts. This can result in failure of the stop lights and overheating at the pedal floor or smoke in the passenger compartment.	Recalled vehicles will have the stop light switch replaced.	4234	OAU6	CLIO			13/12/2005	08/02/2006
17/04/07	R/2007/071	PEUGEOT	207 - PETROL	POSSIBILITY OF AN ELECTRICAL SHORT CIRCUIT	It has been identified that the alternator terminal wiring could be positioned too close to the exhaust heat shield. Under extreme conditions this proximity could result in an electrical short circuit.	Recalled vehicles will checked and the subject terminal repositioned as necessary.	416	yev	207
18/04/07	R/2007/047	ALFA ROMEO	Brera	BRAKING EFFICIENCY WILL BE REDUCED	A reflective heat shield may be incorrectly fitted or missing. This could lead to the servo pipe being damaged and the loss of brake servo assistance.	Recall the vehicles that are likely to be affected to ensure correct fitment of the reflective sheath.	51		BRERA	ZAR93900005007316	ZAR93900005010903	01/06/2006	31/08/2006
19/04/07	R/2007/076	VOLVO CAR	V50	LOAD NET SUPPORT BRACKETS MAY FAIL	It has been identified that; certain welds for the front and rear load net fixings may not be to the required specification. In this condition there is a risk that under certain driving conditions such as sudden braking the brackets may fail causing the luggage to become insecure.	Recalled vehicles will have the subject welds inspected and re-welded should this prove to be necessary.	20		V50	306047	307754
20/04/07	R/2007/012	FIAT	IDEA PUNTO PANDA GRANDE PUNTO AND STILO	ENGINE POWER MAY BE LOST	It is possible that breakage of the ancillary devices pulley on the crankshaft may occur. Should this happen there is the possibility that engine power and functions such as power assisted steering and braking assistance may be lost.	Recalled vehicles will have the crankshaft pulley inspected and changed should this be necessary.	1474		GRANDE PUNTO	ZFA19900000010004	ZFA19900000010004	01/05/2006	31/05/2006
20/04/07	R/2007/012	FIAT	IDEA PUNTO PANDA GRANDE PUNTO AND STILO	ENGINE POWER MAY BE LOST	It is possible that breakage of the ancillary devices pulley on the crankshaft may occur. Should this happen there is the possibility that engine power and functions such as power assisted steering and braking assistance may be lost.	Recalled vehicles will have the crankshaft pulley inspected and changed should this be necessary.	1474		PUNTO	ZFA18800005352627	ZFA18800005352627	01/05/2006	31/05/2006
20/04/07	R/2007/012	FIAT	IDEA PUNTO PANDA GRANDE PUNTO AND STILO	ENGINE POWER MAY BE LOST	It is possible that breakage of the ancillary devices pulley on the crankshaft may occur. Should this happen there is the possibility that engine power and functions such as power assisted steering and braking assistance may be lost.	Recalled vehicles will have the crankshaft pulley inspected and changed should this be necessary.	1474		STILO	ZFA19200000583184	ZFA19200000630209	01/05/2006	31/05/2006
20/04/07	R/2007/012	FIAT	IDEA PUNTO PANDA GRANDE PUNTO AND STILO	ENGINE POWER MAY BE LOST	It is possible that breakage of the ancillary devices pulley on the crankshaft may occur. Should this happen there is the possibility that engine power and functions such as power assisted steering and braking assistance may be lost.	Recalled vehicles will have the crankshaft pulley inspected and changed should this be necessary.	1474		PUNTO	ZFA18800004972397	ZFA18800004972397	01/05/2006	31/05/2006
20/04/07	R/2007/012	FIAT	IDEA PUNTO PANDA GRANDE PUNTO AND STILO	ENGINE POWER MAY BE LOST	It is possible that breakage of the ancillary devices pulley on the crankshaft may occur. Should this happen there is the possibility that engine power and functions such as power assisted steering and braking assistance may be lost.	Recalled vehicles will have the crankshaft pulley inspected and changed should this be necessary.	1474		GRANDE PUNTO	ZFA19900001000014	ZFA19900001094860	01/05/2006	31/05/2006
20/04/07	R/2007/012	FIAT	IDEA PUNTO PANDA GRANDE PUNTO AND STILO	ENGINE POWER MAY BE LOST	It is possible that breakage of the ancillary devices pulley on the crankshaft may occur. Should this happen there is the possibility that engine power and functions such as power assisted steering and braking assistance may be lost.	Recalled vehicles will have the crankshaft pulley inspected and changed should this be necessary.	1474		PUNTO	ZFA18800004990567	ZFA18800004999998	01/05/2006	31/05/2006
20/04/07	R/2007/012	FIAT	IDEA PUNTO PANDA GRANDE PUNTO AND STILO	ENGINE POWER MAY BE LOST	It is possible that breakage of the ancillary devices pulley on the crankshaft may occur. Should this happen there is the possibility that engine power and functions such as power assisted steering and braking assistance may be lost.	Recalled vehicles will have the crankshaft pulley inspected and changed should this be necessary.	1474		PUNTO	ZFA18800000793362	ZFA18800000902645	01/05/2006	31/05/2006
20/04/07	R/2007/012	FIAT	IDEA PUNTO PANDA GRANDE PUNTO AND STILO	ENGINE POWER MAY BE LOST	It is possible that breakage of the ancillary devices pulley on the crankshaft may occur. Should this happen there is the possibility that engine power and functions such as power assisted steering and braking assistance may be lost.	Recalled vehicles will have the crankshaft pulley inspected and changed should this be necessary.	1474		IDEA	ZFA35000000092100	ZFA35000000132472	01/05/2006	31/05/2006
20/04/07	R/2007/012	FIAT	IDEA PUNTO PANDA GRANDE PUNTO AND STILO	ENGINE POWER MAY BE LOST	It is possible that breakage of the ancillary devices pulley on the crankshaft may occur. Should this happen there is the possibility that engine power and functions such as power assisted steering and braking assistance may be lost.	Recalled vehicles will have the crankshaft pulley inspected and changed should this be necessary.	1474		STILO	ZFA19200000576160	ZFA19200000576160	01/05/2006	31/05/2006
20/04/07	R/2007/012	FIAT	IDEA PUNTO PANDA GRANDE PUNTO AND STILO	ENGINE POWER MAY BE LOST	It is possible that breakage of the ancillary devices pulley on the crankshaft may occur. Should this happen there is the possibility that engine power and functions such as power assisted steering and braking assistance may be lost.	Recalled vehicles will have the crankshaft pulley inspected and changed should this be necessary.	1474		PANDA	ZFA16900000475266	ZFA16900000640654	01/05/2006	31/05/2006
20/04/07	R/2007/012	FIAT	IDEA PUNTO PANDA GRANDE PUNTO AND STILO	ENGINE POWER MAY BE LOST	It is possible that breakage of the ancillary devices pulley on the crankshaft may occur. Should this happen there is the possibility that engine power and functions such as power assisted steering and braking assistance may be lost.	Recalled vehicles will have the crankshaft pulley inspected and changed should this be necessary.	1474		GRANDE PUNTO	ZFA19900000000688	ZFA19900000087968	01/05/2006	31/05/2006
20/04/07	RSPV/2007/004	SUZUKI MOTORCYCLES	LT-Z90	STEERING MAY BE LOST	It has been found that some front suspension wishbone mounting eyes have insufficient weld applied. This could cause a front suspension to collapse and the loss of directional control.	Recall the vehicles that are likely to be affected to inspect the senpension arms and replace the suspension arms where necessary.	115	705	LT-Z90
20/04/07	R/2007/048	SUZUKI	SX4	PARKING BRAKE CABLE MAY DETACH	Parking brake cable end fixing may detach resulting in loss of parking brake	Recall the vehicles that are likely to be affected and inspect the cable end position and if necessary refix in the correct position and adjust as necessary. Cables to be replaced as necessary.	4368	R07/04	SX4
23/04/07	R/2007/045	JAGUAR	S-Type 2.7 V6 Diesel and XJ 2.7 V6 Diesel	DIESEL PARTICULATE FILTER EXCESSIVE HEAT	The diesel particulate filters (DPF) of the 2.7 litre engine may exhibit smoke and or fire from the underside of the vehicle flames emanating from within the rear exhaust tailpipe or an orange glow from the underside of the vehicle. Heat from within the DPF can radiate to the surrounding vehicle components and may lead to heating of the underside of the transmission tunnel and subsequent melting of interior components with the potential for an interior fire.	Recalled vehicles will have the engine management control module re-programmed with the latest calibration file. The vehicle will self test for DPF blockage which where required will be replaced.	8028		XJ	SAJAC721067G45259	SAJAA711377H17094	01/04/2005	31/03/2007
23/04/07	R/2007/045	JAGUAR	S-Type 2.7 V6 Diesel and XJ 2.7 V6 Diesel	DIESEL PARTICULATE FILTER EXCESSIVE HEAT	The diesel particulate filters (DPF) of the 2.7 litre engine may exhibit smoke and or fire from the underside of the vehicle flames emanating from within the rear exhaust tailpipe or an orange glow from the underside of the vehicle. Heat from within the DPF can radiate to the surrounding vehicle components and may lead to heating of the underside of the transmission tunnel and subsequent melting of interior components with the potential for an interior fire.	Recalled vehicles will have the engine management control module re-programmed with the latest calibration file. The vehicle will self test for DPF blockage which where required will be replaced.	8028		S TYPE	SAJAC031167N32679	SAJAA011387N82818	01/09/2004	31/03/2007
23/04/07	RSPV/2007/006	LTI	TXII AND TX4	STEERING CONTROL MAY BE LOST	The axle fastner of the rear axle panhard rod may fail. This will initially cause lateral movement of the axle which if ignored may lead to loss of directional control.	Recall the vehicles that are likely to be affected to replace the axle fastner of the panhard rod.	2697		TX4
23/04/07	RSPV/2007/006	LTI	TXII AND TX4	STEERING CONTROL MAY BE LOST	The axle fastner of the rear axle panhard rod may fail. This will initially cause lateral movement of the axle which if ignored may lead to loss of directional control.	Recall the vehicles that are likely to be affected to replace the axle fastner of the panhard rod.	2697		TX2
24/04/07	RM/2007/021	KTM	990 SUPER DUKE	BRAKES MAY FAIL	The friction material of the brake pad may become de-bonded which would lead to greater than expected stopping distances.	Recall the vehicles that are likely to be affected to replace the brake pads.	66		990 SUPERDUKE			01/11/2005	28/02/2006
26/04/07	R/2007/072	PEUGEOT	207	WINDSCREEN WIPERS MAY FAIL	The windscreen wiper wiring may be contacted by the wiper mechanism. If there is prolonged contact between the wiring and mechanism there is a risk of the wiper function failing.	Recall the vehicles that are likely to be affected to check and if necessary reposition the wiring.	2009	ycv	207
27/04/07	R/2007/033	FIAT	GRANDE PUNTO	STEERING COLUMN MAY BECOME DISCONNECTED	Incorrect profile (flaring) of the end of the steering shaft at the upper steering column universal joint. This may give the possibility of the steering column becoming disconnected from the universal joint with a consequent loss of vehicle steering.	Recall the vehicles that are likely to be affected to inspect the profile and flaring of the end of the steering shaft at the upper universal joint and where necessary renew the shaft.	5638	5156	GRANDE PUNTO	ZFA19900000107093	ZFA19900000156059	01/06/2006	31/07/2006
27/04/07	R/2007/033	FIAT	GRANDE PUNTO	STEERING COLUMN MAY BECOME DISCONNECTED	Incorrect profile (flaring) of the end of the steering shaft at the upper steering column universal joint. This may give the possibility of the steering column becoming disconnected from the universal joint with a consequent loss of vehicle steering.	Recall the vehicles that are likely to be affected to inspect the profile and flaring of the end of the steering shaft at the upper universal joint and where necessary renew the shaft.	5638	5156	GRANDE PUNTO	ZFA19900000097536	ZFA19900000097536	01/06/2006	31/07/2006
27/04/07	R/2007/033	FIAT	GRANDE PUNTO	STEERING COLUMN MAY BECOME DISCONNECTED	Incorrect profile (flaring) of the end of the steering shaft at the upper steering column universal joint. This may give the possibility of the steering column becoming disconnected from the universal joint with a consequent loss of vehicle steering.	Recall the vehicles that are likely to be affected to inspect the profile and flaring of the end of the steering shaft at the upper universal joint and where necessary renew the shaft.	5638	5156	GRANDE PUNTO	ZFA19900000024266	ZFA19900000024266	01/06/2006	31/07/2006
27/04/07	R/2007/033	FIAT	GRANDE PUNTO	STEERING COLUMN MAY BECOME DISCONNECTED	Incorrect profile (flaring) of the end of the steering shaft at the upper steering column universal joint. This may give the possibility of the steering column becoming disconnected from the universal joint with a consequent loss of vehicle steering.	Recall the vehicles that are likely to be affected to inspect the profile and flaring of the end of the steering shaft at the upper universal joint and where necessary renew the shaft.	5638	5156	GRANDE PUNTO	ZFA19900001088469	ZFA19900001136966	01/06/2006	31/07/2006
27/04/07	R/2007/033	FIAT	GRANDE PUNTO	STEERING COLUMN MAY BECOME DISCONNECTED	Incorrect profile (flaring) of the end of the steering shaft at the upper steering column universal joint. This may give the possibility of the steering column becoming disconnected from the universal joint with a consequent loss of vehicle steering.	Recall the vehicles that are likely to be affected to inspect the profile and flaring of the end of the steering shaft at the upper universal joint and where necessary renew the shaft.	5638	5156	GRANDE PUNTO	ZFA19900001235640	ZFA19900001235640	01/06/2006	31/07/2006
27/04/07	R/2007/040	RENAULT	TRAFIC II	ENGINE MAY SEIZE	It has been identified that a potential loss of engine cooling fan function (cooling fan number 2) will cause the engine to seize without warning due to overheating. The "STOP" warning light may or may not illuminate.	Recalled vehicles will have front-end wiring replaced.	12	OAUB	TRAFIC
27/04/07	R/2007/049	FIAT	SEDICI	HANDBRAKE MAY FAIL	It has been identified that the possibility exists that a disconnection of the handbrake cable may occur which can result in the handbrake becoming inefficient.	Recalled vehicles will have the fitment of the handbrake cable to the actuating lever checked. If found to be incorrect the situation will be rectified. If the handbrake cable is found to be damaged it will be replaced.	1479	5173	SEDICI	TSMFYB61S00100796	TSMFYB61S00154963	01/02/2006	31/12/2006
27/04/07	R/2007/049	FIAT	SEDICI	HANDBRAKE MAY FAIL	It has been identified that the possibility exists that a disconnection of the handbrake cable may occur which can result in the handbrake becoming inefficient.	Recalled vehicles will have the fitment of the handbrake cable to the actuating lever checked. If found to be incorrect the situation will be rectified. If the handbrake cable is found to be damaged it will be replaced.	1479	5173	SEDICI	TSMFYB21S00100756	TSMFYB21S00154918	01/02/2006	31/12/2006
29/04/07	RM/2007/022	KTM	990 Adventure	REAR BRAKE MAY BECOME INOPERATIVE	It has been identified that under certain riding conditions vibrations transmitted from the chassis to the rear brake hydraulic lines can create a phenomenon whereby gas is released from the brake fluid which can then collect in pockets in the brake lines. Any pockets of gas within the hydraulic circuit of the rear brake will significantly reduce the effectiveness of the system and in extreme cases will render the rear brake inoperative.	Recalled machines will have the original rear brake lines removed and replaced with superseded items that are designed to follow a different routing from the master cylinder to the rear brake caliper via the ABS modulator.	377		990 ADVENTURE			01/12/2005	31/01/2007
30/04/07	R/2007/066	MERCEDES BENZ	SLR	WHEEL BOLTS MAY BECOME LOOSE	It has been identified that under extreme driving conditions single wheel bolts may become loose.	Recalled vehicles will have the front wheels and wheel bolts replaced.	6	P092	SLR
30/04/07	R/2007/050	VW	POLO (with heated cloth seats)	SEAT MAY CATCH FIRE	It has been identified that due to an incorrectly sewn-in tension wire strap for the back-rest cover of the front seats there may be contact between the tension wire of the seat and the filaments of the seat heater. The resulting short circuit can lead to fire damage on the front seat covers.	Recalled vehicles will have the tension wires of the front seats insulated.	433		POLO	WVWZZZ9NZ7Y000001	WVWZZZ9NZ7Y163395	01/05/2006	28/02/2007
30/04/07	R/2007/050	VW	POLO (with heated cloth seats)	SEAT MAY CATCH FIRE	It has been identified that due to an incorrectly sewn-in tension wire strap for the back-rest cover of the front seats there may be contact between the tension wire of the seat and the filaments of the seat heater. The resulting short circuit can lead to fire damage on the front seat covers.	Recalled vehicles will have the tension wires of the front seats insulated.	433		POLO	WVWZZZ9NZ6Y000001	WVWZZZ*9N6Y261502	01/05/2005	28/02/2007
02/05/07	RCOMP/2007/004	YAMAHA	Warn Winch	RISK OF FIRE	In rare circumstances it is possible for the winch to overheat and create a potential fire hazard.	Recall the vehicles that are likely to be affected to replace the eight post contactor with a four post contactor.	31		WARN WINCH			01/05/2001	31/07/2004
05/05/07	R/2007/081	SCANIA TRUCK	All Models	FIRE MAY OCCUR	The mounting rail which connects the 24v supply between chassis and cab may be incorrectly torqued and heat may build up	Recalled vehicles will have the torque checked on the nuts which secure the connection rail.	1293	51662	VARIOUS
08/05/07	RM/2007/020	YAMAHA	YP125R & YP250R	FRAME MAY CRACK	It is a possibility that a small progressive crack may develop in the Frame which may result in instability.	Recall the machines to fit a reinforcement bracket kit to the Frame	458		YP250R			01/01/2006	30/04/2007
08/05/07	RM/2007/020	YAMAHA	YP125R & YP250R	FRAME MAY CRACK	It is a possibility that a small progressive crack may develop in the Frame which may result in instability.	Recall the machines to fit a reinforcement bracket kit to the Frame	458		YP125R			01/01/2006	30/04/2007
11/05/07	R/2007/080	CADILLAC	SRX	POSSIBILITY OF BRAKE FAILURE	It has been identified that some vehicles may have insufficient clearance between one or both of the rear brake pipes and the intermediate steering shaft. Should either of the pipes touch the shaft a hole could be worn in the pipe causing brake fluid to leak out. If sufficient brake fluid leaks from the system the brake warning light will illuminate and braking would be limited to two wheels. Once sufficient brake fluid has leaked out of the second pipe; brake failure would occur.	Recalled vehicles will have a section of the subject pipe replaced with one that has been redesigned to allow sufficient clearance between the brake pipe and the intermediate steering shaft.	54		SRX
11/05/07	RM/2007/018	SUZUKI MOTORCYCLES	VZR1800	FUEL MAY LEAK	A fuel leak may occur from the rubber hose that links the front and rear cylinder's curved metal fuel rails.	Recall the machines that are likely to be affected to replace the fuel rails with ones that have been modified.	304	r07/06	VZR1800	JS1CA111200100002	JS1CA111200100316	01/01/2006	20/04/2007
14/05/07	R/2007/077	KIA	SORENTO	CURTAIN AIRBAGS MAY DEPLOY INCORRECTLY	It has been identified that some of the wires to the airbag control unit are not in the correct order. In consequence an incorrect side curtain airbag could deploy in the event of a collision.	Recalled vehicles will have the pins on the connector to the control unit refitted in the correct order.	1864		SORENTO			04/05/2006	28/03/2007
14/05/07	RSPV/2007/010	HYMER UK LTD	HYMER/ NIESMANN+BISCHOFF MOTORHOME	SEAT BELT MAY FAIL TO OPERATE CORRECTLY IN A COLLISION.	The seat belt fitted to the vehicle cab seats may fail to operate correctly if involved in a collision.	Recall the affected vehicles and replace the seat belts with quality assured items.	59		FIAT/IVECO BASED
14/05/07	RSPV/2007/010	HYMER UK LTD	HYMER/ NIESMANN+BISCHOFF MOTORHOME	SEAT BELT MAY FAIL TO OPERATE CORRECTLY IN A COLLISION.	The seat belt fitted to the vehicle cab seats may fail to operate correctly if involved in a collision.	Recall the affected vehicles and replace the seat belts with quality assured items.	59		NIESMANN+BISCHOFF
16/05/07	R/2007/073	TOYOTA	YARIS	SEATING HEADRESTS MAY DETACH & AIRBAG MAY NOT DEPLOY SUFFICIENTLY IN AN IMPACT	It has been identified that the following seat defects may occur a Front and rear seats - the locking performance of the headrest may be insufficient during an impact and may cause ejection of the headrest from the seat back. b Front seats only- The reliability of the side airbag deployment on the front seats may be insufficient during an impact and may not offer the protection intended.	Recalled vehicles will have the following remedial actions performed:-a) The rear seat headrest guide springs and buttons will be replaced.b) The front seat headrest supports will be replaced. c) The front seat back pads and covers will be replaced.	19075	RNP/WXB	YARIS	VNKJL9#3#0A013738	VNKJL9#3#0A090052	04/11/2005	31/07/2006
16/05/07	R/2007/073	TOYOTA	YARIS	SEATING HEADRESTS MAY DETACH & AIRBAG MAY NOT DEPLOY SUFFICIENTLY IN AN IMPACT	It has been identified that the following seat defects may occur a Front and rear seats - the locking performance of the headrest may be insufficient during an impact and may cause ejection of the headrest from the seat back. b Front seats only- The reliability of the side airbag deployment on the front seats may be insufficient during an impact and may not offer the protection intended.	Recalled vehicles will have the following remedial actions performed:-a) The rear seat headrest guide springs and buttons will be replaced.b) The front seat headrest supports will be replaced. c) The front seat back pads and covers will be replaced.	19075	RNP/WXB	YARIS	VNKKC9#3#0A001024	VNKKC9#3#0A046882	04/11/2005	31/07/2006
16/05/07	R/2007/073	TOYOTA	YARIS	SEATING HEADRESTS MAY DETACH & AIRBAG MAY NOT DEPLOY SUFFICIENTLY IN AN IMPACT	It has been identified that the following seat defects may occur a Front and rear seats - the locking performance of the headrest may be insufficient during an impact and may cause ejection of the headrest from the seat back. b Front seats only- The reliability of the side airbag deployment on the front seats may be insufficient during an impact and may not offer the protection intended.	Recalled vehicles will have the following remedial actions performed:-a) The rear seat headrest guide springs and buttons will be replaced.b) The front seat headrest supports will be replaced. c) The front seat back pads and covers will be replaced.	19075	RNP/WXB	YARIS	VNKKG9#3#0A001018	VNKKG9#3#0A032844	04/11/2005	31/07/2006
16/05/07	R/2007/073	TOYOTA	YARIS	SEATING HEADRESTS MAY DETACH & AIRBAG MAY NOT DEPLOY SUFFICIENTLY IN AN IMPACT	It has been identified that the following seat defects may occur a Front and rear seats - the locking performance of the headrest may be insufficient during an impact and may cause ejection of the headrest from the seat back. b Front seats only- The reliability of the side airbag deployment on the front seats may be insufficient during an impact and may not offer the protection intended.	Recalled vehicles will have the following remedial actions performed:-a) The rear seat headrest guide springs and buttons will be replaced.b) The front seat headrest supports will be replaced. c) The front seat back pads and covers will be replaced.	19075	RNP/WXB	YARIS	VNKJC9#3#0A008629	VNKJC9#3#0A046881	04/11/2005	31/07/2006
16/05/07	R/2007/073	TOYOTA	YARIS	SEATING HEADRESTS MAY DETACH & AIRBAG MAY NOT DEPLOY SUFFICIENTLY IN AN IMPACT	It has been identified that the following seat defects may occur a Front and rear seats - the locking performance of the headrest may be insufficient during an impact and may cause ejection of the headrest from the seat back. b Front seats only- The reliability of the side airbag deployment on the front seats may be insufficient during an impact and may not offer the protection intended.	Recalled vehicles will have the following remedial actions performed:-a) The rear seat headrest guide springs and buttons will be replaced.b) The front seat headrest supports will be replaced. c) The front seat back pads and covers will be replaced.	19075	RNP/WXB	YARIS	VNKJG9#3#0A002425	VNKJG9#3#0A032787	04/11/2005	31/07/2006
16/05/07	R/2007/073	TOYOTA	YARIS	SEATING HEADRESTS MAY DETACH & AIRBAG MAY NOT DEPLOY SUFFICIENTLY IN AN IMPACT	It has been identified that the following seat defects may occur a Front and rear seats - the locking performance of the headrest may be insufficient during an impact and may cause ejection of the headrest from the seat back. b Front seats only- The reliability of the side airbag deployment on the front seats may be insufficient during an impact and may not offer the protection intended.	Recalled vehicles will have the following remedial actions performed:-a) The rear seat headrest guide springs and buttons will be replaced.b) The front seat headrest supports will be replaced. c) The front seat back pads and covers will be replaced.	19075	RNP/WXB	YARIS	VNKKL9#3#0A001022	VNKKL9#3#0A090056	04/11/2005	31/07/2006
16/05/07	R/2007/064	NISSAN	CABSTAR	SEAT ANCHORAGE MAY NOT BE SECURE	A concern has been detected in relation to the passenger seat cushion anchorage of some F24 Cabstar vehicles. If ignored the condition could result in a potential for the seat occupant to not be fully restrained in the case of a vehicle collision.	Recalled vehicles will have the (potentially) missing seat retaining bolt fitted.	6		CABSTAR	VWA**F24100012	VWA**F241012516	27/07/2006	07/03/2007
17/05/07	R/2010/172	MERCEDES BENZ	Sprinter	VEHICLE MAY CUT OUT	It has been identified that a possible poor contact with the fuel pump relay in the fuse and relay module unit may affect the operation of the fuel pump and cause the engine to cut out.	Recall all affected vehicles to check the manufacturing date of the fuse and relay module unit and it necessary replace it.	136	C109	SPRINTER	WDF9066332A963136	WDF9066332A964380
17/05/07	R/2010/172	MERCEDES BENZ	Sprinter	VEHICLE MAY CUT OUT	It has been identified that a possible poor contact with the fuel pump relay in the fuse and relay module unit may affect the operation of the fuel pump and cause the engine to cut out.	Recall all affected vehicles to check the manufacturing date of the fuse and relay module unit and it necessary replace it.	136	C109	SPRINTER	WDB9066112S150041	WDB9066572S149721
18/05/07	R/2007/059	FIAT	DUCATO	POSSIBILITY OF REDUCED BRAKING PERFORMANCE	Due to the inlet filter for the EGR valve being in an exposed position there is a possibility of water entering the brake servo vacuum pipe. This could result in the possibility of ice forming in the brake servo vacuum pipe in conditions of low ambient temperature. As a consequence this may lead to reduced servo assistance to the braking system.	Recalled vehicles will have the EGR solenoids checked for the presence of separate air filters. If theses are not evident new solenoids with separate air filters will be fitted.	4535	5141	DUCATO	ZFA24400007000022	ZFA24400007574570	01/07/2001	31/01/2005
18/05/07	R/2007/046	IVECO	NEW DAILY 29L10 29L12 29L14 35S10 35S12 35S14 & 35S18	PARKING BRAKE MAY FAIL TO FUNCTION CORRECTLY	It has been identified that the parking brake cables may be incorrectly located in the vicinity of the rear suspension leaf spring. In this condition the functionality of the parking brake may be compromised.	Recalled vehicles will have the parking brake cables repositioned.	734	RCT31	DAILY	ZCFC35D000D304190	ZCFC35A600D326112	30/03/2006	03/10/2006
21/05/07	RM/2007/016	PIAGGIO	VESPA GTS 250 VESPA GTV 250 AND VESPA GT60	RISK OF FIRE	In some cases the exhaust may release gases with the potential to damage components adjacent to the muffler area.	Recall the machines that are likely to be affected to replace the exhaust system header pipe with one of a different design.	1292		VESPA			01/01/2005	31/12/2006
21/05/07	R/2007/093	VOLVO CAR	C70	LEFT DOOR HANDLE MAY NOT PERFORM IN A COLLISION	The left hand door handle cable might have been incorrectly assembled. This may allow the door to become unlatched in certain side collision scenarios	Recall the vehicles that are likely to be affected to adjust the door handle cables.	1111		C70	14876	23851
22/05/07	R/2007/029	ISUZU TRUCK	NKR77 NPR77 NPR70 & NQR70	ABS MAY NOT FUNCTION CORRECTLY	There is a possibility that foreign material may contaminate the speed sensor rotor of the ABS. This could cause the ABS not to work correctly at speeds below 10 km/h when the foot brake is applied.	Recall the vehicles that are likely to be affected to fit an additional cover to the ABS speed sensor rotor.	1065		NQR			01/01/2002	31/12/2003
22/05/07	R/2007/029	ISUZU TRUCK	NKR77 NPR77 NPR70 & NQR70	ABS MAY NOT FUNCTION CORRECTLY	There is a possibility that foreign material may contaminate the speed sensor rotor of the ABS. This could cause the ABS not to work correctly at speeds below 10 km/h when the foot brake is applied.	Recall the vehicles that are likely to be affected to fit an additional cover to the ABS speed sensor rotor.	1065		NPR			01/01/2002	31/12/2003
22/05/07	R/2007/029	ISUZU TRUCK	NKR77 NPR77 NPR70 & NQR70	ABS MAY NOT FUNCTION CORRECTLY	There is a possibility that foreign material may contaminate the speed sensor rotor of the ABS. This could cause the ABS not to work correctly at speeds below 10 km/h when the foot brake is applied.	Recall the vehicles that are likely to be affected to fit an additional cover to the ABS speed sensor rotor.	1065		NKR			01/01/2002	31/12/2003
25/05/07	R/2007/035	MITSUBISHI	L200	FUEL MAY LEAK	A crack may occur in the fuel filter water sensor which can lead to a leakage of fuel.	Recalled vehicles will have the fuel filter water sensor replaced.	7917		L200
25/05/07	R/2006/193	MITSUBISHI	SPACE RUNNER AND SPACE WAGON (CZ/CZL)	BRAKE HOSE MAY FRACTURE	The front left brake pipe may foul the power steering hose which can damage the brake pipe which may fail leading to loss of brake fluid.	Recall affected vehicles check pipe for damage if OK apply new securing clip. If damaged replace pipe with modified version.	2795		SPACE RUNNER
29/05/07	R/2007/065	NISSAN	CABSTAR	WHEEL BEARING COULD FAIL	There is a possibility that a rear wheel bearing may have been overtightened at the factory. If ignored this condition could result in reduced bearing life and ultimately the bearings could fail.	Recall the vehicles that are likely to be affected to replace the rear wheel bearings.	184		CABSTAR	VWA**F24100008	VWA**F241010059
29/05/07	R/2007/068	FIAT	PANDA DIESEL	FUEL MAY LEAK	Fuel delivery pipe adjacent to air filter may chafe. This in time could lead to leakage of fuel in the engine compartment and a consequent risk of fire.	Recall the vehicles that are likely to be affected to replace the fuel delivery pipe and where necessary replace the pipe containment channel.	919		PANDA	ZFA16900000445385	ZFA16900000573368	01/07/2005	31/01/2006
01/06/07	R/2007/087	VOLVO TRUCK	FL	BRAKES MAY FAIL TO OPERATE CORRECTLY	Following the washing process water may have been left in the rear spring brake chamber. As a consequence it is possible that this water may freeze under cold conditions.	Recall affected vehicles remove brake chamber drain water and clean out.	39	c0822	FL
01/06/07	RM/2007/030	BMW MOTORCYCLES	F650	HANDLEBARS MAY NOT BE SECURE	Due to a manufacturing non-compliance the handlebar clamping blocks are not to specification. This can result in the handlebars not being held securely in positionn.	Subject machines will have the handlebar clamping blocks replaced with quality assure items.	222	312700	F650			01/01/2007	31/03/2007
01/06/07	RM/2007/029	BMW MOTORCYCLES	G650	CORRECT CHAIN TENSIONERS MAY NOT BE FITTED	It has been identified that in production the left hand chain tensioner may have been fitted to the right hand side of the machine.	Recalled machines will have the chain tensioners checked for correct installation and rectified if found to be incorrect or damaged.	51	270800	G650			01/03/2007	30/04/2007
05/06/07	RM/2007/031	BMW MOTORCYCLES	F800 S/ST	ENGINE PERFORMANCE MAY BE AFFECTED	It has been identified that the use of a faulty tool during engine assembly has led to isolated incidents of damage to the spark plugs. When the engine is in use the insulator of the central electrode may become displaced and contact he ground electrode. Should this occur it will have a detriment effect on engine performance.	Recalled machines will have the suspect spark plugs replaced.	313		F800S/ST			01/01/2006	05/06/2007
06/06/07	R/2007/042	CHRYSLER	300 CALIBER GRAND CHEROKEE AND WRANGLER	REAR BRAKES MAY LOCK	The ABS control unit may be programmed incorrectly. This may lead to the rear brakes locking up during certain braking conditions.	Recall the vehicles that are likely to be affect to re-programme the ABS control module.	1207	F50	300
06/06/07	R/2007/042	CHRYSLER	300 CALIBER GRAND CHEROKEE AND WRANGLER	REAR BRAKES MAY LOCK	The ABS control unit may be programmed incorrectly. This may lead to the rear brakes locking up during certain braking conditions.	Recall the vehicles that are likely to be affect to re-programme the ABS control module.	1207	F50	CALIBER
06/06/07	R/2007/042	CHRYSLER	300 CALIBER GRAND CHEROKEE AND WRANGLER	REAR BRAKES MAY LOCK	The ABS control unit may be programmed incorrectly. This may lead to the rear brakes locking up during certain braking conditions.	Recall the vehicles that are likely to be affect to re-programme the ABS control module.	1207	F50	GRAND CHEROKEE
06/06/07	R/2007/042	CHRYSLER	300 CALIBER GRAND CHEROKEE AND WRANGLER	REAR BRAKES MAY LOCK	The ABS control unit may be programmed incorrectly. This may lead to the rear brakes locking up during certain braking conditions.	Recall the vehicles that are likely to be affect to re-programme the ABS control module.	1207	F50	WRANGLER
07/06/07	R/2007/055	IVECO	EUROCARGO 60E - 190E (EURO 4)	CONTROL RELAY MAY OVERHEAT	It has been identified that if the incorrect type of cold start element is fitted frequent use under extreme weather conditions may lead to overheating of the control relay.	Recalled vehicles will have the part number of the cold start element checked which will be replaced as necessary.	693	RCG10	EUROCARGO	ZCFA75B0302482782	ZCFA80D1302505037	01/06/2006	31/12/2006
07/06/07	RM/2007/024	KTM	990 ADVENTUREJ & 950 SUPER ENDURO	POSSIBLE LOSS OF CONTROL	It is possible for the chain guide to become dislodged by the drive chain whilst the machine is in motion which could result in the rider loosing control.	Recalled machines will have the securing bolt removed the threads cleaned and have Loctite 243 applied to them. The bolt will then be re-fitted and tightened to a torque of 6 Nm.	245		990 ADVENTURE			01/11/2006	31/05/2007
07/06/07	RM/2007/024	KTM	990 ADVENTUREJ & 950 SUPER ENDURO	POSSIBLE LOSS OF CONTROL	It is possible for the chain guide to become dislodged by the drive chain whilst the machine is in motion which could result in the rider loosing control.	Recalled machines will have the securing bolt removed the threads cleaned and have Loctite 243 applied to them. The bolt will then be re-fitted and tightened to a torque of 6 Nm.	245		950 SUPER ENDURO			01/11/2006	31/05/2007
08/06/07	RM/2007/023	HARLEY DAVIDSON	SOFT-TAIL - FXST FXSTB FXSTC FXSTD FXSTSSE FLSTC FLSTF FLSTN FLSTC SHRINE AND FLSTF SHRINE	POSSIBILITY OF FIRE	It has been identified that the possibility exists that the battery positive lead may contact a weld bead on the oil tank. This may cause the weld bead to abrade the insulation on the cable and cause an electrical short circuit from the battery through the oil tank and oil lines. This could lead to an oil leak and or the possibility of a fire.	Recalled machines will have a battery caddy installed that will protect the cable and ensure correct routing.	1230	130	FX			08/06/2006	14/03/2007
11/06/07	R/2007/074	MITSUBISHI	SHOGUN SPORT	STEERING CONTROL MAY BE LOST	When used regularly in severe off road conditions the ball joint of the pitman arm may break resulting in loss of steering control.	Recalled vehicles will be fitted with a modified pitman arm if this has not already been accomplished following a previous intervention.	2894		SHOGUN			01/01/1997	31/12/2001
13/06/07	RSPV/2007/011	POLARIS	OUTLAW 525 INCLUDING A07GP52AA & A07GP52AB	RISK OF FUEL LEAK RELATED FIRE	It has been identified that subject machines were manufactured with petcock valve mounting inserts that may become loose due to an imperfect fit of the threads of the petcock valve and the fuel tank mounting area. If a brass mounting insert becomes loose or is pulled from the base of the fuel tank a fuel leak may develop. This can result in a fire hazard.	Recalled machines will have the fuel tank replaced with a unit which incorporates changes to the petcock valve.	23	ATV-07-02	OUTLAW			21/06/2006	07/02/2007
14/06/07	RM/2007/019	HYOSUNG	GT125 & GT 250	SWING ARM MAY FAIL	The rear swing arm might fail which will lead to the loss of directional control.	Recall the machines that are likely to be affected to replace the rear swinging arm.	367		GT 125			01/01/2003	31/12/2004
14/06/07	RM/2007/019	HYOSUNG	GT125 & GT 250	SWING ARM MAY FAIL	The rear swing arm might fail which will lead to the loss of directional control.	Recall the machines that are likely to be affected to replace the rear swinging arm.	367		GT250			01/01/2003	31/12/2004
18/06/07	RTW/2007/001	MICHELIN	120/70 ZR 17 (58W) PILOT POWER 2CT & 120/70 ZR 17 (58W) PILOT POWER	TREAD SEPARATION	It has been identified that due to a production anomaly a small number of cases of localised tread separation have occurred. This separation can result in a small area of accelerated tread wear which can result in small areas of tread being torn from the carcass.	Identified owners of the affected tyres will be made aware of the concern through direct communication by letter. Additionally websites tyre dealers wholesalers and popular publications will be populated with information relating to the replacement of likely to be affected tyres.	5500		120/70 ZR 17 (58W) PILOT POWER 2CT			01/11/2005	31/05/2007
18/06/07	RTW/2007/001	MICHELIN	120/70 ZR 17 (58W) PILOT POWER 2CT & 120/70 ZR 17 (58W) PILOT POWER	TREAD SEPARATION	It has been identified that due to a production anomaly a small number of cases of localised tread separation have occurred. This separation can result in a small area of accelerated tread wear which can result in small areas of tread being torn from the carcass.	Identified owners of the affected tyres will be made aware of the concern through direct communication by letter. Additionally websites tyre dealers wholesalers and popular publications will be populated with information relating to the replacement of likely to be affected tyres.	5500		120/70 ZR 17 (58W) PILOT POWER			01/07/2004	30/04/2006
18/06/07	RPT/2007/001	IFOR WILLIAMS	KFG35 COUPLING	THUMB CATCH MAY FAIL DURING COUPLING	Under certain conditions it is possible for the thumb catch to fail as the trailer is being coupled	Recall affected trailers and replace coupling head if coloured silver and bearing code 0707 or 0807 or 0907.	510		KRG35 COUPLING
22/06/07	R/2010/173	MERCEDES BENZ	Atego	WHEEL BEARING MAY FAIL	It is possible that water ingress into the front axle hub through a seal can cause corrosion which ultimately could result in failure of the wheel bearing. If not rectified this could ultimately result in detachment of the hub and wheel assembly.	Recall affected vehicles and replace the front hub assemblies.	3369	C118	ATEGO
22/06/07	R/2007/078	FIAT	ULYSSE	BRAKE SERVO ASSISTANCE MAY BE REDUCED	It has been identified that due to the inlet filter for the exhaust gas recirculating valve (EGR) being in an exposed position there is a possibility of water entering the brake servo vacuum pipe. This can give rise to the possibility of ice forming within the pipe during periods of low ambient temperature with the possibility of reduced brake servo assistance.	Recalled vehicles will have the EGR valve solenoids checked for the presence of separate air filters. If this is not the case new solenoids with separate filters will be fitted.	2986	5140	ULYSSE	ZFA17900013001046	ZFA17900013201942	01/08/2002	31/12/2004
25/06/07	RCT/2007/002	POWNALL	TRAILER PARK BRAKE CONTROL VALVE	TRAILER BRAKES MAY NOT APPLY	Parking brake may not apply when manually operated or when red line is disconnected	When likely to be affected vehicles are presented for routine maintenance the Pownall Trailer Park Brake Control valve is to be replaced with a modified version.	2668		TRAILER PARK BRAKE CONTROL VALVE			30/01/2006	20/12/2006
27/06/07	R/2007/083	FORD	Transit	FRONT SUSPENSION STRUT TO KNUCKLE CLAMPING BOLT INSUFFICIENT TORQUE	It has been identified that the front suspension strut to knuckle clamping bolt torque might be insufficient. The possibility therefore exists that should the assembly move within it's mounting the tyre may contact the wheel arch. Additionally in the case of FWD vehicles the shock absorber could contact the driveshaft.	Subject vehicles will have the suspension strut checked for correct positioning and the clamp bolt tightened to the revised torque.	57275		TRANSIT			21/10/2005	27/04/2007
01/07/07	R/2007/097	EMC EUROPE LTD	AEVIT	POSSIBLE LOSS OF VEHICULAR CONTROL	It has been identified that a situation could exist with the Avit disabled vehicle electronic accelerator/brake/steering system which might cause the equipment to malfunction. .	Recalled vehicles which will be fitted with a countermeasure to prevent any possible short circuit within the electronic control system.	4		AEVIT 1.0
03/07/07	R/2007/101	LDV	MAXUS	SEAT BELT STALK MAY FAIL	Non-conformity of weld attaching the seat belt buckle brackets to passenger seat frames. Affecting all passenger compartment seat locations.	Recall the Minibuses within the affected poplulation and fit a modified (bolted) belt buckle to the seat frame.	1104		MAXUS	200001	218187	01/04/2006	30/06/2007
05/07/07	RSPV/2007/008	POLARIS	HAWKEYE ATV INC A06LB27AA A06LB27FA A06LD27AC A06LD27AB & A06LD27FB	POSSIBLE LOSS OF VEHICLE CONTROL	It has been identified that the castings of some front bearing carriers have been produced with insufficient material thickness in an area where the lower a-arm and ball joint are attachedto the front bearing carrier. Should the attachment point for the lower a-arm and ball-joint fai vehicular control may be lost.	Recalled vehicles will have the front bearing carriers replaced with quality assured units.	84	ATV-07-01A	HAWKEYE
05/07/07	RSPV/2007/009	POLARIS	HAWKEYE ATV INC A06LB27AA A06LB27FA A06LD27AC A06LD27AB & A06LD27FB	POSSIBLE LOSS OF STEERING CONTROL	The handlebar mounting plate is contained within a moulded rubber vibration insulator on the steering post which may fail as a result of excessive loading and or cyclic fatigue. Should failure occur steering control might be lost.	Recalled vehicles will be fitted with a steering post support bracket which will eliminate the possibility of a fatigue failure.	2	ATV-07-01B	HAWKEYE
10/07/07	R/2007/135	SCANIA BUS	N BUS	BATTERY POSITIVE CABLE MAY BE DAMAGED	It has been identified that the battery positive cable could come into contact with the compressor outlet pipe and suffer damage as a consequence.	Recalled vehicles will have the subject cable secured with a cable tie.	23	RC071607	N			01/05/2006	31/10/2006
10/07/07	R/2007/107	SCANIA BUS	N bus	ELECTRIC CABLE MAY OVERHEAT	It has been identified that the B+ electrical cable has been routed so that it is in contact with the compressor pipe. This can result in the cable becoming hot with the likelihood of damage occurring to the insulation.	Recalled vehicles will have the cable routed and secured to prevent it contacting the compressor pipe.	23	RC 071607	N			01/05/2006	31/10/2006
16/07/07	R/2007/106	BMW	X5 - E70 Estate	DRIVER'S SEAT BELT MAY DE-LATCH	It has been identified that in the event of a situation which requires activation of the driver's seat belt tensioner. The possibility exists that due to an unfavourable pulse within the seatbelt buckle tensioner mechanism the buckle may open inadvertently.	Recalled vehicles will have the relevant electronic control units reprogrammed.	1606		X5			13/11/2006	03/04/2007
16/07/07	R/2007/124	MAN	TGL	STEERING MAY FAIL	It has been identified that some MAN TGL vehicles may have a problem with the steering shaft universal joint which may have been inserted too far over the teeth of the steering transmission shaft. This could result in the teeth failing to be adequately engaged with the consequence if ignored that the steering could fail.	Recalled vehicles will have the connection between the steering shafts checked. The components will be replaced if they show signs of damage.	34	249304	TGL
18/07/07	R/2007/079	SSANGYONG	REXTON	BRAKE FLUID MAY LEAK	It has been identified that a brake pipe may chafe against the cylinder head. Should this occur there is a possibility that brake fluid will be lost from one of the two braking circuits.	Recalled vehicles will have the subject brake pipes checked adjusted for position or replaced as necessary.	3000		REXTON
19/07/07	R/2007/100	MAZDA	MAZDA 3 MPS	ENGINE MOUNTING BOLT MAY FAIL	No 4 Engine mounting tightening bolt may loosen if a sudden acceleration is repeatedly carried out. If vehicle is continually used under such conditions No 4 mounting bolt may drop off and break allowing transmission to be out of position and in the worst case the driveshaft may detach resulting in loss of drive.	Recall affected vehicles to check mounting bolt torque and if necessary replace bolt with modified version.	430		3	JMZBK14L681595899	JMZBK14L681628171	13/07/2006	16/05/2007
19/07/07	R/2007/100	MAZDA	MAZDA 3 MPS	ENGINE MOUNTING BOLT MAY FAIL	No 4 Engine mounting tightening bolt may loosen if a sudden acceleration is repeatedly carried out. If vehicle is continually used under such conditions No 4 mounting bolt may drop off and break allowing transmission to be out of position and in the worst case the driveshaft may detach resulting in loss of drive.	Recall affected vehicles to check mounting bolt torque and if necessary replace bolt with modified version.	430		3	JMZBK14L671534993	JMZBK14L671595664	13/07/2006	16/05/2007
19/07/07	R/2007/100	MAZDA	MAZDA 3 MPS	ENGINE MOUNTING BOLT MAY FAIL	No 4 Engine mounting tightening bolt may loosen if a sudden acceleration is repeatedly carried out. If vehicle is continually used under such conditions No 4 mounting bolt may drop off and break allowing transmission to be out of position and in the worst case the driveshaft may detach resulting in loss of drive.	Recall affected vehicles to check mounting bolt torque and if necessary replace bolt with modified version.	430		3	JMZBK14L601540132	JMZBK14l601623471	13/07/2006	16/05/2007
20/07/07	R/2007/109	CITROEN	C4 Picasso	SEAT BELT MAY FAIL IN A COLLISION	It has been identified that on some vehicles fitted with electrically controlled seats in very rare cases and under certain impact conditions the front seatbelt may provide a diminished level of restraint.	As a preventative measure subject vehicles will have the front seatbelt buckles replaced.	101	YDH	C4	VF7******45002651	VF7******45075747	05/09/2006	31/03/2007
20/07/07	R/2007/109	CITROEN	C4 Picasso	SEAT BELT MAY FAIL IN A COLLISION	It has been identified that on some vehicles fitted with electrically controlled seats in very rare cases and under certain impact conditions the front seatbelt may provide a diminished level of restraint.	As a preventative measure subject vehicles will have the front seatbelt buckles replaced.	101	YDH	C4 PICASSO	VF7******45002651	VF7******45075747	05/09/2006	31/03/2007
20/07/07	R/2007/043	CHRYSLER	DODGE RAM 1500	WHEEL SEPERATION MAY OCCUR	Insufficient grease may have been applied to the front wheel bearings which could result in the very worst cases in detachment of the wheel and hub.	Recall the vehicles that are likely to be affected to replace the front wheel bearings.	45	G02	DODGE RAM
23/07/07	R/2007/137	SCANIA BUS	K AND N	TACHOGRAPH SPEED SENSOR NOT SEALED CORRECTLY	It has been identified that the speed sensor on the gearbox is not correctly sealed.	Recalled vehicles will have the sensor sealed correctly and the tachograph re-calibrated.	7	rc71702	K
23/07/07	R/2007/137	SCANIA BUS	K AND N	TACHOGRAPH SPEED SENSOR NOT SEALED CORRECTLY	It has been identified that the speed sensor on the gearbox is not correctly sealed.	Recalled vehicles will have the sensor sealed correctly and the tachograph re-calibrated.	7	rc71702	N
24/07/07	R/2007/132	SCANIA BUS	K340 AND K380	FUEL MAY LEAK	It has been identified that when the fuel tank is filled to it's maximum capacity fuel may leak from the filler neck aperture.	Recalled vehicles will be fitted with a fuel cap which incorporates an anti-splash valve.	24	70392	K380			07/12/2005	15/09/2006
24/07/07	R/2007/132	SCANIA BUS	K340 AND K380	FUEL MAY LEAK	It has been identified that when the fuel tank is filled to it's maximum capacity fuel may leak from the filler neck aperture.	Recalled vehicles will be fitted with a fuel cap which incorporates an anti-splash valve.	24	70392	K340			07/12/2005	15/09/2006
24/07/07	R/2007/138	SCANIA BUS	N SERIES	STEERING JOINT BOLT MAY FAIL	The nut and bolt that clamp the track rod end to the track rod may be defective resulting in the clamping force applied being insufficient.	Recall the vehicles that are likely to be affected to replace the nuts and bolts for the track rod end clamp.	327	70702	N
24/07/07	RM/2007/025	KAWASAKI	VN1600	FUEL MAY LEAK	Under certain conditions the fuel tank may crack at the front and rear mounting tabs. This can allow fuel to leak causing the risk of fire.	Recall the machines that are likely to be affected and replace the fuel tank dampers and where necessary replace the fuel tank.	35		VN1600	JKBVNT60AAA000042	JKBVNT60AAA005907
25/07/07	R/2007/115	CATERHAM CARS	SUPER 7	STEERING MAY FAIL	The steering column universal joint may fail which will lead to the loss of directional control.	Recall the vehicles that are likely to be affected to fit quality assured components.	16		SUPER 7			01/03/2007	30/04/2007
25/07/07	R/2007/111	RENAULT	TRAFIC II (PHASE II)	FRONT PASSENGER SEAT BELT PRETENSIONER MAY NOT TRIGGER IN AN IMPACT	It has been identified that the front passenger seatbelt pretensioner has not been configured correctly. In the event of an impact the pretensioner will not trigger. The front seat passenger will however still be retained by the seatbelt but without the pretensioner function.	Recalled vehicles will have the front passenger seatbelt configured.	6	OAWA	TRAFIC
25/07/07	R/2007/114	RENAULT TRUCKS UK LTD	MASCOTT	ABS SENSOR MOUNT & DRIVERS SEAT RUNNER MAY BECOME LOOSE	The rear ABS sensor mountings may come loose which may lead to the rear ABS not working.	Recall the vehicles that are likely to be affected to tighten the ABS sensor mounting fixing screws.	3	1B8	MASCOT			23/05/2006	22/06/2007
27/07/07	R/2007/092	ALFA ROMEO	159 BRERA & SPIDER	POSSIBLE LOSS OF VEHICLE CONTROL	Oil may leak from the Power Take Off Unit which may cause the unit to seize and possible loss of vehicle control.	Recall the vehicles that are likely to be affected to apply sealant to the core plug and to fit a retaining clip.	610		BRERA	ZAR93900005000002	ZAR93900005014818	01/11/2005	28/02/2007
27/07/07	R/2007/092	ALFA ROMEO	159 BRERA & SPIDER	POSSIBLE LOSS OF VEHICLE CONTROL	Oil may leak from the Power Take Off Unit which may cause the unit to seize and possible loss of vehicle control.	Recall the vehicles that are likely to be affected to apply sealant to the core plug and to fit a retaining clip.	610		SPIDER	ZAR93900005000002	ZAR93900005014818	01/11/2005	28/02/2007
27/07/07	R/2007/092	ALFA ROMEO	159 BRERA & SPIDER	POSSIBLE LOSS OF VEHICLE CONTROL	Oil may leak from the Power Take Off Unit which may cause the unit to seize and possible loss of vehicle control.	Recall the vehicles that are likely to be affected to apply sealant to the core plug and to fit a retaining clip.	610		159	ZAR93900007000312	ZAR93900007094838	01/03/2005	28/02/2007
30/07/07	R/2007/095	SKODA	ROOMSTER AND FABIA 2	INCORRECT CURTAIN AIRBAG MAY ACTIVATE	It has been identified that some of the wires within airbag control unit block connector have been incorrectly installed. In the event of a collision this will result in the activation of the curtain airbag on the opposite side to the impact.	Recalled vehicles will have the wiring to the control unit checked and rectified should this be necessary.	5142	97M1	ROOMSTER	TMB###5J#73000127	TMB###5J#73023883	07/03/2007	24/05/2007
30/07/07	R/2007/095	SKODA	ROOMSTER AND FABIA 2	INCORRECT CURTAIN AIRBAG MAY ACTIVATE	It has been identified that some of the wires within airbag control unit block connector have been incorrectly installed. In the event of a collision this will result in the activation of the curtain airbag on the opposite side to the impact.	Recalled vehicles will have the wiring to the control unit checked and rectified should this be necessary.	5142	97M1	FABIA	TMB###5J#75000194	TMB###5J#75060968	28/06/2006	24/05/2007
30/07/07	R/2007/095	SKODA	ROOMSTER AND FABIA 2	INCORRECT CURTAIN AIRBAG MAY ACTIVATE	It has been identified that some of the wires within airbag control unit block connector have been incorrectly installed. In the event of a collision this will result in the activation of the curtain airbag on the opposite side to the impact.	Recalled vehicles will have the wiring to the control unit checked and rectified should this be necessary.	5142	97M1	FABIA	TMB###5J#73000127	TMB###5J#73023883	07/03/2007	24/05/2007
30/07/07	R/2007/095	SKODA	ROOMSTER AND FABIA 2	INCORRECT CURTAIN AIRBAG MAY ACTIVATE	It has been identified that some of the wires within airbag control unit block connector have been incorrectly installed. In the event of a collision this will result in the activation of the curtain airbag on the opposite side to the impact.	Recalled vehicles will have the wiring to the control unit checked and rectified should this be necessary.	5142	97M1	ROOMSTER	TMB###5J#75000194	TMB###5J#75060968	28/06/2006	24/05/2007
02/08/07	R/2007/090	IVECO	STRALIS	LOSS OF STEERING	Steering control could be lost on vehicles that have been fitted with non-quality assured steering column shafts.	Recall the vehicles that are likely to be affected to check and if necessary replace the steering column shaft.	641	RCV29	STRALIS	WJMA1VUJ004278496	WJMA1VM0004290942	06/04/2004	10/12/2004
02/08/07	R/2007/090	IVECO	STRALIS	LOSS OF STEERING	Steering control could be lost on vehicles that have been fitted with non-quality assured steering column shafts.	Recall the vehicles that are likely to be affected to check and if necessary replace the steering column shaft.	641	RCV29	STRALIS	WJMM1VRP00C126284	WJMJ4CSS00C143500	06/10/2003	15/11/2004
02/08/07	R/2007/091	IVECO	EUROCARGO	LOSS OF STEERING	Steering control could be lost on vehicles that have been fitted with none quality assured steering column shafts.	Recall the vehicles that are likely to be affected to check and if necessary replace the steering column shaft.	2876	RC G07	EUROCARGO	ZCFA1GJ0102424971	ZCFA75C0202450062	19/03/2004	04/11/2004
06/08/07	R/2010/174	MERCEDES BENZ	Vito and Viano	ENGINE MAY FAIL	The engine may stop as a result of the fuel feed lines from tank to engine leaking and or separating because they were not manufactured to the correct specification.	Recall the vehicles that are likely to be affected to replace the fuel feed lines.	1	C123	VITO
06/08/07	R/2010/174	MERCEDES BENZ	Vito and Viano	ENGINE MAY FAIL	The engine may stop as a result of the fuel feed lines from tank to engine leaking and or separating because they were not manufactured to the correct specification.	Recall the vehicles that are likely to be affected to replace the fuel feed lines.	1	C123	VIANO
06/08/07	R/2007/094	SEDDON ATKINSON	VARIOUS	LOSS OF STEERING	An incorrect length steering column shaft may have been fitted during manufacture.	Check the length of the column shaft and replace where necessary.	119	RC V29	R518275NSD
06/08/07	R/2007/094	SEDDON ATKINSON	VARIOUS	LOSS OF STEERING	An incorrect length steering column shaft may have been fitted during manufacture.	Check the length of the column shaft and replace where necessary.	119	RC V29	S526275NDD
06/08/07	R/2007/094	SEDDON ATKINSON	VARIOUS	LOSS OF STEERING	An incorrect length steering column shaft may have been fitted during manufacture.	Check the length of the column shaft and replace where necessary.	119	RC V29	R518240NSD
06/08/07	R/2007/094	SEDDON ATKINSON	VARIOUS	LOSS OF STEERING	An incorrect length steering column shaft may have been fitted during manufacture.	Check the length of the column shaft and replace where necessary.	119	RC V29	R626345MDD
06/08/07	R/2007/094	SEDDON ATKINSON	VARIOUS	LOSS OF STEERING	An incorrect length steering column shaft may have been fitted during manufacture.	Check the length of the column shaft and replace where necessary.	119	RC V29	R626350FDD
06/08/07	R/2007/094	SEDDON ATKINSON	VARIOUS	LOSS OF STEERING	An incorrect length steering column shaft may have been fitted during manufacture.	Check the length of the column shaft and replace where necessary.	119	RC V29	EUROMOVER (MUNICIPAL)
06/08/07	R/2007/094	SEDDON ATKINSON	VARIOUS	LOSS OF STEERING	An incorrect length steering column shaft may have been fitted during manufacture.	Check the length of the column shaft and replace where necessary.	119	RC V29	MP440E44HT
06/08/07	R/2007/094	SEDDON ATKINSON	VARIOUS	LOSS OF STEERING	An incorrect length steering column shaft may have been fitted during manufacture.	Check the length of the column shaft and replace where necessary.	119	RC V29	R632350FDD
06/08/07	R/2007/094	SEDDON ATKINSON	VARIOUS	LOSS OF STEERING	An incorrect length steering column shaft may have been fitted during manufacture.	Check the length of the column shaft and replace where necessary.	119	RC V29	S518275NSD
06/08/07	R/2007/094	SEDDON ATKINSON	VARIOUS	LOSS OF STEERING	An incorrect length steering column shaft may have been fitted during manufacture.	Check the length of the column shaft and replace where necessary.	119	RC V29	S518240NSD
06/08/07	R/2007/094	SEDDON ATKINSON	VARIOUS	LOSS OF STEERING	An incorrect length steering column shaft may have been fitted during manufacture.	Check the length of the column shaft and replace where necessary.	119	RC V29	R626310FDD
06/08/07	R/2007/094	SEDDON ATKINSON	VARIOUS	LOSS OF STEERING	An incorrect length steering column shaft may have been fitted during manufacture.	Check the length of the column shaft and replace where necessary.	119	RC V29	PACER
06/08/07	R/2007/094	SEDDON ATKINSON	VARIOUS	LOSS OF STEERING	An incorrect length steering column shaft may have been fitted during manufacture.	Check the length of the column shaft and replace where necessary.	119	RC V29	R526275NDD
06/08/07	R/2007/105	FORD	Fiesta and Fusion	POTENTIAL LOSS OF STEERING CONTROL	It has been identified that a small number of Fiesta and Fusion vehicles may have been built with a steering column which may have suffered damage by inappropriate handling prior to vehicle production. In rare cases there may be damage to the column upper universal joint which could result in loss of steering control.	Recalled vehicles will have the steering column universal joint inspected for signs of damage. If damage is found the steering column assembly will be replaced.	496	7C124	FUSION			18/08/2006	08/09/2006
06/08/07	R/2007/105	FORD	Fiesta and Fusion	POTENTIAL LOSS OF STEERING CONTROL	It has been identified that a small number of Fiesta and Fusion vehicles may have been built with a steering column which may have suffered damage by inappropriate handling prior to vehicle production. In rare cases there may be damage to the column upper universal joint which could result in loss of steering control.	Recalled vehicles will have the steering column universal joint inspected for signs of damage. If damage is found the steering column assembly will be replaced.	496	7C124	FIESTA			18/08/2006	08/09/2006
09/08/07	R/2007/136	SCANIA BUS	K AND N SERIES	ALTERNATOR BRACKET BOLTS MAY LOOSEN	It has been identified that the bracket which carries the alternator has been constructed incorrectly. Due to this the securing bolts may become loose.	Recalled vehicles will be fitted with a modified alternator bracket.	101	rc071603	N
09/08/07	R/2007/136	SCANIA BUS	K AND N SERIES	ALTERNATOR BRACKET BOLTS MAY LOOSEN	It has been identified that the bracket which carries the alternator has been constructed incorrectly. Due to this the securing bolts may become loose.	Recalled vehicles will be fitted with a modified alternator bracket.	101	rc071603	K
09/08/07	R/2007/139	SCANIA TRUCK	R AND P SERIES	STEERING JOINT BOLT MAY FAIL	The nut and bolt that clamp the track rod end to the track rod may be defective resulting in the clamping force applied being insufficient.	Recall the vehicles that are likely to be affected to replace the nuts and bolts for the track rod end clamp.	3358	rc070701	R SERIES
09/08/07	R/2007/139	SCANIA TRUCK	R AND P SERIES	STEERING JOINT BOLT MAY FAIL	The nut and bolt that clamp the track rod end to the track rod may be defective resulting in the clamping force applied being insufficient.	Recall the vehicles that are likely to be affected to replace the nuts and bolts for the track rod end clamp.	3358	rc070701	P SERIES
09/08/07	R/2007/110	CHRYSLER	Wrangler	ENGINE MAY STALL	Under certain operating conditions it has been identified that the engine might stall due to incorrect programming of the totally integrated power module (TIPM).	Recalled vehicles will have the TPIM re-programmed.	57	g25	WRANGLER			01/01/2007	19/07/2007
10/08/07	R/2007/082	ALFA ROMEO	147 & GT 1.9 Multijet 16V	POSSIBILITY OF FIRE	There is a possibility that the fuel hose from the diesel filter to the high pressure pump may chafe on the fuel filter housing. In time this could result in a fuel leak and the possibility of an engine compartment fire.	Recalled vehicles will have the routing of the hose checked at which time if the hose is not damaged a new bracket will be fitted to prevent chafing. If the hose is damaged it will be replaced in addition a new bracket will be fitted.	890	5121	GT	ZAR93700005196866	ZAR93700005243870	01/12/2005	30/06/2006
10/08/07	R/2007/082	ALFA ROMEO	147 & GT 1.9 Multijet 16V	POSSIBILITY OF FIRE	There is a possibility that the fuel hose from the diesel filter to the high pressure pump may chafe on the fuel filter housing. In time this could result in a fuel leak and the possibility of an engine compartment fire.	Recalled vehicles will have the routing of the hose checked at which time if the hose is not damaged a new bracket will be fitted to prevent chafing. If the hose is damaged it will be replaced in addition a new bracket will be fitted.	890	5121	147	ZAR93700005208396	ZAR93700005230016	01/10/2005	31/08/2006
10/08/07	R/2007/082	ALFA ROMEO	147 & GT 1.9 Multijet 16V	POSSIBILITY OF FIRE	There is a possibility that the fuel hose from the diesel filter to the high pressure pump may chafe on the fuel filter housing. In time this could result in a fuel leak and the possibility of an engine compartment fire.	Recalled vehicles will have the routing of the hose checked at which time if the hose is not damaged a new bracket will be fitted to prevent chafing. If the hose is damaged it will be replaced in addition a new bracket will be fitted.	890	5121	GT	ZAR93700003274558	ZAR93700003344882	01/12/2005	30/06/2006
10/08/07	R/2007/082	ALFA ROMEO	147 & GT 1.9 Multijet 16V	POSSIBILITY OF FIRE	There is a possibility that the fuel hose from the diesel filter to the high pressure pump may chafe on the fuel filter housing. In time this could result in a fuel leak and the possibility of an engine compartment fire.	Recalled vehicles will have the routing of the hose checked at which time if the hose is not damaged a new bracket will be fitted to prevent chafing. If the hose is damaged it will be replaced in addition a new bracket will be fitted.	890	5121	147	ZAR93700003312927	ZAR93700003345203	01/10/2005	31/08/2006
10/08/07	RM/2007/034	YAMAHA	MT01	SUSPENSION MAY FAIL	Rear suspension relay arm bearing housing may weaken by ingress of water and particularly when exposed to road salt in the Winter months. If not rectified this concern could lead to the failure of the rear suspension.	Recall the machines that are likely to be affected to replace the suspension link arm and associated components.	816		MT	RP121000000000301	RP1210000011175
10/08/07	RSPV/2007/015	THE FIFTH WHEEL COMPANY LTD	Celtic Rambler	WELD ON PIN BOX MOUNTING PLATE MAY FAIL	Insufficient weld applied to king pin box mounting which in exceptional circumstances could lead to the separation of trailer from the drawing vehicle.	Recall the vehicles that are likely to be affected to apply the correct weld detail and additional support brace.	30		CELTIC RAMBLER
13/08/07	R/2007/113	FIAT	NEW SCUDO	STEERING SWIVEL JOINT MAY FAIL RESULTING IN LOSS OF VEHICLE CONTROL	The possibility exists that the swivel joint stem of the front suspension vertical links maybe of an incorrect size. This can lead to the generation of noise whilst driving and the possibility of suspension disconnection following a violent impact to the front axle and subsequent loss of vehicle control.	Recalled vehicles will have the swivel joint stems checked for the presence of play and will be replaced if any is found.	198	5177	SCUDO	ZFA27000064008057	ZFA27000064026461	01/01/2007	31/01/2007
14/08/07	R/2007/104	IVECO	Stralis & Eurotrakker	EXHAUST SILENCER RETAINING BOLTS MAY FAIL	It is possible for the for the exhaust silencer strap bolts to slacken which if not rectified could lead to the total failure of the silencer mounting.	Recall the vehicles that are likely to be affected to replace the mounting bolts with new pre-coated bolts (locking compound) and tighten to the correct torque.	152		EUROTREKKER	WJMM1VSH404306677	WJMM1VTH404325414	01/11/2005	31/12/2006
14/08/07	R/2007/104	IVECO	Stralis & Eurotrakker	EXHAUST SILENCER RETAINING BOLTS MAY FAIL	It is possible for the for the exhaust silencer strap bolts to slacken which if not rectified could lead to the total failure of the silencer mounting.	Recall the vehicles that are likely to be affected to replace the mounting bolts with new pre-coated bolts (locking compound) and tighten to the correct torque.	152		STRALIS	WJMM1VSH404306677	`WJMM1VTH404325414	01/11/2005	31/12/2006
14/08/07	R/2007/104	IVECO	Stralis & Eurotrakker	EXHAUST SILENCER RETAINING BOLTS MAY FAIL	It is possible for the for the exhaust silencer strap bolts to slacken which if not rectified could lead to the total failure of the silencer mounting.	Recall the vehicles that are likely to be affected to replace the mounting bolts with new pre-coated bolts (locking compound) and tighten to the correct torque.	152		STRALIS	WJMA1VM100C157524	WJMA1VNH40C180361	01/11/2005	31/01/2007
14/08/07	R/2007/104	IVECO	Stralis & Eurotrakker	EXHAUST SILENCER RETAINING BOLTS MAY FAIL	It is possible for the for the exhaust silencer strap bolts to slacken which if not rectified could lead to the total failure of the silencer mounting.	Recall the vehicles that are likely to be affected to replace the mounting bolts with new pre-coated bolts (locking compound) and tighten to the correct torque.	152		EUROTREKKER	WJMA1VM100C157524	WJMA1VNH40C180361	01/11/2005	31/01/2007
14/08/07	R/2007/089	CHRYSLER	PT CRUISER	REAR QUARTER WINDOW MAY DETACH FROM VEHICLE	The fixed rear quarter glass may separate from the vehicle whilst in motion	Recall affected vehicles and replace Quarter Glass assembly	212	G01	PT CRUSIER			01/01/2005	31/12/2006
14/08/07	R/2007/122	BMW	X5	BRAKE FLUID MAY LEAK	If a brake fluid leak occurs the brake fluid low level warning may be given too late.	Recall the vehicles that are likely to be affected to check the serial number of the brake servo and where necessary replace the cap for the expansion tank which includes the warning switch.	1887		X5			05/02/2007	30/04/2007
14/08/07	R/2007/088	CHRYSLER	Jeep Liberty	RISK OF FIRE	The blower motor may under certain operating conditions overheat and cause an interior fire	Recall affected vehicles and fit modified blower motor.	2207	G03	JEEP			01/01/2006	01/06/2007
15/08/07	RSPV/2007/012	LUNAR	VARIOUS	WHEEL DISHES MAY CRACK POTENTIAL LOSS OF TYRE PRESSURE	It has been recorded that a small number of instances have occurred where cracks have appeared in the wheel rim with the potential to cause deflation of the tyre.	Wheels which have the potential to suffer this concern will be replaced.	625		VARIOUS MODELS			01/06/2005	30/04/2007
15/08/07	RM/2007/027	HARLEY DAVIDSON	XL1200L & XL1200N	POTENTIAL FOR INJURY FROM CONTACT WITH EXHAUST	It has been identified that on the subject machines a condition may exist which will cause the trousers of some riders to have direct contact with the exhaust pipe. Should this occur the clothing could char or burn which might result in injury to the rider.	Recalled machines will be fitted with a new exhaust shield.	382		XL			31/10/2005	16/05/2007
15/08/07	RM/2007/033	DUCATI	HYPERMOTARD 1100	BATTERY MAY BE INSECURE	The battery is not fully secure and will move in the carrier. This could result in the main wiring harness cables being damaged at the battery terminals and eventually the engine cutting out.	Recall the vehicles that are likely to be affected to fit a battery mounting bracket.	138		HYPERMOTARD 1100
17/08/07	R/2007/103	MITSUBISHI	SHOGUN (BK)	DRIVE MAY BE LOST	It has been identified that the possibility exists that a bolt welded to the gearshift lever may fracture. Should this occur the adjustment may loosen and the shift cable may move. This can result in a mismatch between the gear shift selector and the actual gear selected. In the worst case the bolt may break which can cause the control cable to become disconnected and drive to be lost.	Affected vehicles will have the transmission shift lever replaced with a quality assured item.	726		SHOGUN
18/08/07	RM/2007/026	HARLEY DAVIDSON	VRSCR	POTENTIAL FOR INJURY FROM CONTACT WITH EXHAUST	It has been identified that on the subject machines a condition may exist which will cause the trousers of some riders to have direct contact with the exhaust pipe. Should this occur the clothing could char or burn which might result in injury to the rider.	Recalled machines will be fitted with a new exhaust shield.	385	132	VCSCR
20/08/07	R/2007/119	IVECO	IVECO BUS & NEW DAILY 2006	INDICATORS MAY FAIL	There is a possibility that the side repeater lamps may not work.	Recall the vehicles that are likely to be affected and reprogramme the computer to allow the side repeater lamps to activate.	22	RCT28	BUS	ZCFC502005624794	ZCFC65D0005645740	01/09/2006	31/12/2006
20/08/07	R/2007/119	IVECO	IVECO BUS & NEW DAILY 2006	INDICATORS MAY FAIL	There is a possibility that the side repeater lamps may not work.	Recall the vehicles that are likely to be affected and reprogramme the computer to allow the side repeater lamps to activate.	22	RCT28	DAILY	ZCFC50A2005624794	ZCFC65D0005645740	01/09/2006	31/12/2006
21/08/07	R/2007/099	VW	CRAFTER	FUEL PUMP MAY FAIL - ENGINE MAY CUT OUT	The power supply to the fuel pump may fail due to widened plug contacts in the central electrics unit	Recall affected vehicles check production date of central electrics unit and replace if necessary.	38		CRAFTER	WV1ZZZ2EZ76022619	WV1ZZZ2EZ76024301	09/01/2007	09/01/2007
28/08/07	RM/2007/036	KEEWAY	Flash 50 and Hurricane 50	CARBURETTOR HEATER MAY MALFUNCTION	The manufacturer has established that there is a slight possibility that if the battery terminals become loose or is unfortunately disconnected the temperature control unit which controls the operation of the carburettor heater could short out internally and fail to operate the heater.	Recall all the affected machines and replace the control unit with a re-designed unit.	626		FLASH 50
28/08/07	RM/2007/036	KEEWAY	Flash 50 and Hurricane 50	CARBURETTOR HEATER MAY MALFUNCTION	The manufacturer has established that there is a slight possibility that if the battery terminals become loose or is unfortunately disconnected the temperature control unit which controls the operation of the carburettor heater could short out internally and fail to operate the heater.	Recall all the affected machines and replace the control unit with a re-designed unit.	626		HURRICANE 50
28/08/07	R/2007/125	SUZUKI	LIANA 1.6. PETROL	GEAR SELECTION MAY BE LOST	It has been identified that due to an improper design of the gear change cable retaining clip contact on the gear lever housing by the clip is possible if excessive force is applied when selecting first gear. In this situation the clip may detach at which point gear selection will be lost.	Recalled vehicles will have the gear change cable clip replaced with a quality assured part.	9514		LIANA	JSAERC31S00100059	JSAERC31S00353390	01/01/2001	01/01/2006
28/08/07	R/2007/125	SUZUKI	LIANA 1.6. PETROL	GEAR SELECTION MAY BE LOST	It has been identified that due to an improper design of the gear change cable retaining clip contact on the gear lever housing by the clip is possible if excessive force is applied when selecting first gear. In this situation the clip may detach at which point gear selection will be lost.	Recalled vehicles will have the gear change cable clip replaced with a quality assured part.	9514		LIANA	JSAERA31S00100377	JSAERA31S00300245	01/01/2001	01/01/2006
29/08/07	RSPV/2007/013	SWIFT	Various	SWIVEL SEATS MAY DE-LATCH	Certain versions of the seat swivel manufactured by FASP (Italy) may delatch which could lead to some loss of control and the seat belt to be ineffective in the event of an accident.	Recall the vehicles that are likely to be affected to identify and replace the potentially defective seats.	4577		VARIOUS			01/01/1998	31/12/2006
30/08/07	R/2007/131	PEUGEOT	207 CC	WINDOW CONTROLS COULD REMAIN ACTIVE AFTER SWITCHING OFF THE IGNITION.	The window controls could remain active for 45 seconds after switching off the ignition even after opening one of the doors. This could allow unintentional use of windows which could result in an injury. Additionally it contravenes anti-theft regulations.	Recall all affected vehicles and install upgrades software.	2022		207cc
30/08/07	R/2007/129	MASERATI	QUATTROPORTE	ELECTRONIC STABILITY PROGRAMME MAY BE DISABLED	Due to an anomaly in the ABS/ASR software the Electronic Stability Programme may be disabled. The condition only occurs with the ignition in "Key on" position and the vehicle battery in a low state of charge	Recall affected vehicles and replace ABS/ASR ECU.	96	163	QUATTROPORTE	ZAMFD39C000028015	ZAMFD39C000031112	01/01/2007	23/08/2007
03/09/07	R/2007/134	WRIGHTBUS	VOLVO B7R B7RLE B9TL - EURO 4 CHASSIS WITH WRIGHTBUS BODIES	STEERING COLUMN UNIVERSAL JOINTS MAY BE INSECURE	It has been identified that the steering column universal joints may not have been correctly assembled to the steering column.	Subject vehicles will be checked to ensure the joints have been assembled and correctly installed should this be found to be necessary.	346		B9TL
03/09/07	R/2007/134	WRIGHTBUS	VOLVO B7R B7RLE B9TL - EURO 4 CHASSIS WITH WRIGHTBUS BODIES	STEERING COLUMN UNIVERSAL JOINTS MAY BE INSECURE	It has been identified that the steering column universal joints may not have been correctly assembled to the steering column.	Subject vehicles will be checked to ensure the joints have been assembled and correctly installed should this be found to be necessary.	346		B7R
03/09/07	R/2007/134	WRIGHTBUS	VOLVO B7R B7RLE B9TL - EURO 4 CHASSIS WITH WRIGHTBUS BODIES	STEERING COLUMN UNIVERSAL JOINTS MAY BE INSECURE	It has been identified that the steering column universal joints may not have been correctly assembled to the steering column.	Subject vehicles will be checked to ensure the joints have been assembled and correctly installed should this be found to be necessary.	346		B7RLE
05/09/07	RSPV/2007/016	GOINGREEN UK	G-WIZ (electric vehicle)	THERMISTER POTENTIAL FIRE HAZARD WHEN CHARGING	There has been an incident where a vehicle caught fire whilst parked and charging due to a problem with the charging unit.	Recall the vehicles that are likely to be affected to replace the thermistor fit an additional thermal cut out inside the charger and to replace the existing charger cover for one with fire retardant properties.	621		G WIZ	R0000000000200312	R0000000007011830	29/10/2002	26/02/2007
06/09/07	RM/2007/038	BMW MOTORCYCLES	K1200R SPORT	REDUCTION OF FRONT BRAKE EFFICIENCY	Vibration on a long ride at a constantly high engine speed can under certain circumstances causing foaming of the brake fluid in the reservoir of the front brakes. The possibility therefore of this foaming causing air to enter into the braking system cannot be excluded. Should air enter the system the efficiency of the front brakes can diminish severely dependant upon the volume of air which has entered the system.	Recalled machines will have the front brake system bled and a damper weight installed in the front brake fluid reservoir.	152	346300	K SERIES
10/09/07	R/2007/102	SUZUKI	Grand Vitara 1.9 diesel	WIRING HARNESS MAY CHAFE RESULTING IN POSSIBLE LOSS OF ENGINE POWER	It has been identified that due to improper insulation of a branch of the engine wiring harness. The possibility exists that the harness can chafe on the cam cover securing bolt and sustain damage. Should this occur a possible sudden loss of engine power might ensue.	Subject vehicles will have the engine wiring harness inspected and repaired as necessary before being fitted with a protective cover.	3579	r07/011	GRAND VITARA	JSAJTD44V00103047	JSAJTD44V00211187	17/06/2005	29/12/2006
10/09/07	R/2007/084	SUZUKI	Grand Vitara 1.9 Diesel	RISK OF FIRE	It has been identified that due to an improper design of the intercooler inlet hose there is a possibility that the air/fuel mixture ratio may be incorrect within the diesel particulate filter assembly. This in the worst case may cause the diesel particulate filter to ignite.	Recalled vehicles will be fitted with a modified intercooler hose.	3421	R07/09	GRAND VITARA	JSAJTD44V00102735	JSAJTD44V00218932	28/06/2005	02/04/2007
10/09/07	R/2007/118	VAUXHALL	COMBO C MERIVA< TIGRA B	STEERING CONTROL MAY BE LOST	The retaining ring of the steering gear pinion might be out of it's retaining groove. In the worst case the steering gear pinion may lose engagement resulting in loss of steering control	Recall affected vehicles and replace steering gear assembly	557		TIGRA
10/09/07	R/2007/118	VAUXHALL	COMBO C MERIVA< TIGRA B	STEERING CONTROL MAY BE LOST	The retaining ring of the steering gear pinion might be out of it's retaining groove. In the worst case the steering gear pinion may lose engagement resulting in loss of steering control	Recall affected vehicles and replace steering gear assembly	557		MERIVA			01/08/2007	01/08/2007
10/09/07	R/2007/118	VAUXHALL	COMBO C MERIVA< TIGRA B	STEERING CONTROL MAY BE LOST	The retaining ring of the steering gear pinion might be out of it's retaining groove. In the worst case the steering gear pinion may lose engagement resulting in loss of steering control	Recall affected vehicles and replace steering gear assembly	557		COMBO
10/09/07	R/2007/086	SUZUKI	Swift 1.3 & 1.5 petrol and 1.3 diesel	HANDBRAKE MAY FAIL	It is possible that the parking brake cable end could detach from the trailing brake shoe lever rendering the parking brake ineffective.	Recall the vehicles that are likely to be affected to refit or replace the cables.	18352		SWIFT	TSMMZA21S00177124	TSMMZA21S00334713
10/09/07	R/2007/086	SUZUKI	Swift 1.3 & 1.5 petrol and 1.3 diesel	HANDBRAKE MAY FAIL	It is possible that the parking brake cable end could detach from the trailing brake shoe lever rendering the parking brake ineffective.	Recall the vehicles that are likely to be affected to refit or replace the cables.	18352		SWIFT	TSMMZC21S00100148	TSMMZC21S00334774
10/09/07	R/2007/086	SUZUKI	Swift 1.3 & 1.5 petrol and 1.3 diesel	HANDBRAKE MAY FAIL	It is possible that the parking brake cable end could detach from the trailing brake shoe lever rendering the parking brake ineffective.	Recall the vehicles that are likely to be affected to refit or replace the cables.	18352		SWIFT	TSMMZC91S00119890	TSMMZC91S00334668
10/09/07	R/2007/086	SUZUKI	Swift 1.3 & 1.5 petrol and 1.3 diesel	HANDBRAKE MAY FAIL	It is possible that the parking brake cable end could detach from the trailing brake shoe lever rendering the parking brake ineffective.	Recall the vehicles that are likely to be affected to refit or replace the cables.	18352		SWIFT	TSMMZA11S00103322	TSMMZA11S00334720
10/09/07	R/2007/086	SUZUKI	Swift 1.3 & 1.5 petrol and 1.3 diesel	HANDBRAKE MAY FAIL	It is possible that the parking brake cable end could detach from the trailing brake shoe lever rendering the parking brake ineffective.	Recall the vehicles that are likely to be affected to refit or replace the cables.	18352		SWIFT	TSMMZA91S00118873	TSMMZA91S00118873
10/09/07	R/2007/085	SUZUKI	Grand Vitara 1.9 Diesel	RISK OF FIRE	It has been identified that the intercooler has been improperly designed. This may allow the intercooler to come apart in use causing an improper mixture ratio of air/fuel in the diesel particulate filter. In the worst case the particulate filter may ignite.	Recalled vehicles will be fitted with an engine intercooler attachment assembly.	3775	R07/08	GRAND VITARA	JSAJTD44V00102735	JSAJTD44V00218932	28/06/2005	02/04/2007
10/09/07	R/2007/085	SUZUKI	Grand Vitara 1.9 Diesel	RISK OF FIRE	It has been identified that the intercooler has been improperly designed. This may allow the intercooler to come apart in use causing an improper mixture ratio of air/fuel in the diesel particulate filter. In the worst case the particulate filter may ignite.	Recalled vehicles will be fitted with an engine intercooler attachment assembly.	3775	R07/08	GRAND VITARA	JSAJTA44V00100031	JSAJTD44V00208913	28/06/2005	02/04/2007
12/09/07	R/2007/108	IVECO	DAILY 2000	REAR AXLE LEAF SPRING MOUNTING MAY CRACK	It has been identified that on a limited number of vehicles the rear axle leaf spring mountings may crack or fracture. Should this occur vehicle stability could be affected.	Recalled vehicles will be inspected and repaired as required.	287		DAILY	ZCFC3582005463613	ZCFC50C0005609999	01/11/2003	31/05/2006
12/09/07	R/2007/108	IVECO	DAILY 2000	REAR AXLE LEAF SPRING MOUNTING MAY CRACK	It has been identified that on a limited number of vehicles the rear axle leaf spring mountings may crack or fracture. Should this occur vehicle stability could be affected.	Recalled vehicles will be inspected and repaired as required.	287		DAILY	ZCFC509000D141465	ZCFC50C000D283695	01/11/2000	30/09/2005
13/09/07	RM/2007/035	SUZUKI MOTORCYCLES	GSX-R1000	ENGINE MAY NOT REMAIN AT IDLE SPEED	Gear engagement from neutral and low speed control of the machine could be affected by the idle speed control valve being of incorrect specification	Recall the machines that are likely to be affected to replace the idle speed control valve and to reprogramme the Electronic Control Module.	2091		GSXR1000	JS1CL111100100049	JS1CL111100111800
14/09/07	R/2007/140	VOLVO TRUCK	FL	BRAKES MAY ENGAGE WHILST DRIVING	It has been identified that the rear spring brake chambers may have possibly seal damage which can cause the brake to apply whilst the vehicle is being driven.	Recalled vehicles will have the spring brake chambers changed.	15	C0903	FL
17/09/07	R/2007/121	FIAT	Bravo	ANTI-ROLL BAR BUSH WEAR	It has been identified that the front anti-roll bar bushes may wear after a period of time. Should this occur noise will be generated by contact between the anti-roll bar and the metal sleeve of the bush.	Recalled vehicles will have the front anti-roll bar replaced.	867	5224	BRAVO	ZFA19800004005815	ZFA19800004052000	01/06/2007	30/06/2007
17/09/07	R/2007/112	VW	T5	FRONT RIGHT HAND TYRE MAY FAIL	It has been identified that during production the right-hand front tyre may have suffered damage to the inside face.	Recalled vehicles will have the subject tyre checked for damage and replaced as necessary.	526	44G3	T5	WV.ZZZ7HZ8H000045	WV.ZZZ7HZ8H008198	12/05/2007	08/06/2007
17/09/07	R/2007/112	VW	T5	FRONT RIGHT HAND TYRE MAY FAIL	It has been identified that during production the right-hand front tyre may have suffered damage to the inside face.	Recalled vehicles will have the subject tyre checked for damage and replaced as necessary.	526	44G3	T5	WV.ZZZ7HZ7H144956	WV.ZZZ7HZ7H151527	12/05/2007	08/06/2007
18/09/07	RM/2007/037	DUCATI	MONSTER S4RS AND ST3	ENGINE MAY FAIL	The engine may overheat because the water pump impeller shaft is of incorrect length and does not engage drive from the timing layshaft.	Recall the machines that are likely to be affected to check the engagement of the water pump impeller shaft and where necessary replace the water pump assembly.	11		MONSTER
24/09/07	RM/2007/028	TRIUMPH	Rockett III	ENGINE MAY STALL	It has been identified that the engine from time to time may stall when at idle.	Recalled vehicles will have the engine ECU re-programmed which will raise the engine RPM at idle.	1881		ROCKET 3	205267	320019	01/03/2004	31/05/2007
25/09/07	R/2007/120	AUDI	A6 - Avant with power tailgate & Q7 with power tailgate	TAILGATE MAY CLOSE WITHOUT WARNING	It has been identified that the power operated tailgate may close abruptly and unexpectedly following opening using the power function.	Recalled vehicle will have the tailgate motors replaced.	8468	55E4	A6	WAUZZZ4F#6N000101	WAUZZZ4F#6N195117	01/06/2004	31/07/2007
25/09/07	R/2007/120	AUDI	A6 - Avant with power tailgate & Q7 with power tailgate	TAILGATE MAY CLOSE WITHOUT WARNING	It has been identified that the power operated tailgate may close abruptly and unexpectedly following opening using the power function.	Recalled vehicle will have the tailgate motors replaced.	8468	55E4	Q7			01/06/2004	31/07/2007
25/09/07	R/2007/120	AUDI	A6 - Avant with power tailgate & Q7 with power tailgate	TAILGATE MAY CLOSE WITHOUT WARNING	It has been identified that the power operated tailgate may close abruptly and unexpectedly following opening using the power function.	Recalled vehicle will have the tailgate motors replaced.	8468	55E4	A6	WAUZZZ4F#5N000201	WAUZZZ4F#5N000391	01/06/2004	31/12/2005
25/09/07	R/2007/116	SEAT	IBIZA / CORDOBA	HEAD AIRBAG MAY FAIL TO ACTIVATE UNDER CERTAIN COLLISION CONDITIONS.	It has been identified that some SEAT vehicles fitted with right hand drive head airbag equipment due to an assembly error in the wiring may experience incorrect head airbag activation under certain collision conditions.	Recalled vehicles will have the subject wiring connections checked and corrected if necessary.	331		IBIZA	VSSZZZ6LZ4R000074	VSSZZZ6LZ4R221563	01/03/2004	31/07/2007
25/09/07	R/2007/116	SEAT	IBIZA / CORDOBA	HEAD AIRBAG MAY FAIL TO ACTIVATE UNDER CERTAIN COLLISION CONDITIONS.	It has been identified that some SEAT vehicles fitted with right hand drive head airbag equipment due to an assembly error in the wiring may experience incorrect head airbag activation under certain collision conditions.	Recalled vehicles will have the subject wiring connections checked and corrected if necessary.	331		CORDOBA
25/09/07	R/2007/116	SEAT	IBIZA / CORDOBA	HEAD AIRBAG MAY FAIL TO ACTIVATE UNDER CERTAIN COLLISION CONDITIONS.	It has been identified that some SEAT vehicles fitted with right hand drive head airbag equipment due to an assembly error in the wiring may experience incorrect head airbag activation under certain collision conditions.	Recalled vehicles will have the subject wiring connections checked and corrected if necessary.	331		CORDOBA			01/03/2004	31/07/2007
27/09/07	R/2007/117	IVECO BUS	BUS/NEW DAILY 2006	NO WARNING SIGNAL TO THE DRIVER WHEN TRAILER DIRECTION INDICATOR LAMPS FAIL.	It has been identified that the possibility exists that the driver will not receive a warning signal should the trailer direction indicator lamp/s fail.	Recalled vehicles will have the trailer lighting control unit replaced.	22	RCT32	DAILYBUS	ZCFC3583005644009	ZCFC29A2005656670	01/12/2006	31/03/2007
27/09/07	R/2007/117	IVECO BUS	BUS/NEW DAILY 2006	NO WARNING SIGNAL TO THE DRIVER WHEN TRAILER DIRECTION INDICATOR LAMPS FAIL.	It has been identified that the possibility exists that the driver will not receive a warning signal should the trailer direction indicator lamp/s fail.	Recalled vehicles will have the trailer lighting control unit replaced.	22	RCT32	DAILYBUS	ZCFC35D000D324317	ZCFC35D100D344468	01/09/2006	30/04/2007
01/10/07	R/2007/146	RENAULT TRUCKS UK LTD	Premium DXI and Kerax DXI	SHORT CIRCUIT MAY RESULT IN A FIRE	It has been identified that there is a risk of contact between the starter motor cable and the exhaust heat shielding. Should this occur and the cable insulation become damaged an electrical short circuit with the attendant risk of fire might ensue.	Affected vehicles will have the exhaust heat shielding re-shaped to prevent contact with the starter cable.	4	1D9	PREMIUM RANGE			09/09/2007	24/09/2007
01/10/07	R/2007/146	RENAULT TRUCKS UK LTD	Premium DXI and Kerax DXI	SHORT CIRCUIT MAY RESULT IN A FIRE	It has been identified that there is a risk of contact between the starter motor cable and the exhaust heat shielding. Should this occur and the cable insulation become damaged an electrical short circuit with the attendant risk of fire might ensue.	Affected vehicles will have the exhaust heat shielding re-shaped to prevent contact with the starter cable.	4	1D9	KERAX			09/09/2007	24/09/2007
04/10/07	R/2007/144	PEUGEOT	807 EW10J4	POSSIBILITY OF BRAKE FLUID LEAKAGE.	It has been identified that the heat shield which protects the exhaust system may contact one of the rear brake hoses. In extreme situations this may cause leakage within a brake circuit which would be represented by extended brake pedal travel.	Recalled vehicles will be checked for heat shield to brake hose contact and if necessary the shield will be adjusted. The brake hose will be replaced if rubbing contact has been made.	20		807 EW10J4
05/10/07	R/2007/123	RENAULT	TRAFIC II	DASHBOARD WIRING MY SHORT CIRCUIT	It has been identified that the dashboard wiring hs been mounted incorrectly. This may result in the vehicle failing to start the reversing lights failing to operate the risk of a short circuit of the FRH headlights damage to the wiring and high temperatures.	Recalled vehicles will have the dashboard wiring refitted and replaced as necessary.	2	oavG	TRAFIC			01/05/2006	08/03/2007
05/10/07	R/2007/123	RENAULT	TRAFIC II	DASHBOARD WIRING MY SHORT CIRCUIT	It has been identified that the dashboard wiring hs been mounted incorrectly. This may result in the vehicle failing to start the reversing lights failing to operate the risk of a short circuit of the FRH headlights damage to the wiring and high temperatures.	Recalled vehicles will have the dashboard wiring refitted and replaced as necessary.	2	oavG	TRAFIC			01/05/2006	10/04/2007
05/10/07	R/2007/145	RENAULT TRUCKS UK LTD	Midlum DXI	FRONT BRAKE PERFORMANCE MAY BE AFFECTED	It has been identified that the front brake chambers of affected vehicles may have been incorrectly torqued. Should this be the case detachment of the chamber and subsequent loss of braking effort at the affected wheel station may occur.	Recalled vehicles will have the front brake chambers checked for conformity. The chambers will be replaced should any nonconformance be found.	22	1E1	MIDLUM			03/09/2007	17/09/2007
08/10/07	R/2010/176	MERCEDES BENZ	Sprinter	AIRBAG MAY NOT INFLATE CORRECTLY	In the case of an incident where the air bags deploy as a result of the offside window bag module possibly having been fitted with a defective diffuser the air bag may not fully inflate and parts of the window bag module may detach and fly into the interior compartment at high speeds.	Recall the vehicles that are likely to be affected to replace the offside window bag module.	4	C129	SPRINTER	WDB9061352N316280	WDB9066352S176951
08/10/07	R/2010/175	MERCEDES BENZ	Sprinter	AIRBAG MAY NOT DEPLOY CORRECTLY	In the case of an incident where the air bags deploy as a result of the offside window bag module possibly having been fitted with a defective diffuser the air bag may not fully inflate and parts of the window bag module may detach and fly into the interior compartment at high speeds.	Recall the vehicles that are likely to be affected to replace the offside window bag module.	1	C128	SPRINTER
11/10/07	RM/2007/039	KTM	990 SUPER DUKE R	STEERING DAMPER BRACKET MAY FAIL	The steering damper bracket may fail which could result the steering being locked and loss of directional control.	Recall the machines that are likely to be affected to remove the steering damper.	65		990 SUPERDUKE			01/04/2007	31/05/2007
15/10/07	RM/2007/040	YAMAHA	NXC125 YP400 AND XP500	FUEL MAY LEAK	Possibility that the fuel tank may leak.	Recall the machines that are likely to be affected to replace the fuel pump seal.	1047		YP400			01/01/2005	01/10/2007
15/10/07	RM/2007/040	YAMAHA	NXC125 YP400 AND XP500	FUEL MAY LEAK	Possibility that the fuel tank may leak.	Recall the machines that are likely to be affected to replace the fuel pump seal.	1047		YP500			01/01/2005	01/10/2007
15/10/07	RM/2007/040	YAMAHA	NXC125 YP400 AND XP500	FUEL MAY LEAK	Possibility that the fuel tank may leak.	Recall the machines that are likely to be affected to replace the fuel pump seal.	1047		NXC125			01/01/2007	01/10/2007
15/10/07	R/2007/141	HONDA	CIVIC HYBRID	BRAKE LIGHTS MAY FAIL TO ILLUMINATE. GEAR SELECTOR MAY BECOME STUCK IN PARK	It has been identified that the brake lights may not illuminate when the brake pedal is depressed. Additionally it may not be possible for the driver to release the gear selector from the park(P) position.	Recalled vehicles will have the brake light switch replaced additionally a new block connector will be fitted which has additional protection against ingress of foreign substances.	601		CIVIC			02/02/2005	31/07/2006
15/10/07	R/2007/151	VOLVO TRUCK	FL	SPRING BRAKE CHAMBER OPERATION MAY BE AFFECTED IN LOW TEMPERATURES	Water may have been left in the rear Spring Brake Chambers after the production washing process which may freeze under cold conditions and effect the operation of the system	Recall affected vehicles to drain the actuators.	24		FL
19/10/07	R/2007/154	VOLVO TRUCK	FH/FM	BOLTS COULD BECOME LOOSE ON BRAKE CALIPER BRIDGE.	The holes on the brake caliper bridge may have been double threaded which may cause the bolts to become loose	Recall affected vehicles check part numbers and if necessary replace brake bridge	276		FH
19/10/07	R/2007/154	VOLVO TRUCK	FH/FM	BOLTS COULD BECOME LOOSE ON BRAKE CALIPER BRIDGE.	The holes on the brake caliper bridge may have been double threaded which may cause the bolts to become loose	Recall affected vehicles check part numbers and if necessary replace brake bridge	276		FM
22/10/07	RM/2007/041	KEEWAY	X-RAY ENDURO AND SUPERMOTARD	FRONT WHEEL COULD LOCK AND EJECT RIDER FROM MACHINE.	It has been identified that the bolts securing the two halves of the front brake caliper together; may not have been tightened to the correct torque. This could lead to the bolts migrating out of the caliper and making contact with the front wheel causing the wheel to lock. Should this occur the rider might be thrown from the machine.	Recalled machines will have the subject bolts tightened to the correct torque.	93		SUPERMOTARD			01/08/2007	31/08/2007
22/10/07	RM/2007/041	KEEWAY	X-RAY ENDURO AND SUPERMOTARD	FRONT WHEEL COULD LOCK AND EJECT RIDER FROM MACHINE.	It has been identified that the bolts securing the two halves of the front brake caliper together; may not have been tightened to the correct torque. This could lead to the bolts migrating out of the caliper and making contact with the front wheel causing the wheel to lock. Should this occur the rider might be thrown from the machine.	Recalled machines will have the subject bolts tightened to the correct torque.	93		X-RAY ENDURO			01/08/2007	31/08/2007
22/10/07	R/2007/127	KIA	SPORTAGE	ENGINE COOLING FAN BLADES COULD FRACTURE AND DAMAGE THE COOLING SYSTEM.	It has been established that the plastic cooling fan blades could fracture and damage the cooling system/hoses causing the engine to overheat and possibly fail.	Recalled vehicles will have the engine cooling fan replaced with a modified unit.	2253		SPORTAGE			01/01/2001	31/12/2002
24/10/07	R/2007/142	NEOMAN BUS UK	SKYLINER STARLINER EUROLINER	BOLTS ON THE LOWER TRAPEZOIDAL LINK TO FRONT AND TRAILING AXLE MAY BREAK.	It has been identified that the bolts on the trapezoidal link to the front and trailing axle may break due to corrosion.	Recalled vehicles will have the bolts replaced with quality assured items.	256	254104e	STARLINER			01/01/2005	31/12/2006
24/10/07	R/2007/142	NEOMAN BUS UK	SKYLINER STARLINER EUROLINER	BOLTS ON THE LOWER TRAPEZOIDAL LINK TO FRONT AND TRAILING AXLE MAY BREAK.	It has been identified that the bolts on the trapezoidal link to the front and trailing axle may break due to corrosion.	Recalled vehicles will have the bolts replaced with quality assured items.	256	254104e	EUROLINER N316SHD			01/01/2005	31/12/2006
24/10/07	R/2007/142	NEOMAN BUS UK	SKYLINER STARLINER EUROLINER	BOLTS ON THE LOWER TRAPEZOIDAL LINK TO FRONT AND TRAILING AXLE MAY BREAK.	It has been identified that the bolts on the trapezoidal link to the front and trailing axle may break due to corrosion.	Recalled vehicles will have the bolts replaced with quality assured items.	256	254104e	SKYLINER N122/3L			01/01/2005	31/12/2006
25/10/07	R/2007/148	PEUGEOT	Expert III	POTENTIAL LOSS OF POWER STEERING ASSISTANCE	It has been identified that the earthing terminal for the electrical power assisted steering assembly may require reinforcing. This is necessary in order to provide the correct electrical supply to the power steering assembly and to prevent possible loss of steering assistance. In any case the vehicle's steering capacity is not altered.	Recalled vehicles will have the power steering earth connection reinforced as necessary.	749	YGC	EXPERT			05/05/2006	23/03/2007
26/10/07	R/2007/126	IVECO	Eurocargo Tector 60 E to 320 E	THE CONTACTS IN THE CAB LOOM MAY OXIDIZE AND OVERHEAT POSSIBILITY OF FIRE.	It has been identified that the possibility exists that the contacts in the cab wiring loom may oxidize and cause overheating of the connector block. In the worst case this may result in a fire.	Recalled vehicles will have the suspect wires removed from the connector block. Theses will then be reconnected using heat shrink terminals.	12045	RC G26	EUROCARGO	ZCFA1AF1102350527	ZCFA1LD0002412703	01/06/2001	31/05/2003
29/10/07	R/2007/162	VOLVO CAR	V70 & XC70	AIRBAGS MAY NOT DEPLOY AS INTENDED	It has been identified that due to a software deviation within the supplementary restraint system (SRS) the inflatable curtain and side impact protection system may not deploy as intended.	Recalled vehicles will have the SRS software updated.	2386	R87093 & R87094	XC70	328	12705
29/10/07	R/2007/162	VOLVO CAR	V70 & XC70	AIRBAGS MAY NOT DEPLOY AS INTENDED	It has been identified that due to a software deviation within the supplementary restraint system (SRS) the inflatable curtain and side impact protection system may not deploy as intended.	Recalled vehicles will have the SRS software updated.	2386	R87093 & R87094	XC70	328	10287
29/10/07	R/2007/162	VOLVO CAR	V70 & XC70	AIRBAGS MAY NOT DEPLOY AS INTENDED	It has been identified that due to a software deviation within the supplementary restraint system (SRS) the inflatable curtain and side impact protection system may not deploy as intended.	Recalled vehicles will have the SRS software updated.	2386	R87093 & R87094	V70	342	13463
29/10/07	R/2007/162	VOLVO CAR	V70 & XC70	AIRBAGS MAY NOT DEPLOY AS INTENDED	It has been identified that due to a software deviation within the supplementary restraint system (SRS) the inflatable curtain and side impact protection system may not deploy as intended.	Recalled vehicles will have the SRS software updated.	2386	R87093 & R87094	V70	342	17032
30/10/07	R/2007/143	RENAULT	MODUS	FRONT HEAD RESTRAINT MAY NOT RETAIN ITS POSITION IN THE EVENT OF AN IMPACT.	It has been identified that the possibility exists that the front seat head restraint components may have been incorrectly welded into position in the seat frame. This in certain cases can cause the sleeve to become loose to the seat frame. This has the potential to prevent the front seat head restraints retaining their position in the event of an impact.	Recalled vehicles will have the fabrication of the two front seat back frames checked. These will be replaced if found to be necessary.	76		MODUS			27/10/2004	28/10/2004
31/10/07	R/2007/190	ISUZU	RODEO PICK UP	BRAKE MASTER CYLINDER MAY FAIL	The front brakes may fail as a result of a fault in the brake master cylinder.	Recall the vehicles that are likely to be affected to fit new brake master cylinders.	782		PICK UP
31/10/07	R/2007/155	AUTO-SLEEPERS LTD	WILTON	EXHAUST FUMES COULD ENTER THE CAB AREA	Engine exhaust fumes may travel up the 'B' post and enter the cab area.	Recall affected vehicles and fit a new designed exhaust extension	13		WILTON			06/02/2006	05/06/2007
01/11/07	R/2008/005	MAN	TGL TGM & TGA	STEERING MAY FAIL	The steering upper universal joint may be incorrectly located and secured on the shaft. Steering control may be affected.	Recall affected vehicles check if joint located correctly if not reposition and fit and correctly torque new securing bolt.	2	263204	TGM
01/11/07	R/2008/005	MAN	TGL TGM & TGA	STEERING MAY FAIL	The steering upper universal joint may be incorrectly located and secured on the shaft. Steering control may be affected.	Recall affected vehicles check if joint located correctly if not reposition and fit and correctly torque new securing bolt.	2	263204	TG-A
01/11/07	R/2008/005	MAN	TGL TGM & TGA	STEERING MAY FAIL	The steering upper universal joint may be incorrectly located and secured on the shaft. Steering control may be affected.	Recall affected vehicles check if joint located correctly if not reposition and fit and correctly torque new securing bolt.	2	263204	TGL
07/11/07	R/2007/128	SEDDON ATKINSON	Various	POSSIBILITY OF FIRE	It has been identified that the possibility exists that the contacts in the cab wiring loom may oxidize and cause overheating of the connector block. In the worst case this may result in a fire.	Recalled vehicles will have the suspect wires removed from the connector block. Theses will then be reconnected using heat shrink terminals.	275	RC G26	VARIOUS			01/08/2002	31/05/2003
07/11/07	R/2007/165	CITROEN	C1	POSSIBILITY OF FUEL LEAK	It has been identified that during the fuel tank production process the joint between the tank and the fuel supply pipe assembly may not have been produced to the correct standard. Should this indeed be the case leakage from the supply pipe area of the fuel tank might occur.	Recalled vehicles will have the fuel tank inspected and replaced as necessary.	33	YFC	C1	VF7******89146681	VFY******89149153	16/05/2007	25/05/2007
07/11/07	R/2007/164	CITROEN	C8	POSSIBILITY OF EXTENDED BRAKE PEDAL TRAVEL	It has been identified that a brake hose may become worn as a result of rubbing contact against the heat shield protecting the exhaust system. This may lead in extreme cases to a leak from a brake circuit which manifests itself in increased brake pedal travel.	Recalled vehicles will have the exhaust heat shield adjusted in order to maintain the correct distance from the subject brake hose. Should the hose display signs of wear it will be replaced.	18	YEW	C8	VF7******13320046	VF7******13340501	12/12/2006	20/04/2007
08/11/07	R/2007/160	LDV	MAXUS	POTENTIAL DETACHMENT OF REAR HUB ASSEMBLY	It has been identified that due to possible incorrect assembly of the rear axle hub through omission of the bearing retaining nut split pin. The potential exists for detachment of a rear hub assembly.	Recalled vehicles will be checked to ensure completeness of the assembly and the presence of split pins in both rear hubs.	18770		MAXUS	200001	221250	01/01/2005	30/09/2007
08/11/07	RCOMP/2007/006	DELPHI	Suspension Wishbone	LOSS OF VEHICLE FRONT WHEEL SUSPENSION	A possibility exists that the suspension wishbone may crack and in the worst case fail completely causing loss of suspension and direction control	Recall the vehicles that are likely to be affected to replace the wishbone.	1003		SUSPENSION WISHBONES
12/11/07	R/2007/163	CITROEN	Dispatch	POSSIBLE LOSS OF POWER STEERING	It has been identified that poor protection of the power steering pump earth terminal; could result in loss of power assistance to the steering.	Recalled vehicles will have the power steering pump earth terminal protection reinforced.	689	YCW	DISPATCH	VF7******64003925	VF7******64042952	26/07/2006	22/03/2007
12/11/07	RCT/2007/003	ANDOVER TRAILERS LIMITED	CBDB12	INSUFFICIENT WELD PENETRATION ON DRAWBAR MAY RESULT IN TRAILER DETACHMENT	It has been identified that insufficient weld penetration at the reinforcement bush for the extending drawbar caused trailer detachment.	Recalled vehicles will be fitted with a non-extendable drawbar.	2		CBDB12	SA9120U60850046	SA9120U60850046
12/11/07	RCT/2007/003	ANDOVER TRAILERS LIMITED	CBDB12	INSUFFICIENT WELD PENETRATION ON DRAWBAR MAY RESULT IN TRAILER DETACHMENT	It has been identified that insufficient weld penetration at the reinforcement bush for the extending drawbar caused trailer detachment.	Recalled vehicles will be fitted with a non-extendable drawbar.	2		CBDB12	SA9120U5080033	SA9120U5080033
12/11/07	R/2007/069	DAIHATSU	HIJET VAN AND PICK-UP	PROPSHAFT MAY DETACH	It has been identified that failure of the propshaft universal joint may occur which can cause the propshaft to detach. On van versions the propshaft may contact the fuel tank and or the fuel lines.	Recalled vehicles will be fitted with a quality assured propshaft.	1605		HIJET			01/06/1998	31/12/2004
12/11/07	RM/2007/043	KTM	SX & EXC	FUEL MAY LEAK	Under certain circumstances it is possible that if the customers do not properly secure the fuel cap or if it is knocked by the rider's body during off road use then the fuel tank cap may leak and allow fuel to leak over the rider and engine.	To overcome this issue the manufacturer is to recall the likely affected machines to fit a new design of self locking fuel cap.	2004		EXC			01/08/2005	30/04/2007
12/11/07	RM/2007/043	KTM	SX & EXC	FUEL MAY LEAK	Under certain circumstances it is possible that if the customers do not properly secure the fuel cap or if it is knocked by the rider's body during off road use then the fuel tank cap may leak and allow fuel to leak over the rider and engine.	To overcome this issue the manufacturer is to recall the likely affected machines to fit a new design of self locking fuel cap.	2004		SX			01/08/2005	30/04/2007
16/11/07	RM/2008/003	BMW MOTORCYCLES	G650	REAR WHEEL BEARING MAY FAIL	Some motorcycles left the factory with an incorrect circlip fitted to the left hand side of the wheel bearing guide. It is possible for the circlip to rub against the spacing bushing and the resultant metal particles may penetrate the wheel bearing and cause failure. The metal particles may also cause incorrect ABS sensor signals where the warning lamp will illuminated but the brake will still function.	Recall the vehicles that are likely to be affected to replace the rear wheel bearings seals circlip and spacing bushing.	135	1363900	G650	XB60000	XB60405
16/11/07	RM/2008/003	BMW MOTORCYCLES	G650	REAR WHEEL BEARING MAY FAIL	Some motorcycles left the factory with an incorrect circlip fitted to the left hand side of the wheel bearing guide. It is possible for the circlip to rub against the spacing bushing and the resultant metal particles may penetrate the wheel bearing and cause failure. The metal particles may also cause incorrect ABS sensor signals where the warning lamp will illuminated but the brake will still function.	Recall the vehicles that are likely to be affected to replace the rear wheel bearings seals circlip and spacing bushing.	135	1363900	G650	XB20000	XB20269
16/11/07	RM/2008/003	BMW MOTORCYCLES	G650	REAR WHEEL BEARING MAY FAIL	Some motorcycles left the factory with an incorrect circlip fitted to the left hand side of the wheel bearing guide. It is possible for the circlip to rub against the spacing bushing and the resultant metal particles may penetrate the wheel bearing and cause failure. The metal particles may also cause incorrect ABS sensor signals where the warning lamp will illuminated but the brake will still function.	Recall the vehicles that are likely to be affected to replace the rear wheel bearings seals circlip and spacing bushing.	135	1363900	G650	XA80000	XA81637
16/11/07	RM/2008/003	BMW MOTORCYCLES	G650	REAR WHEEL BEARING MAY FAIL	Some motorcycles left the factory with an incorrect circlip fitted to the left hand side of the wheel bearing guide. It is possible for the circlip to rub against the spacing bushing and the resultant metal particles may penetrate the wheel bearing and cause failure. The metal particles may also cause incorrect ABS sensor signals where the warning lamp will illuminated but the brake will still function.	Recall the vehicles that are likely to be affected to replace the rear wheel bearings seals circlip and spacing bushing.	135	1363900	G650	XB00000	XB01857
16/11/07	RM/2008/003	BMW MOTORCYCLES	G650	REAR WHEEL BEARING MAY FAIL	Some motorcycles left the factory with an incorrect circlip fitted to the left hand side of the wheel bearing guide. It is possible for the circlip to rub against the spacing bushing and the resultant metal particles may penetrate the wheel bearing and cause failure. The metal particles may also cause incorrect ABS sensor signals where the warning lamp will illuminated but the brake will still function.	Recall the vehicles that are likely to be affected to replace the rear wheel bearings seals circlip and spacing bushing.	135	1363900	G650	XB40000	XB40717
16/11/07	RM/2008/003	BMW MOTORCYCLES	G650	REAR WHEEL BEARING MAY FAIL	Some motorcycles left the factory with an incorrect circlip fitted to the left hand side of the wheel bearing guide. It is possible for the circlip to rub against the spacing bushing and the resultant metal particles may penetrate the wheel bearing and cause failure. The metal particles may also cause incorrect ABS sensor signals where the warning lamp will illuminated but the brake will still function.	Recall the vehicles that are likely to be affected to replace the rear wheel bearings seals circlip and spacing bushing.	135	1363900	G650	XA60000	XA62134
16/11/07	RM/2008/002	BMW MOTORCYCLES	G650	FUEL MAY LEAK	In isolated cases it is possible for the fuel lines to leak as a result of damage during their manufacture.	Recall the vehicles that are likely to be affected to replace the fuel lines.	338		G650	XB20000	XB20269
16/11/07	RM/2008/002	BMW MOTORCYCLES	G650	FUEL MAY LEAK	In isolated cases it is possible for the fuel lines to leak as a result of damage during their manufacture.	Recall the vehicles that are likely to be affected to replace the fuel lines.	338		G650	XB40000	XB40717
16/11/07	RM/2008/002	BMW MOTORCYCLES	G650	FUEL MAY LEAK	In isolated cases it is possible for the fuel lines to leak as a result of damage during their manufacture.	Recall the vehicles that are likely to be affected to replace the fuel lines.	338		G650	XA80000	XA81637
16/11/07	RM/2008/002	BMW MOTORCYCLES	G650	FUEL MAY LEAK	In isolated cases it is possible for the fuel lines to leak as a result of damage during their manufacture.	Recall the vehicles that are likely to be affected to replace the fuel lines.	338		G650	XB60000	XB60405
16/11/07	RM/2008/002	BMW MOTORCYCLES	G650	FUEL MAY LEAK	In isolated cases it is possible for the fuel lines to leak as a result of damage during their manufacture.	Recall the vehicles that are likely to be affected to replace the fuel lines.	338		G650	XB00000	XB01857
16/11/07	RM/2008/002	BMW MOTORCYCLES	G650	FUEL MAY LEAK	In isolated cases it is possible for the fuel lines to leak as a result of damage during their manufacture.	Recall the vehicles that are likely to be affected to replace the fuel lines.	338		G650	XA60000	XA62134
23/11/07	R/2007/149	FIAT	Idea	FRONT SUSPENSION ARM MOUNTINGS - FAILURE OF WELD	There is a possibility that corrosion may be present near the welds for the front suspension arm front mountings on the front cross member.Should this be the case in time this could lead to noise whilst driving and the possibility that the weld could fail. Failure of the weld may lead to loss of vehicle stability.	Recalled vehicle will be checked to ascertain whether corrosion is present near the front suspension mountings. If this is found to be the case the front cross member will be replaced. If corrosion is not present a front cross member strengthening kit will be fitted.	793		IDEA	ZFA35000000055997	ZFA35000000103352	01/05/2005	30/09/2005
23/11/07	R/2007/149	FIAT	Idea	FRONT SUSPENSION ARM MOUNTINGS - FAILURE OF WELD	There is a possibility that corrosion may be present near the welds for the front suspension arm front mountings on the front cross member.Should this be the case in time this could lead to noise whilst driving and the possibility that the weld could fail. Failure of the weld may lead to loss of vehicle stability.	Recalled vehicle will be checked to ascertain whether corrosion is present near the front suspension mountings. If this is found to be the case the front cross member will be replaced. If corrosion is not present a front cross member strengthening kit will be fitted.	793		IDEA	ZFA35000000038691	ZFA35000000038691	01/05/2005	30/09/2005
23/11/07	R/2007/149	FIAT	Idea	FRONT SUSPENSION ARM MOUNTINGS - FAILURE OF WELD	There is a possibility that corrosion may be present near the welds for the front suspension arm front mountings on the front cross member.Should this be the case in time this could lead to noise whilst driving and the possibility that the weld could fail. Failure of the weld may lead to loss of vehicle stability.	Recalled vehicle will be checked to ascertain whether corrosion is present near the front suspension mountings. If this is found to be the case the front cross member will be replaced. If corrosion is not present a front cross member strengthening kit will be fitted.	793		IDEA	ZFA35000000782432	ZFA35000000782432	01/05/2005	30/09/2005
23/11/07	R/2007/153	FIAT	DUCATO (250)	STEERING COULD BECOME INCREASINGLY STIFF.	It has been identified that; due to a possible lack of lubricant between the steering rack and pinion the steering may become increasingly stiff to operate. This can eventually lead to damage to the steering rack teeth. As a consequence the steering operation of the vehicle may become increasingly difficult.	Recalled vehicles will have the steering rack inspected for damage. If no damage is evident the rack and pinion will be lubricated. Should any damage be in evidence the steering rack will be replaced.	5427		DUCATO	ZFA25000001000000	ZFA25000001173859	01/07/2006	30/06/2007
23/11/07	R/2007/150	FIAT	Ducato (250) with steel wheels	TYRE VALVE MAY BREAK CAUSING RAPID DEFLATION (STEEL WHEELS)	It has been identified that due to manufacture from an incorrect material the tyre inflation valve may break. Should this occur rapid deflation of the tyre and possible vehicle instability would occur.	Recalled vehicles will have the tyre inflation valve replaced on all steel wheels including the spare.	368		DUCATO	ZFA25000001268314	ZFA25000001292389	01/08/2007	30/09/2007
23/11/07	R/2007/152	FIAT	DUCATO	FRONT WINDSCREEN WIPERS MAY BECOME INOPERATIVE	It has been identified that the possibility exists that water may ingress into the front windscreen wiper motor. Should this occur the wipers may become inoperative. In conditions of poor visibility this may result in impaired driver visibility.	Recalled vehicles will have the front windscreen wiper motor fitted with a protective cover.	3253	5223	DUCATO	ZFA25000001000000	ZFA25000001114798	01/07/2006	31/12/2006
28/11/07	R/2007/167	FORD	FIESTA FUSION & TRANSIT	POWER STEERING MAY BE LOST	It has been identified that the power steering pump drive belts could de-laminate and fail. Should this occur drive to the power steering pump would be lost likewise the assistance to the steering.	Recalled vehicles will have the power steering drive belts checked and renewed should they be found to be within the affected batch.	7000	7C148	TRANSIT			01/10/2007	07/11/2007
28/11/07	R/2007/167	FORD	FIESTA FUSION & TRANSIT	POWER STEERING MAY BE LOST	It has been identified that the power steering pump drive belts could de-laminate and fail. Should this occur drive to the power steering pump would be lost likewise the assistance to the steering.	Recalled vehicles will have the power steering drive belts checked and renewed should they be found to be within the affected batch.	7000	7C148	FUSION			08/10/2007	07/11/2007
28/11/07	R/2007/167	FORD	FIESTA FUSION & TRANSIT	POWER STEERING MAY BE LOST	It has been identified that the power steering pump drive belts could de-laminate and fail. Should this occur drive to the power steering pump would be lost likewise the assistance to the steering.	Recalled vehicles will have the power steering drive belts checked and renewed should they be found to be within the affected batch.	7000	7C148	FIESTA			08/10/2007	07/11/2007
29/11/07	R/2007/176	VOLVO CAR	C30 S40 & V50	BRAKING PERFORMANCE MAY BE AFFECTED	Brake servo assistance from the vacuum pump may be reduced under certain cold start conditions. The brakes will still function but more pressure on the pedal will be required than normal.	Recall the vehicles that are likely to be affected to fit a modified non-return valve to the vacuum pump.	10871		V50	162669	312148
29/11/07	R/2007/176	VOLVO CAR	C30 S40 & V50	BRAKING PERFORMANCE MAY BE AFFECTED	Brake servo assistance from the vacuum pump may be reduced under certain cold start conditions. The brakes will still function but more pressure on the pedal will be required than normal.	Recall the vehicles that are likely to be affected to fit a modified non-return valve to the vacuum pump.	10871		S40	163780	193791
29/11/07	R/2007/176	VOLVO CAR	C30 S40 & V50	BRAKING PERFORMANCE MAY BE AFFECTED	Brake servo assistance from the vacuum pump may be reduced under certain cold start conditions. The brakes will still function but more pressure on the pedal will be required than normal.	Recall the vehicles that are likely to be affected to fit a modified non-return valve to the vacuum pump.	10871		V50	186270	194303
29/11/07	R/2007/176	VOLVO CAR	C30 S40 & V50	BRAKING PERFORMANCE MAY BE AFFECTED	Brake servo assistance from the vacuum pump may be reduced under certain cold start conditions. The brakes will still function but more pressure on the pedal will be required than normal.	Recall the vehicles that are likely to be affected to fit a modified non-return valve to the vacuum pump.	10871		C30	1	8766
29/11/07	R/2007/176	VOLVO CAR	C30 S40 & V50	BRAKING PERFORMANCE MAY BE AFFECTED	Brake servo assistance from the vacuum pump may be reduced under certain cold start conditions. The brakes will still function but more pressure on the pedal will be required than normal.	Recall the vehicles that are likely to be affected to fit a modified non-return valve to the vacuum pump.	10871		S40	162003	295267
30/11/07	R/2008/020	MERCEDES BENZ	S & CL Class	POTENTIAL LEAK OF BRAKE LINE	Corrosion may occur in the brake line to the front/rear axle distibuter. If left unattended this could result in brake fluid leakage and loss of brake efficiency.	Recall the vehicles that are likely to be affected to replace the brake pipe with one of a modified design.	2987	P097	CL CLASS			01/01/1999	31/12/2003
30/11/07	R/2008/020	MERCEDES BENZ	S & CL Class	POTENTIAL LEAK OF BRAKE LINE	Corrosion may occur in the brake line to the front/rear axle distibuter. If left unattended this could result in brake fluid leakage and loss of brake efficiency.	Recall the vehicles that are likely to be affected to replace the brake pipe with one of a modified design.	2987	P097	S CLASS			01/01/1999	31/12/2003
30/11/07	RCOMP/2009/002	DOMETIC GMBH	Fridge Freezer - 7 series	FIXING SCREWS OF COOLING UNIT ARE MISSING	Fire could occur as a result of a screw retaining the cooling unit coming loose. The ensuing vibrations can then lead to a gas leak on the valve screw connection.	Recall the units that are likely to be affected to where necessary replace the fixings used to retain the cooling unit to carry out appropriate gas tests and rectify leaks.	5400		7 Series Fridge Freezer			20/01/2004	20/08/2027
01/12/07	R/2008/010	AYATS	Bravo 1R	SUSPENSION JOINT MAY FAIL	The Anti - Roll Bar chassis mounting bracket may fail allowing the Anti - Roll Bar to become insecure	Recall affected vehicles and replace chassis mounting bracket with modified type.	9		BRAVO 1			01/01/2006	31/12/2006
01/12/07	RSPV/2007/014	CRANES UK LTD	Mitsubishi Mobile Cranes - Various	REAR AXLE HUB MAY FAIL	It has been identified that there is a possibility that a rear axle hub might fracture. Additionally fractures might occur in the clutch housing due to insufficient rigidity of the material.	Subject vehicles will have the rear hubs replaced. Additionally the clutch housing with one constructed of cast iron.	35		MITSUBISHI MOBILE CRANES - VARIOUS
04/12/07	RM/2007/044	DUCATI	Hypermotard 1100 & 1100S	NUMBER PLATE HOLDER MAY DETACH	It has been identified that due to a manufacturing deviation the number plate holder may break.	Recalled machines will be fitted with a quality assured number plate holder.	154	732	HYPERMOTARD
05/12/07	R/2007/133	FORD	FOCUS C-MAX S-MAX AND GALAXY	IN LOW AMBIENT TEMPERATURE HARD BRAKE PEDAL MAY OCCUR	Hard brake pedal may occur in low ambient temperatures which is caused by a non return valve in the vacuum pump sticking.	Recall the vehicles that are likely to be affected to fit a revised non return valve to the brake vacuum pump.	17972	7C127	S-MAX			02/11/2005	30/12/2006
05/12/07	R/2007/133	FORD	FOCUS C-MAX S-MAX AND GALAXY	IN LOW AMBIENT TEMPERATURE HARD BRAKE PEDAL MAY OCCUR	Hard brake pedal may occur in low ambient temperatures which is caused by a non return valve in the vacuum pump sticking.	Recall the vehicles that are likely to be affected to fit a revised non return valve to the brake vacuum pump.	17972	7C127	FOCUS			01/08/2005	28/12/2006
05/12/07	R/2007/133	FORD	FOCUS C-MAX S-MAX AND GALAXY	IN LOW AMBIENT TEMPERATURE HARD BRAKE PEDAL MAY OCCUR	Hard brake pedal may occur in low ambient temperatures which is caused by a non return valve in the vacuum pump sticking.	Recall the vehicles that are likely to be affected to fit a revised non return valve to the brake vacuum pump.	17972	7C127	CMAX			01/08/2005	28/12/2006
05/12/07	R/2007/133	FORD	FOCUS C-MAX S-MAX AND GALAXY	IN LOW AMBIENT TEMPERATURE HARD BRAKE PEDAL MAY OCCUR	Hard brake pedal may occur in low ambient temperatures which is caused by a non return valve in the vacuum pump sticking.	Recall the vehicles that are likely to be affected to fit a revised non return valve to the brake vacuum pump.	17972	7C127	GALAXY			02/11/2005	30/12/2006
06/12/07	RM/2007/042	TRIUMPH	SPRINT 1050ST & TIGER 1050 (INC ABS MODELS)	ACCESSORY RACK MAY CAUSE INSTABILITY IF OVERLOADED	It has been identified that the luggage top carriage may have insufficient lateral movement. Should this be the case the stability of the machine might be affected if ridden with the accessories fitted at speeds far in excess of the 80 mph/130kph limit warning.	Recalled machines will be checked to ensure that the carriage has sufficient lateral movement.	4237		TIGER
06/12/07	RM/2007/042	TRIUMPH	SPRINT 1050ST & TIGER 1050 (INC ABS MODELS)	ACCESSORY RACK MAY CAUSE INSTABILITY IF OVERLOADED	It has been identified that the luggage top carriage may have insufficient lateral movement. Should this be the case the stability of the machine might be affected if ridden with the accessories fitted at speeds far in excess of the 80 mph/130kph limit warning.	Recalled machines will be checked to ensure that the carriage has sufficient lateral movement.	4237		SPRINT ST
06/12/07	RM/2007/045	DUCATI	1098/1098S & 1098 Tricolore	ENGINE MAY STALL	It has been identified that the engine can stall at idle due to the ECU requiring to be re-mapped.	Recalled machines will have the ECU re-mapped.	255		TRICOLORE	ZDMH700AA6B000007	ZDMH700AA7B004659
06/12/07	RM/2007/045	DUCATI	1098/1098S & 1098 Tricolore	ENGINE MAY STALL	It has been identified that the engine can stall at idle due to the ECU requiring to be re-mapped.	Recalled machines will have the ECU re-mapped.	255		1098	ZDMH700AA6B000007	ZDMH700AA7B004659
07/12/07	R/2007/173	FIAT	Panda Grande Punto Bravo and Multipla	BRAKES MAY FAIL	Due to the possibility of a fault in the production process the flexible rubber brake hoses may not have been correctly vulcanised. As a consequence may partially or totally restrict the internal flow of the brake hydraulic fluid. Should this happen a reduction in efficiency during braking would occur.	Recalled vehicles will have the hoses checked to identify if they are within the affected batch. If this is the case they will be replaced with quality assured items.	4804	5260	GRANDE PUNTO	ZFA19900000347085	ZFA19900000363506	12/10/2007	14/11/2007
07/12/07	R/2007/173	FIAT	Panda Grande Punto Bravo and Multipla	BRAKES MAY FAIL	Due to the possibility of a fault in the production process the flexible rubber brake hoses may not have been correctly vulcanised. As a consequence may partially or totally restrict the internal flow of the brake hydraulic fluid. Should this happen a reduction in efficiency during braking would occur.	Recalled vehicles will have the hoses checked to identify if they are within the affected batch. If this is the case they will be replaced with quality assured items.	4804	5260	GRANDE PUNTO	ZFA19900002041923	ZFA19900002050313	16/10/2007	14/11/2007
07/12/07	R/2007/173	FIAT	Panda Grande Punto Bravo and Multipla	BRAKES MAY FAIL	Due to the possibility of a fault in the production process the flexible rubber brake hoses may not have been correctly vulcanised. As a consequence may partially or totally restrict the internal flow of the brake hydraulic fluid. Should this happen a reduction in efficiency during braking would occur.	Recalled vehicles will have the hoses checked to identify if they are within the affected batch. If this is the case they will be replaced with quality assured items.	4804	5260	BRAVO	ZFA19800004101184	ZFA19800004106814	07/11/2007	14/11/2007
07/12/07	R/2007/173	FIAT	Panda Grande Punto Bravo and Multipla	BRAKES MAY FAIL	Due to the possibility of a fault in the production process the flexible rubber brake hoses may not have been correctly vulcanised. As a consequence may partially or totally restrict the internal flow of the brake hydraulic fluid. Should this happen a reduction in efficiency during braking would occur.	Recalled vehicles will have the hoses checked to identify if they are within the affected batch. If this is the case they will be replaced with quality assured items.	4804	5260	PANDA	ZFA16900001023629	ZFA16900001045874	11/10/2007	27/10/2007
07/12/07	R/2007/173	FIAT	Panda Grande Punto Bravo and Multipla	BRAKES MAY FAIL	Due to the possibility of a fault in the production process the flexible rubber brake hoses may not have been correctly vulcanised. As a consequence may partially or totally restrict the internal flow of the brake hydraulic fluid. Should this happen a reduction in efficiency during braking would occur.	Recalled vehicles will have the hoses checked to identify if they are within the affected batch. If this is the case they will be replaced with quality assured items.	4804	5260	GRANDE PUNTO	ZFA19900001325671	ZFA19900001347783	12/10/2007	14/11/2007
07/12/07	R/2007/173	FIAT	Panda Grande Punto Bravo and Multipla	BRAKES MAY FAIL	Due to the possibility of a fault in the production process the flexible rubber brake hoses may not have been correctly vulcanised. As a consequence may partially or totally restrict the internal flow of the brake hydraulic fluid. Should this happen a reduction in efficiency during braking would occur.	Recalled vehicles will have the hoses checked to identify if they are within the affected batch. If this is the case they will be replaced with quality assured items.	4804	5260	MULTIPLA	ZFA18600002310141	ZFA18600002331490	06/11/2007	19/11/2007
07/12/07	R/2007/169	FORD	Focus CC	ROLL OVER PROTECTION MAY FAIL	It has been identified that on affected vehicles the roll over protection system securing bolts may either be loose or not fully tight. In this condition the roll over protection may not be fully effective in the event of a roll over occurring.	Recalled vehicles will have the protection units checked for the correct number of securing bolts with bolts being installed as necessary. In addition all securing bolts will be checked to ensure that they are tightened to the correct specification.	3	7c145	FOCUS
07/12/07	R/2007/174	ALFA ROMEO	147 GT 159 Brera and Spider	BRAKES MAY FAIL	Due to the possibility of a fault in the production process the flexible rubber brake hoses may not have been correctly vulcanised. As a consequence may partially or totally restrict the internal flow of the brake hydraulic fluid. Should this happen a reduction in efficiency during braking would occur.	Recalled vehicles will have the hoses checked to identify if they are within the affected batch. If this is the case they will be replaced with quality assured items.	687		147	ZAR93700003404366	ZAR93700003409538	16/10/2007	16/11/2007
07/12/07	R/2007/174	ALFA ROMEO	147 GT 159 Brera and Spider	BRAKES MAY FAIL	Due to the possibility of a fault in the production process the flexible rubber brake hoses may not have been correctly vulcanised. As a consequence may partially or totally restrict the internal flow of the brake hydraulic fluid. Should this happen a reduction in efficiency during braking would occur.	Recalled vehicles will have the hoses checked to identify if they are within the affected batch. If this is the case they will be replaced with quality assured items.	687		BRERA	ZAR93900005021630	ZAR93900005021749	20/11/2007	22/11/2007
07/12/07	R/2007/174	ALFA ROMEO	147 GT 159 Brera and Spider	BRAKES MAY FAIL	Due to the possibility of a fault in the production process the flexible rubber brake hoses may not have been correctly vulcanised. As a consequence may partially or totally restrict the internal flow of the brake hydraulic fluid. Should this happen a reduction in efficiency during braking would occur.	Recalled vehicles will have the hoses checked to identify if they are within the affected batch. If this is the case they will be replaced with quality assured items.	687		GT	ZAR93700003403295	ZAR93700003409513	16/10/2007	16/11/2007
07/12/07	R/2007/174	ALFA ROMEO	147 GT 159 Brera and Spider	BRAKES MAY FAIL	Due to the possibility of a fault in the production process the flexible rubber brake hoses may not have been correctly vulcanised. As a consequence may partially or totally restrict the internal flow of the brake hydraulic fluid. Should this happen a reduction in efficiency during braking would occur.	Recalled vehicles will have the hoses checked to identify if they are within the affected batch. If this is the case they will be replaced with quality assured items.	687		147	ZAR93700005267140	ZAR93700005269407	16/10/2007	16/11/2007
07/12/07	R/2007/174	ALFA ROMEO	147 GT 159 Brera and Spider	BRAKES MAY FAIL	Due to the possibility of a fault in the production process the flexible rubber brake hoses may not have been correctly vulcanised. As a consequence may partially or totally restrict the internal flow of the brake hydraulic fluid. Should this happen a reduction in efficiency during braking would occur.	Recalled vehicles will have the hoses checked to identify if they are within the affected batch. If this is the case they will be replaced with quality assured items.	687		159	ZAR93900007148416	ZAR93900007154237	17/10/2007	19/11/2007
07/12/07	R/2007/174	ALFA ROMEO	147 GT 159 Brera and Spider	BRAKES MAY FAIL	Due to the possibility of a fault in the production process the flexible rubber brake hoses may not have been correctly vulcanised. As a consequence may partially or totally restrict the internal flow of the brake hydraulic fluid. Should this happen a reduction in efficiency during braking would occur.	Recalled vehicles will have the hoses checked to identify if they are within the affected batch. If this is the case they will be replaced with quality assured items.	687		GT	ZAR93700005267033	ZAR93700005269013	16/10/2007	16/11/2007
07/12/07	R/2007/174	ALFA ROMEO	147 GT 159 Brera and Spider	BRAKES MAY FAIL	Due to the possibility of a fault in the production process the flexible rubber brake hoses may not have been correctly vulcanised. As a consequence may partially or totally restrict the internal flow of the brake hydraulic fluid. Should this happen a reduction in efficiency during braking would occur.	Recalled vehicles will have the hoses checked to identify if they are within the affected batch. If this is the case they will be replaced with quality assured items.	687		SPIDER	ZAR93900005021630	ZAR93900005021749	20/11/2007	22/11/2007
07/12/07	R/2007/172	FIAT	NEW DUCATO	BRAKES MAY FAIL	Due to the possibility of a fault in the production process the flexible rubber brake hoses may not have been correctly vulcanised. As a consequence may partially or totally restrict the internal flow of the brake hydraulic fluid. Should this happen a reduction in efficiency during braking would occur.	Recalled vehicles will have the hoses checked to identify if they are within the affected batch. If this is the case they will be replaced with quality assured items.	336	5263	DUCATO	ZFA25000001313880	ZFA25000001335641	16/10/2007	14/11/2007
10/12/07	R/2007/181	VOLVO CAR	S80 & NEW V70	WEIGHT INFORMATION PRODUCT LABEL INCORRECTLY	It has been identified that the product label fitted to the inside of the right hand door pillar does not contain any weight information	Affected vehicles will have a replacement label affixed.	1		V70	2581	2587
10/12/07	R/2007/181	VOLVO CAR	S80 & NEW V70	WEIGHT INFORMATION PRODUCT LABEL INCORRECTLY	It has been identified that the product label fitted to the inside of the right hand door pillar does not contain any weight information	Affected vehicles will have a replacement label affixed.	1		S80	51056	60673
10/12/07	R/2007/182	VOLVO CAR	XC90	CAN-BUS CONNECTION MAY BE AFFECTED	It has been identified that upon insertion of the ignition key the engine control module may transmit a signal to shut down the Can-Bus network thus disabling functions such as the climate control.	Recalled vehicles will have the relevant software upgraded.	245		XC90	328000	448032
11/12/07	R/2008/003	VOLVO TRUCK	FL/FE	TORQUE REDUCTION VALUE LABEL MISSING ON ENGINE	It has been identified that the engine information label does not indicate the torque reduction value.	Recalled vehicle will have the plate replaced.	44	C0892	FL
11/12/07	R/2008/003	VOLVO TRUCK	FL/FE	TORQUE REDUCTION VALUE LABEL MISSING ON ENGINE	It has been identified that the engine information label does not indicate the torque reduction value.	Recalled vehicle will have the plate replaced.	44	C0892	FE
12/12/07	R/2007/179	PORSCHE	911 FT & 911 GT	DEFECTIVE SWITCH CONSOLE	The switch console for the PASM (Porsche Active Suspension Management) and TC Off (Traction Control) may be defective and give incorrect signals or cause the above systems to fail.	Recall the vehicles that are likely to be affected to check and where necessary replace the switch console.	40	A802	911
14/12/07	R/2007/183	NEOMAN BUS UK	A72 A74 A75 A85 A89 A90 & A91	STEERING ARM MAY CONTACT BRAKE CALLIPER	It has been identified that the possibility exists that the steering track rod arm may contact the brake calliper with the steering on lock.	Recalled vehicles will be checked for the relevant conflicting parts and if necessary will be fitted with replacement brake pads. It should be noted at this time that the foregoing represents an interim fix.	29	263903EN	A90
14/12/07	R/2007/183	NEOMAN BUS UK	A72 A74 A75 A85 A89 A90 & A91	STEERING ARM MAY CONTACT BRAKE CALLIPER	It has been identified that the possibility exists that the steering track rod arm may contact the brake calliper with the steering on lock.	Recalled vehicles will be checked for the relevant conflicting parts and if necessary will be fitted with replacement brake pads. It should be noted at this time that the foregoing represents an interim fix.	29	263903EN	A75
14/12/07	R/2007/183	NEOMAN BUS UK	A72 A74 A75 A85 A89 A90 & A91	STEERING ARM MAY CONTACT BRAKE CALLIPER	It has been identified that the possibility exists that the steering track rod arm may contact the brake calliper with the steering on lock.	Recalled vehicles will be checked for the relevant conflicting parts and if necessary will be fitted with replacement brake pads. It should be noted at this time that the foregoing represents an interim fix.	29	263903EN	A85
14/12/07	R/2007/183	NEOMAN BUS UK	A72 A74 A75 A85 A89 A90 & A91	STEERING ARM MAY CONTACT BRAKE CALLIPER	It has been identified that the possibility exists that the steering track rod arm may contact the brake calliper with the steering on lock.	Recalled vehicles will be checked for the relevant conflicting parts and if necessary will be fitted with replacement brake pads. It should be noted at this time that the foregoing represents an interim fix.	29	263903EN	A91
14/12/07	R/2007/183	NEOMAN BUS UK	A72 A74 A75 A85 A89 A90 & A91	STEERING ARM MAY CONTACT BRAKE CALLIPER	It has been identified that the possibility exists that the steering track rod arm may contact the brake calliper with the steering on lock.	Recalled vehicles will be checked for the relevant conflicting parts and if necessary will be fitted with replacement brake pads. It should be noted at this time that the foregoing represents an interim fix.	29	263903EN	A89
14/12/07	R/2007/183	NEOMAN BUS UK	A72 A74 A75 A85 A89 A90 & A91	STEERING ARM MAY CONTACT BRAKE CALLIPER	It has been identified that the possibility exists that the steering track rod arm may contact the brake calliper with the steering on lock.	Recalled vehicles will be checked for the relevant conflicting parts and if necessary will be fitted with replacement brake pads. It should be noted at this time that the foregoing represents an interim fix.	29	263903EN	A74
14/12/07	R/2007/183	NEOMAN BUS UK	A72 A74 A75 A85 A89 A90 & A91	STEERING ARM MAY CONTACT BRAKE CALLIPER	It has been identified that the possibility exists that the steering track rod arm may contact the brake calliper with the steering on lock.	Recalled vehicles will be checked for the relevant conflicting parts and if necessary will be fitted with replacement brake pads. It should be noted at this time that the foregoing represents an interim fix.	29	263903EN	A72
17/12/07	R/2008/012	MAN	TGL/TGM'S with double cab	REAR SEATBELTS MAY NOT FUNCTION CORRECTLY	The rear seat belts and lock mechanisms are not compatible and may not lock correctly	Recall affected vehicles replace seat belts and brackets and rework cladding elements at seat belts.	63	245206	TGL
17/12/07	R/2008/012	MAN	TGL/TGM'S with double cab	REAR SEATBELTS MAY NOT FUNCTION CORRECTLY	The rear seat belts and lock mechanisms are not compatible and may not lock correctly	Recall affected vehicles replace seat belts and brackets and rework cladding elements at seat belts.	63	245206	TGM
17/12/07	R/2007/171	VAUXHALL	CORSA C COMBO C & TIGRA B	ABS MAY FAIL	It is possible for moisture to enter the ABS connector/control unit. This can cause the ABS system not to function correctly and in the worst case overheating which may lead to fire.	Recall the vehicles that are likely to be affected to check the ABS control unit fit a protective cover to the control unit and seal the earth point with wax.	345634	07c043	COMBO	74037358	84035287	01/01/2003	21/11/2007
17/12/07	R/2007/171	VAUXHALL	CORSA C COMBO C & TIGRA B	ABS MAY FAIL	It is possible for moisture to enter the ABS connector/control unit. This can cause the ABS system not to function correctly and in the worst case overheating which may lead to fire.	Recall the vehicles that are likely to be affected to check the ABS control unit fit a protective cover to the control unit and seal the earth point with wax.	345634	07c043	COMBO	43000023	73027322	01/01/2003	21/11/2007
17/12/07	R/2007/171	VAUXHALL	CORSA C COMBO C & TIGRA B	ABS MAY FAIL	It is possible for moisture to enter the ABS connector/control unit. This can cause the ABS system not to function correctly and in the worst case overheating which may lead to fire.	Recall the vehicles that are likely to be affected to check the ABS control unit fit a protective cover to the control unit and seal the earth point with wax.	345634	07c043	CORSA	44000188	64352258	01/01/2003	21/11/2007
17/12/07	R/2007/171	VAUXHALL	CORSA C COMBO C & TIGRA B	ABS MAY FAIL	It is possible for moisture to enter the ABS connector/control unit. This can cause the ABS system not to function correctly and in the worst case overheating which may lead to fire.	Recall the vehicles that are likely to be affected to check the ABS control unit fit a protective cover to the control unit and seal the earth point with wax.	345634	07c043	TIGRA	5E000023	8E000983	01/01/2003	21/11/2007
17/12/07	R/2007/170	SAAB	9-3	HANDBRAKE MAY FAIL	It has been identified that due to a manufacturing deviation the handbrake cables on certain 9-3s may deform under load. Should this occur a reduced or non-existent handbrake force will ensue.	Recalled vehicles will have the handbrake cables replaced with quality assured items.	320		9-3	81100408	81105669
20/12/07	R/2007/166	VAUXHALL	Corsa D	STEERING MAY FAIL	It has been identified that due to a manufacturing deviation the base material for the telescopic tube of the intermediate steering shaft may lack the required rigidity. This may lead to breakage of the shaft which in the worst case would lead to loss of steering control.	Recalled vehicles will be fitted with a quality assured steering shaft.	6086	07-C-038	CORSA	76021542	76087940
20/12/07	R/2007/166	VAUXHALL	Corsa D	STEERING MAY FAIL	It has been identified that due to a manufacturing deviation the base material for the telescopic tube of the intermediate steering shaft may lack the required rigidity. This may lead to breakage of the shaft which in the worst case would lead to loss of steering control.	Recalled vehicles will be fitted with a quality assured steering shaft.	6086	07-C-038	CORSA	74029534	74233663
21/12/07	R/2007/187	NEOMAN BUS UK	P21 & P22	AIR BELLOW MAY CRACK	A reinforcing plate might have been omitted from the air bellow carriers during production. As a result the carrier may crack which if allowed to progress will lead to instability at the rear of the vehicle.	Recall the vehicles that are likely to be affected to check and where necessary replace the bellows carrier with a quality assured component.	2	263104	P22
21/12/07	R/2007/187	NEOMAN BUS UK	P21 & P22	AIR BELLOW MAY CRACK	A reinforcing plate might have been omitted from the air bellow carriers during production. As a result the carrier may crack which if allowed to progress will lead to instability at the rear of the vehicle.	Recall the vehicles that are likely to be affected to check and where necessary replace the bellows carrier with a quality assured component.	2	263104	P21
21/12/07	R/2008/002	RENAULT TRUCKS UK LTD	Premium dxi II and Kerax dxi II	OIL MAY LEAK FROM FILTER HOUSING	It has been identified that there exixts a sustatial risk of leakage from the engine oil filter housing.	Recalled vehicles will have the functionality of the oil sprayer ramp and supply valve checked and if necessary replace filter housing.	57		KERAX			11/05/2007	22/10/2007
21/12/07	R/2008/002	RENAULT TRUCKS UK LTD	Premium dxi II and Kerax dxi II	OIL MAY LEAK FROM FILTER HOUSING	It has been identified that there exixts a sustatial risk of leakage from the engine oil filter housing.	Recalled vehicles will have the functionality of the oil sprayer ramp and supply valve checked and if necessary replace filter housing.	57		PREMIUM RANGE			11/05/2007	22/10/2007
24/12/07	R/2007/147	PROTON	GEN-2 & SATRIA NEO	JACK MAY FAIL DURING WHEEL CHANGE	In certain loaded conditions the vehicle jack may fail causing the vehicle to drop during a wheel change operation.	Recall the vehicles that are likely to be affected to replace the existing jack with one of a new design.	4031		SATIRA
24/12/07	R/2007/147	PROTON	GEN-2 & SATRIA NEO	JACK MAY FAIL DURING WHEEL CHANGE	In certain loaded conditions the vehicle jack may fail causing the vehicle to drop during a wheel change operation.	Recall the vehicles that are likely to be affected to replace the existing jack with one of a new design.	4031		GEN-2